The 1991 Dodge Dakota has no open NHTSA recalls. Owners report 7 recurring issue clusters, led by “Transmission shifting out of park.” Dodge uses Stellantis' Oil Change Indicator — it watches engine load and duty cycle and messages when to change oil, capped at 10,000 miles or 12 months. Know your engine: the 3.6L Pentastar V6 goes 100,000 miles on plugs, while HEMI V8s carry sixteen plugs (two per cylinder) on a roughly 30,000-mile interval — that's a real cost difference at the service counter. HEMI models with MDS cylinder deactivation are especially sensitive to overdue oil.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 1991 Dodge Dakota.
POWER TRAIN
16 NHTSA complaints · 1995-08 → 2008-10
“TRANSMISSION SLIPPED INTO REVERSE FROM PARK, CAUSING ACCIDENT”
“VEHICLE WAS INSIDE THE GARAGE AND WAS IN PARK. CONSUMER HEARD A GRINDING SOUND AND A CLICK. GEAR JUMPED INTO REVERSE AND WENT BACKWARDS TOWARD THE WALL, DAMAGEING THE WALL AND THE TRUCK ITSELF”
“ON (3) OR (4) OCCASIONS THE VEHICLE HAS ROLLED FORWARD OR BACKWARDS WHILE THE GEAR WAS IN THE PARK POSITION”
POWER TRAIN
15 NHTSA complaints · 2000-06 → 2002-04
“HAD RECEIVED RECALL 00V106000. CONTACTED DEALERSHIP & SET APPOINTMENT. TOOK VEHICLE IN ON DATE GIVEN. VEHICLE HAD WORKED FINE BEFORE TAKING VEHICLE TO DEALER”
“CONSUMER RECEIVED RECALL LETTER 00V106000. CONTACTED THE DEALER, NO PARTS WERE AVAILABLE TO CORRECT THE PROBLEM”
“VEHICLE WAS RUNNING FINE BEFORE TAKING IT IN FOR MANUFACTURER'S RECALL REPAIRS. LATER ON, DEALER INFORMED CONSUMER THAT VEHICLE NEEDS A NEW TRANSMISSION”
POWER TRAIN
7 NHTSA complaints · 1995-11 → 1996-09
“AUTO TRAN: WHILE DRIVING, TRANSMISSION DOWNSHIFTED WITHOUT WARNING, RPM'S INCREASED, VEHICLE SLOWED DOWN, SPEED 65 MPH”
“INADVERTENT SHIFTING OF THE AUTOMATIC TRANSMISSION WHILE DRIVING”
“DURING VEHICLE OPERATION, THE VEHICLE DOWNSHIFTED FROM 2ND TO 1ST”
FUEL SYSTEM, GASOLINE
6 NHTSA complaints · 1995-08 → 2003-09
“2 FUEL LINES ROUTED OVER CROSS MEMBERS, HAVE BEEN RUBBING AGAINST THEM. THIS CAUSED FUEL LINES TO CRACK, RESULTING IN FUEL LEAKS”
“THE FUEL LINE RUBS AGAINST UNDERSIDE OF THE CAB, CAUSING A HOLE IN THE FUEL LINE”
“HIGH PRESSURE LINE RUBBING AGAINST THE FRAME OF THE VEHICLE CAUSING FUEL LEAKAGE”
STEERING
6 NHTSA complaints · 1995-02 → 1998-07
“STEERING PITTMAN ARM REPLACED 7 TIMES DUE TO VEHICLE WANDERING/POOR STEERING”
“POWER STEERING LOOSE, CAUSING VEHICLE TO WANDER ON ROAD”
“VEHICLE WAS PARKED IN GARAGE. NOTICED OIL LEAKING FROM THE RACK & PINION AREA”
TIRES
4 NHTSA complaints · 2000-10 → 2001-08
“WHILE DRIVING, RIGHT REAR TIRE EXPERIENCED TREAD SEPARATION, CAUSING CONSUMER TO RUN OFF THE ROAD AND CAUSING DAMAMGE TO VEHICLE, FIRESTONE AFFINITY, P215/70R15, CLAIM 46-0351-405”
“TREAD OF CONTINENTAL TIRE CAME COMPLETELY OFF THE CASING CAUSING BODY DAMAGE TO THE VEHICLE, THE SECOND TIRE BLEWOUT DAMAGING REAR QUARTER PANEL”
SERVICE BRAKES, HYDRAULIC
11 NHTSA complaints · 1995-04 → 1998-07
“BRAKE MASTER CYLINDER FAILURE, BRAKE PEDAL GOES TO THE FLOOR”
“THE TRUCK HAS ABS BRAKES AND HAS EXPERIENCED FAILURE. THE PEDAL GOES TO THE FLOOR AND HAS CAUSED AN ACCIDENT”
“THE ABS ANTI -LOCK BRAKES FAILED AT LOW SPEED, TRUCK SLID ON WET ROAD”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Change when the indicator says so — never beyond 10,000 miles or 12 months. Pentastar 3.6L: 0W-20. HEMI 5.7L: 5W-20 (0W-40 for 6.4L SRT). MDS-equipped HEMIs punish stretched oil intervals with lifter and cam wear.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate every 8,000 miles. Charger/Challenger R/T and Scat Pack: staggered-width setups can't rotate front-to-rear — budget rear tires accordingly.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect pads and rotors at every oil change. Heavy Durangos used for towing and hard-driven Chargers both run through rear pads faster than the front-pad-first rule of thumb suggests.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Keeps your vehicle running smoothly and efficiently
HEMI 5.7L: sixteen plugs roughly every 30,000 miles — check your year's manual. Pentastar 3.6L (Charger/Challenger V6, Durango V6, Journey, Grand Caravan): 100,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Grand Caravan/Journey (62TE): ATF+4 service every 60,000 miles in family duty. Charger/Challenger/Durango with the TorqueFlite 8-speed: no published normal interval, but specialists recommend service around 60,000-100,000 miles — sooner with towing.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
RWD Charger/Challenger and AWD Durango: replace rear diff fluid around 60,000 miles, sooner with towing or drag-strip duty. Limited-slip units need the friction-modifier additive.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Replace every 30,000 miles. HEMIs pull serious airflow — a clogged filter costs measurable power before it throws a code.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Inspect from 60,000 miles, replace on cracking or glazing. On the HEMI, a shredded belt can take the cooling drive with it mid-drive.
Estimated cost — typical U.S. ranges
Dealer
~$195–$235
Shop
~$135–$165
DIY
~$20–$50
DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.
Extends the life of your vehicle and improves comfort
Replace every 20,000 miles where equipped (behind the glovebox on most models). Some earlier Journeys and Avengers shipped without one — check before buying a filter.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Stellantis OAT coolant is scheduled for 10 years / 150,000 miles; shops commonly refresh by 100,000. OAT-compatible coolant only — mixing chemistries gels the system.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Test annually after year 3. Big-audio Chargers and tow-package Durangos lean on the battery hard; weak batteries surface as gremlins in the electronics before they fail to crank.
Estimated cost — typical U.S. ranges
Dealer
~$225–$390
Shop
~$160–$280
DIY
~$130–$250
Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.
Occupant deaths in fatal crashes (FARS)
226 crashes 1990–2024
How the 226 occupant deaths break down
187
driver deaths
38
passenger deaths
1
not recorded by seat
226
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 1991 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
11
complaints mentioning a crash
5
complaints mentioning a fire
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 1991 Dodge Dakota reflects Dodge's published service intervals and the Oil Change Indicator System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.