1991 Eagle Talon Recalls, Issues & Maintenance
The 1991 Eagle Talon carries 2 open NHTSA recalls — most recently covering automatic transmission and buckle assembly. No recurring owner-reported issue clusters are on file. Eagle was Chrysler's badge for other companies' cars, so maintenance follows whoever built yours. The Talon is a Mitsubishi Eclipse twin, and its 4G63 engine lives or dies by timing-belt discipline: belt, tensioner, and the small balance-shaft belt every 60,000 miles, because a snapped balance belt takes the timing belt with it. The Summit is a Mitsubishi Mirage with the same belt-era rules. The Vision is a Chrysler LH sedan, chain-driven with the 3.3 V6 and belt-driven with the 3.5. Premier and Medallion are Renault-derived and poorly documented; treat them as annual-service classics and lean on a specialist. Every figure here is decades old, so age now governs as much as mileage.
2 Open Recalls
Source: NHTSAPOWER TRAIN:AUTOMATIC TRANSMISSION
Campaign #98V069002 · Jul 4, 1998
POWER TRAIN:AUTOMATIC TRANSMISSION
Campaign #98V069002 · Jul 4, 1998
Issue: VEHICLE DESCRIPTION: PASSENGER VEHICLES. LOCKUP OF THE TRANSFER CASE CAN OCCUR DUE TO INSUFFICIENT LUBRICATION.
Risk: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Fix: DEALERS WILL INSPECT THE VEHICLES FOR ADEQUACY OF THE TRANSFER CASE OIL VOLUME, TRANSFER CASE OIL LEAKAGE, AND OPERATIONAL DEGRADATION OF THE TRANSFER CASE MECHANISM. IF OIL VOLUME IS INSUFFICIENT, THE APPROPRIATE AMOUNT OF OIL WILL BE ADDED. IF THERE IS TRANSFER CASE OIL LEAKAGE, AFFECTED COMPONENTS WILL BE REPLACED. IF THE TRANSFER CASE SHOWS OPERATIONAL DEGRADATION, THE TRANSFER CASE WILL BE REPLACED.
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Campaign #95V103003 · May 24, 1995
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Campaign #95V103003 · May 24, 1995
Issue: THE FRONT SAFETY BELT BUCKLE RELEASE BUTTONS CAN BREAK. THESE RED PLASTIC RELEASE BUTTONS ARE MARKED "PRESS." IF A BUTTON BREAKS, PIECES CAN FALL INTO THE BUCKLE ASSEMBLY CAUSING THE BUCKLE TO OPERATE IMPROPERLY.
Risk: THE SAFETY BELTS WOULD NOT PROVIDE ADEQUATE PROTECTION TO AN OCCUPANT IN A VEHICLE CRASH.
Fix: OWNERS SHOULD PROMPTLY CHECK THE CONDITION AND OPERATION OF BOTH FRONT SAFETY BELT BUCKLES AND CAREFULLY INSPECT THE RED RELEASE BUTTON FOR ANY BREAKS OR CRACKS. THEY SHOULD ENSURE THAT BOTH BUCKLES ARE OPERATING PROPERLY BY INSERTING EACH LATCH PLATE INTO ITS BUCKLE, TUGGING ON THE BELT TO MAKE SURE THE LATCH IS SECURELY LOCKED, AND THEN PRESSING THE RELEASE BUTTON. THE LATCH PLATE SHOULD POP OUT OF THE BUCKLE WHEN THE BUTTON IS PRESSED. IF EITHER RELEASE BUTTON SHOWS A SIGN OF BREAKING OR CRACKING OR IF EITHER BUCKLE FAILS TO OPERATE PROPERLY, OWNERS SHOULD PROMPTLY CONTACT THEIR AUTHORIZED DEALER TO SCHEDULE AN APPOINTMENT TO HAVE THE BUCKLE REPLACED OR REPAIRED, FREE OF CHARGE. THE MANUFACTURER IS DEVELOPING A REMEDY DESIGNED TO PREVENT FAILURE OF THE BUTTONS THAT ARE NOT CURRENTLY BROKEN.
Known issues for this vehicle
What drivers and federal regulators have officially reported about the 1991 Eagle Talon.
Reported to NHTSA
NHTSA has 114 complaints on file for the 1991 Eagle Talon (1995-01 → 2006-08). We haven't grouped them yet for this specific vehicle — for now, the full list lives on NHTSA.
Top reported components: POWER TRAIN (57) · ENGINE AND ENGINE COOLING (23) · SEAT BELTS (17)
Note: NHTSA also opened 3 defect investigation(s) on this vehicle that closed without action.
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 18, 2026. Investigation data refreshed Sep 1, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Essential maintenance
Critical for safety and preventing major damage
Oil & Filter Change
Every 3,000 miChrysler's era schedule: 7,500 miles normal, 3,000 severe. Turbo Talons should live on the severe schedule; turbos of this era cook oil. Any surviving Eagle deserves at least an annual change regardless of miles.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Timing Belt (and Balance-Shaft Belt)
Every 60,000 miTalon 4G63 (turbo and not): every 60,000 miles including tensioner, idlers, and the balance-shaft belt, the item whose failure causes most 4G63 belt disasters. Summit engines: same 60,000-mile discipline. Vision 3.5 V6: 60,000 miles on pre-1997 cars, inspect at 60 and replace by 90 on later ones, water pump with it. Vision 3.3: chain, no service. These are mostly interference engines; on a 25+ year old car, replace on age if history is unknown.
Estimated cost — typical U.S. ranges
Dealer
~$935–$1175
Shop
~$655–$825
DIY
Pro only
On interference engines, a snapped belt destroys valves. Worth doing on schedule. Bundle water pump + tensioner — labor is already there.
Annual Service Inspection
Every 7,500 miAnnual inspection of belts, hoses, cooling system, and suspension. Rubber and coolant age out on cars this old regardless of mileage.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free with any paid service. A flashlight and 10 minutes covers the basics yourself.
Brake Fluid
Every 24,000 miEvery 2 years is sound practice for this era; no published factory interval survives.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Tire Rotation
Every 7,500 miWith each oil service. AWD Talons: keep tire diameters matched to protect the driveline.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Important maintenance
Keeps your vehicle running smoothly and efficiently
Spark Plugs
Every 30,000 miConventional plugs of the era ran about 30,000 miles. No verified Eagle-specific figure survives; check the manual if you have one.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Recommended maintenance
Extends the life of your vehicle and improves comfort
Engine Coolant
Every 30,000 miGreen coolant of the era: every 2 years or 30,000 miles. Old coolant eats water pumps and radiators quietly.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Engine Air Filter
Every 30,000 miRoughly every 30,000 miles, inspected at services.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Transmission Fluid
Every 30,000 miEra automatics like fresh fluid; every 30,000 miles is the safe habit, and the Vision's 42LE needs the correct ATF+ spec. Manual gearboxes: change on condition.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Drive Belts & Hoses
Every 60,000 miInspect at every service, replace on age. On cars this old, original rubber anywhere is overdue.
Estimated cost — typical U.S. ranges
Dealer
~$195–$235
Shop
~$135–$165
DIY
~$20–$50
DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 1991 Eagle Talon reflects Eagle's published service intervals. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.