The 1993 BMW 740i has no open NHTSA recalls. Owners report 5 recurring issue clusters, led by “Driver power seat recline or movement while driving.” BMW vehicles use Condition-Based Service (CBS) — the dashboard shows each service item with its own remaining mileage and time, calculated by sensors. The schedule below shows BMW's underlying targets. BMW Ultimate Care covers the first 3 years / 36,000 miles of factory-scheduled maintenance on most new vehicles.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 1993 BMW 740i.
SEATS
4 NHTSA complaints · 2000-03 → 2003-05
“DRIVER'S SEAT ON MY 1993 BMW 740I RECLINED WHILE CAR WAS IN MOTION. SEAT BACK WENT ALL THE WAY DOWN AND WILL NOT MOVE”
“WHILE DRIVING POWER SEAT ON THE DRIVER'S SIDE KEPT MOVING FORWARD, PINNING THE DRIVER AGAINST THE STEERING WHEEL”
ENGINE AND ENGINE COOLING
2 NHTSA complaints · 2002-09 → 2003-03
“GASKETS IN ENGINE, OIL PAN, AND INTAKE MANIFOLD HAVE FAILED APPROXIMATELY 3 TIMES AFTER ORIGINALS HAD TO BE REPLACED. ENGINE SMOKED AND LEAKED OIL ONTO MANIFOLD”
“FEBRUARY 2003, THE CAR IS LEAKING OIL AGAIN”
ENGINE AND ENGINE COOLING
4 NHTSA complaints · 1998-07 → 2001-09
“NOTICED COOLANT HAD LEAKED OUT. ALSO, HOSE TO RADIATOR WAS DISCONNECTED. CLAMP STILL ON HOSE & WAS CRACKED”
“VEHICLE WAS EXPERIENCING AN ENGINE COOLANT LEAK, THE DEALER FOUND THAT THE HOSE CLAMP WAS LEAKING WHICH WAS THEN REPLACED”
AIR BAGS
2 NHTSA complaints · 2003-02 → 2003-02
“THE SRS LIGHT CAME ON IN MY VEHICLE AND I TOOK THE VEHICLE INTO THE DEALER TO HAVE IT INSPECTED. THEY TOLD ME THAT THE AIRBAG MODULE WAS DEFECTIVE AND WAS IN NEED OF REPLACEMENT AT A SIGNIFICANT COST”
“THE AIR BAG LIGHT ILLUMINATED DUE TO FAULTY MODULE”
ELECTRICAL SYSTEM
2 NHTSA complaints · 2002-04 → 2002-05
“WHILE TRAVELING ON HIGHWAY WITHOUT PRIOR WARNING SMOKE WAS COMING FROM REAR TIRE, AND VEHICLE CAUGHT ON FIRE”
“VEHICLE CAUGT FIRE AND BURNED COMPLETELY UP WITH IN MINUTES AFTER LEAVING BMW DEALERSHIP”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Replace BMW Longlife-04 (LL-04) full-synthetic oil and filter every 10,000 miles or annually — whichever the CBS system signals first. M-series engines may require shorter intervals; check the vehicle-specific iDrive screen.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Replace DOT 4 LV brake fluid every 2 years regardless of mileage. CBS triggers based on time, not miles, due to moisture absorption.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Multi-point inspection covering brakes, suspension, steering, exhaust, fluids, lighting, and underbody. CBS signals every 30,000 miles or 2 years.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free with any paid service. A flashlight and 10 minutes covers the basics yourself.
Replace engine air filter every 40,000 miles. Higher-performance N55, B58, and S58 engines should be inspected at every oil service.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
B48 (2.0L turbo) and B58 (3.0L turbo) require new spark plugs every 60,000 miles. N20/N55 engines often spec 45,000 miles. M-series typically 30,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
BMW labels the ZF 8HP automatic as 'lifetime fill,' but independent transmission specialists strongly recommend replacement every 60,000 miles. Use BMW-spec ZF Lifeguard 8 — no substitutes.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
RWD and xDrive AWD: replace rear diff fluid every 60,000 miles, sooner with M-Sport or active differential. M-cars require BMW SAF-XO synthetic.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
BMW xDrive AWD: replace transfer case fluid every 60,000 miles. Skipping this causes the most common xDrive failure — actuator stuck in 100/0 split.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
Extends the life of your vehicle and improves comfort
Replace the activated-carbon microfilter every 30,000 miles. Most BMWs have a single combined cabin/charcoal filter behind the engine bay firewall.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
BMW labels coolant as lifetime fill on most modern vehicles. Independent BMW specialists recommend replacement every 4-5 years to prevent water-pump and thermostat housing degradation.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Occupant deaths in fatal crashes (FARS)
9 crashes 1990–2024
How the 9 occupant deaths break down
7
driver deaths
2
passenger deaths
9
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 1995 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
1
complaints mentioning a crash
2
complaints mentioning a fire
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 1993 BMW 740i reflects BMW's published service intervals and the Condition-Based Service system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.