Wrench.Pro

1992 Chevrolet Suburban Recalls, Problems & Maintenance

The 1992 Chevrolet Suburban has no open NHTSA recalls. Owners report 6 recurring issue clusters, led by “Extended stopping distance with antilock brakes.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 1992 Chevrolet Suburban.

Reported to NHTSA

Extended stopping distance with antilock brakes

SERVICE BRAKES, HYDRAULIC

25 NHTSA complaints · 1995-10 → 2000-07

“WHEN APPLYING THE ABS BRAKES IN A PANIC STOP SITUATION, THERE IS AN EXTENDED AMOUNT OF BRAKING DISTANCE. CAUSE UNKNOWN. *AK”
— Owner report, NHTSA ODI #817913
“ABS BRAKING SYSTEM MALFUNCTIONS CAUSING LONG AND EXTENDED STOPPING DISTANCES.PEDAL BECOMES SOFT.THE ABS SYSTEM BRAIN HAD TO BE REPLACED BEFORE. TT *SLC”
— Owner report, NHTSA ODI #973902
“WHILE MAKING A SUDDEN STOP, THE VEHICAL EXPERIENCED EXTENDED STOPING DISTANCE, RESULTING IN AN ACCIDENT. *AK”
— Owner report, NHTSA ODI #823126

Read all complaints on NHTSA →

Brakes lock up, grab or pull to one side

SERVICE BRAKES, HYDRAULIC

32 NHTSA complaints · 1995-03 → 2000-01

“ANTI-LOCK BRAKES LOCK UP WHEN BACKING UP AND AT SLOW SPEEDS”
— Owner report, NHTSA ODI #524839
“WHILE DRIVING VEHICLE ABOUT 35 MPH THE CONSUMER TRIED TO SLOW DOWN AND THE BRAKES LOCKED UP. THE BRAKES GRABBED WHEN THE SHOULDN'T, ACCORDING TO THE CONSUMER . *AK”
— Owner report, NHTSA ODI #818496
“BRAKES WILL EITHER LOCK UP, PULL TO THE LEFT OR RIGHT OR THEY FEEL SPONGY. TT”
— Owner report, NHTSA ODI #970937

Read all complaints on NHTSA →

Brake pad, rotor and overheating complaints

SERVICE BRAKES, HYDRAULIC

9 NHTSA complaints · 1995-06 → 2001-08

“EXCESSIVE WEAR OF THE FRONT BRAKE PADS, THEY NEED REPLACING EVERY 7K MILES. TT”
— Owner report, NHTSA ODI #972019
“CONSUMER IS AT 57,000 MILES HAD TO REPLACE THE PADS ROTORS FOUR TIMES . TT”
— Owner report, NHTSA ODI #974763

Read all complaints on NHTSA →

Brake pedal travels to the floor

SERVICE BRAKES, HYDRAULIC

32 NHTSA complaints · 1995-05 → 2003-01

“WHEN APPLYING THE BRAKES THE PEDAL GOES TO THE FLOOR AND VEHICLE DID NOT STOP. DEALER REPLACED ABS. *AK”
— Owner report, NHTSA ODI #818880
“ABS BRAKES; WHEN APPLYING THE BRAKES IN NORMAL CONDITIONS, THE PEDAL GOES TO THE FLOOR, AND THE BRAKES FAILED TO STOP THE VEHICLE. PLEASE PROVIDE FURTHER DETAILS. *AK”
— Owner report, NHTSA ODI #818965
“WHEN THE BRAKES ARE APPLIED IN AN EMERGENCY STOP THE PEDAL GOES TO THE FLOOR, RESULTING IN EXTENDED STOPPING DISTANCE. THE DEALER HAS INSPECTED THE VEHICLE. *AK”
— Owner report, NHTSA ODI #820046

Read all complaints on NHTSA →

Windshield wipers operate intermittently or fail

VISIBILITY

13 NHTSA complaints · 1997-12 → 2005-02

“WHEN WINDSHIELD WIPERS ARE ACTIVATED THEY DO NOT TURN OFF UNTIL THE VEHICLE IS SHUT OFF. SOMETIMES THEY WILL STOP IN THE MIDDLE OF THE WINDSHIELD WHILE THE VEHICLE IS RUNNING. DEALER HAS BEEN CONTACTED. *AK”
— Owner report, NHTSA ODI #849996
“THIS VEHICLE HAS A FAULTY WINDSHIELD WIPER MOTOR WHICH CAUSES THE WIPERS TO WORK INTERMITTENTLY. DEALER HAS BEEN CONTACTED. *AK”
— Owner report, NHTSA ODI #836768
“THE WINDSHIELD WIPERS WILL WORK ONE WEEK AND THE NEXT WEEK THEY DON'T WORK DUE TO AN OVERHEATED CIRCUITBOARD. DEALER HAS NOT SEEN VEHICLE. *AK”
— Owner report, NHTSA ODI #830118

Read all complaints on NHTSA →

Tire tread separation and blowouts

TIRES

5 NHTSA complaints · 2000-08 → 2002-08

“CONSUMER WAS TRAVELING ON HIGHWAY AND VEHICLE STARTED TO VIBRATE. SHE WAS ABLE TO PULL OVER TO SHOULDERS, NOTICED TREAD SEPARATION AND WIRES HANGING OUT FROM TIRES. THERE WERE NO INJURIES. COOPER TIRES. *AK”
— Owner report, NHTSA ODI #879523
“TWO OF THE FIRESTONE WILDERNESS AT P255/70R16 TIRES ON THE VEHICLE WENT FLAT, WHEN TIRES WERE BROKEN DOWN TO PATCH, THE TIRES WERE SEPARATED ON THE INSIDE. *MJS”
— Owner report, NHTSA ODI #554584
“WHILE DRIVING 65MPH HEARD & FELT A BUMPING AGAINST VEHICLE. STOPPED & CHECKED VEHICLE. NOTICED TIRES WERE BLISTERED & TREAD WAS PULLING FROM THE CASING. BOTH FRONT & REAR TIRES WERE SHOWING TREAD PROBLEMS. NOT POSITIVE IF ORIGINAL TIRES AT TIME OF PURCHASE WERE USED. ALSO, ABS BR”
— Owner report, NHTSA ODI #867215

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

On 4WD models, replace transfer case fluid every 45,000 miles — sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

115 crashes 1990–2024

How the 115 occupant deaths break down

63

driver deaths

52

passenger deaths

115

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 1992 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

40

complaints mentioning a crash

7

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 1992 Chevrolet Suburban reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →