1993 Ford F-150 Recalls, Problems & Maintenance

The 1993 Ford F-150 has no open NHTSA recalls. Owners report 8 recurring issue clusters, led by “Fuel transfer between dual tanks and filler overflow.” Ford uses the Intelligent Oil-Life Monitor (IOLM) to determine when oil changes are due based on actual driving load — not just mileage. Ford's published cap is 10,000 miles or 1 year, whichever comes first. The schedule below reflects Ford's Normal service intervals; F-Series trucks and Super Duty have additional towing-specific items.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 1993 Ford F-150.

Reported to NHTSA

Fuel transfer between dual tanks and filler overflow

FUEL SYSTEM, GASOLINE

91 NHTSA complaints · 2001-07 → 2024-06

“FUEL CROSSFLOW: UNUSED FUEL FROM REAR TANK RETURNS TO FRONT TANK, CAUSING FUEL OVERFLOW AND FUEL SPILLAGE”
— Owner report, NHTSA ODI #11000866
“FUEL FROM ONE TANK TRANSFERS TO THE OTHER AND OVERFLOWS PAST THE FILL CAP”
— Owner report, NHTSA ODI #10285999
“THE SAFETY CONCERN IS THAT THE FRONT TANK IS BEING FILLED BY THE REAR TANK AND WILL OVER FILL THE FRONT TANK”
— Owner report, NHTSA ODI #10361910

Read all complaints on NHTSA →

Fuel tank leakage and corrosion

FUEL SYSTEM, GASOLINE

14 NHTSA complaints · 2001-08 → 2015-06

“REAR FUEL TANK BEGAN LEAKING, SPARE TIRE IS INSTALLED UNDER REAR FUEL TANK”
— Owner report, NHTSA ODI #10003161
“FUEL TANK ON MY 1993 FORD F150 RUSTED FROM THE INSIDE OUT AND IS LEAKING FUEL AND RUINED MY SPARE TIRE”
— Owner report, NHTSA ODI #10264875
“TOP OF GAS TANK IS CORRODED DUE TO ROAD SALT, CAUSING VEHICLE LEAK FUEL”
— Owner report, NHTSA ODI #8005797

Read all complaints on NHTSA →

Speed control (cruise control) recall repair availability

VEHICLE SPEED CONTROL

21 NHTSA complaints · 2003-10 → 2010-03

“THE CONTACT RECEIVED A SAFETY RECALL NOTICE IN AUGUST OF 2007 FOR THE VEHICLE SPEED CONTROL”
— Owner report, NHTSA ODI #10222117
“1993 FORD F-150 WITH A RECALL CONCERNING THE SPEED CONTROL FUSE HARNESS”
— Owner report, NHTSA ODI #10204986
“1993 FORD F-150 RECALL ON SPEED CONTROL SWITCH DEACTIVATION”
— Owner report, NHTSA ODI #10206064

Read all complaints on NHTSA →

Oil pan rust and oil leakage

ENGINE AND ENGINE COOLING

8 NHTSA complaints · 2001-12 → 2004-09

“CONSUMER STATED OIL WAS LEAKING OUT OF OIL PAN WHICH HAD RUSTED, THIS CAUSED OIL PAN GASKET TO BLOWOUT”
— Owner report, NHTSA ODI #8002007
“CONSUMER STATED THE OIL PAN IS RUSTING, AND OIL IS LEAKING FROM VEHICLE”
— Owner report, NHTSA ODI #8001520
“OIL PAN IS RUSTING OUT AN LEAKING OIL”
— Owner report, NHTSA ODI #10040820

Read all complaints on NHTSA →

Rear leaf spring hanger and shackle rust

SUSPENSION

7 NHTSA complaints · 2001-09 → 2005-09

“THE DESIGN OF THE REAR LEAF SPRING SUPPORT, LET WATER AND SALT COLLECT IN THE SUPPORT”
— Owner report, NHTSA ODI #10137645
“MECHANIC NOTICED THAT THE BED OF TRUCK WAS LAYING ON THE SPRINGS WHEN INSPECTING THE TRUCK FOR AN EXHAUST PROBLEM”
— Owner report, NHTSA ODI #10091825
“THE SPRING HANGERS AND SHACKLES RUSTED ON THE 1993 FORD F150”
— Owner report, NHTSA ODI #10122635

Read all complaints on NHTSA →

Transmission slipping and transfer case shifting out of gear

POWER TRAIN

8 NHTSA complaints · 2001-10 → 2024-03

“WHILE DRIVING BETWEEN 1-50 MPH WITH THE 4 WHEEL DRIVE ACTIVATED, THE TRANSFER CASE POPPED OUT OF GEAR AND WENT INTO NEUTRAL”
— Owner report, NHTSA ODI #10217812
“TRANSMISSION IS SLIPPING IN ALL GEARS AND REVERSE IS NOT WORKING AT ALL”
— Owner report, NHTSA ODI #10016630
“FORD EARLY MODEL E4OD TRANSMISSION HAS HAD MANY AND MULTIPLE PART FAILURES”
— Owner report, NHTSA ODI #10255430

Read all complaints on NHTSA →

Tire tread separation

TIRES

6 NHTSA complaints · 2001-07 → 2003-10

“WHILE DRIVING 70 MPH PASSENGER'S SIDE REAR TIRE TREAD SEPARATED”
— Owner report, NHTSA ODI #10044919
“AT 60MPH, A TIRE BLEWOUT WITH NO WARNING DUE TO TREAD SEPARATION”
— Owner report, NHTSA ODI #8012912
“THE ORIGINAL TIRES ON THE TRUCK FAILED AT 36K MILES”
— Owner report, NHTSA ODI #749366

Read all complaints on NHTSA →

Electrical smoke and fire under dash or hood

ELECTRICAL SYSTEM

7 NHTSA complaints · 2002-02 → 2015-04

“SMOKE WAS COMING FROM UNDER THE STERING COLUMN”
— Owner report, NHTSA ODI #10045751
“A HALF AN HOUR AFTER PARKING THE VEHICLE, IT CAUGHT ON FIRE”
— Owner report, NHTSA ODI #10026236
“CONSUMER STATES THAT ONE OF THE WIRES FOR THE OVERDRIVE LOCK OUT BUTTON ON THE END OF THE SHIFTER COLUMN HAD SHORTED OUT, STARTING A SMALL FIRE INSIDE THE STEERING COLUMN”
— Owner report, NHTSA ODI #8004141

Read all complaints on NHTSA →

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 7,500 mi

Replace synthetic-blend or full-synthetic Motorcraft oil per the IOLM, or every 7,500-10,000 miles. EcoBoost engines require full synthetic; Coyote 5.0L V8 specifies SAE 5W-30.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 10,000 mi

Rotate tires every 10,000 miles, or with every other oil change. F-150 4x4 owners should rotate every 5,000-7,500 miles to even out drivetrain bias wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 10,000 mi

Inspect brake pads, rotors, and brake fluid level every 10,000 miles. Front pads on F-150 and Explorer typically last 40,000-60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

Ford specifies brake fluid replacement on an inspection basis, but moisture testing every 3 years is recommended. Replace if reading exceeds 3% water content.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace the engine air filter every 30,000 miles. EcoBoost turbocharged engines are sensitive to airflow restriction — don't extend.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 150,000 mi

Ford 6R80, 10R80, and 8F transmissions use Mercon LV fluid rated 150,000 miles under normal service. Severe service (towing, plowing) drops this to 60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD models)

Every 60,000 mi

On 4x4 models, replace transfer case fluid every 60,000 miles. Use Motorcraft XL-12 — do not substitute generic transfer case fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Rear Differential Fluid

Every 100,000 mi

F-Series and Expedition: replace rear axle fluid every 100,000 miles, or 50,000 miles if towing. Limited-slip rear ends require friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs

Every 100,000 mi

Iridium spark plugs on Coyote 5.0L, EcoBoost 2.7L/3.5L, and 2.3L are rated 100,000 miles. EcoBoost engines: never exceed the interval — gap erosion causes coil failure.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Coolant

Every 50,000 mi

Motorcraft Orange (Dex-Cool compatible) coolant: first change at 100,000 miles, then every 50,000. Older trucks with Yellow Motorcraft coolant: 50,000 miles throughout.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 20,000 mi

Replace the cabin air filter every 20,000 miles. On F-150, located behind the glove box; on Escape and Explorer, accessed from the passenger footwell.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

1,062 crashes 1990–2024

How the 1,062 occupant deaths break down

841

driver deaths

217

passenger deaths

4

not recorded by seat

1,062

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 1993 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

25

complaints mentioning a crash

22

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 1993 Ford F-150 reflects Ford's published service intervals and the Intelligent Oil-Life Monitor system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.