The 1994 Mazda 626 has no open NHTSA recalls. Owners report 6 recurring issue clusters, led by “Automatic transmission failure and replacement.” Mazda's Skyactiv engines use unusually high compression ratios (13:1 to 16:1) and require strict adherence to oil intervals — extending oil life on a Skyactiv engine accelerates carbon buildup on intake valves. Mazda's published Schedule 1 (severe) covers most US driving conditions.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 1994 Mazda 626.
POWER TRAIN
104 NHTSA complaints · 1999-11 → 2018-12
“MY TRANSMISSION FAILED COMPLETELY. ACCORDING TO THE DEALER I BOUGHT IT FROM IT HAD BEEN REPLACED AT AROUND 60K MILES. NOW ITS AT 120K MILES AND IT FAILED COMPLETELY”
“VEHICLE STOPPED ON A BRIDGE AT 45 MPH. VEHICLE WAS TOWED. VEHICLE WOULD NOT PICK UP GEARS, NOR GO INTO REVERSE”
“AUTOMATIC TRANSMISSIOIN FAILURE, TWICE: ONCE AT 70000 MILES (WHICH I HAD REBUILT) THEN AGAIN AT 145000 MILES”
POWER TRAIN
34 NHTSA complaints · 2000-01 → 2018-12
“ROUGH TRANSMISSION SHIFTING THAT OCCURS ALMOST EVERY DAY WITH O/D LIGHT FLASHING. NO REPAIR SHOP IS ABLE TO FIND WHAT THE PROBLEM IS”
“I PURCHASED A 1994 MAZDA 626 WITH 72,000 MILES. AT 84,000 MILES, MY HOLD LIGHT WOULD START FLASHING ON AND OFF, WHEN THIS HAPPENED MY TRANSMISSION WAS VERY ROUGH, SHIFTED HARD”
“I OWN A 94 MAZDA 626 4 CYLINDER. IT HAS 116000 MILES AND NOW THE HOLD(O/D) LIGHT IS BLINKING, IT IS SHIFTING HARD, AND THE RPM'S ARE ACTING FUNNY BETWEEN GEARS”
SUSPENSION
3 NHTSA complaints · 2002-06 → 2003-07
“CONSUMER STATED THAT WHEN VEHICLE WAS PARKED THE SPRING SNAPPED, PUNCTURING THE FRONT DRIVER'S SIDE TIRE”
“THE RIGHT FRONT TIRE WAS PUNCTURED AS A RESULT OF A BROKEN COIL SPRING”
“CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH THE FRONT COIL SPRING. DEALER STATED THAT A COIL SPRING WAS BROKEN BUT CONSUMER HAD TO PAY FOR THE WORK”
SERVICE BRAKES, HYDRAULIC
2 NHTSA complaints · 2000-11 → 2007-08
“REAR CALIPERS WILL NOT STOP SEIZING. TRIED USING REMAN'D AND NEW WITH THE SAME RESULTS”
“THE REAR LEFT BRAKE CALIPER DID NOT RELEASE PROPERLY AFTER THE CAR WAS STARTED AND DRIVEN. THIS CAUSED THE BRAKES TO OVERHEAT WHILE DRIVING”
EXTERIOR LIGHTING
6 NHTSA complaints · 2000-06 → 2003-07
“CONSUMER STATES THAT WHILE DRIVING AT NIGHT AND WITH NO WARNING HEADLIGHTS WOULD SHUT OFF”
“CONSUMER STATES THAT WHEN PUTTING TURN SIGNAL ON HEADLIGHTS WOULD SHUT OFF WITHOUT WARNING”
“VEHICLE WAS REPAIRED UNDER RECALL FOR HEADLIGHT WIRING THAT RAN THROUGH TURN SIGNAL LEVER. IT FAILED WHERE IT WAS SOLDERED TO HEADLIGHT SWITCH”
ENGINE AND ENGINE COOLING
11 NHTSA complaints · 1999-10 → 2002-05
“WHEN TRAVELING AT HIGHWAY SPEEDS VEHICLE WILLCUT OFF WITHOUT PRIOR WARNING. RPM GOES DOWN TO ZERO”
“WHILE DRIVING 40-55 MPH VEHICLE COMPLETELY SHUT DOWN. THIS HAS HAPPENED TWICE”
“THICK FILM ON IGNITION COMPONENT CAUSED DISTRIBUTOR TO FAIL. VEHICLE T STALLED”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Replace 0W-20 full-synthetic oil every 5,000 miles under Schedule 1. Schedule 2 (highway-only): 7,500 miles. Turbo engines: 5,000 miles regardless of schedule.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 7,500 miles; every 5,000 on AWD models, where the front-biased coupling wears tires unevenly.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect brake pads, rotors, and parking brake at every oil change. Front pads typically last 35,000-50,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Replace DOT 3 brake fluid every 30,000 miles or 36 months.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Replace engine air filter every 30,000 miles. Skyactiv-G direct injection is sensitive to airflow restriction — inspect at every oil change.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Replace ATF every 60,000 miles severe / 100,000 normal. Use Mazda FZ ATF — substitutes cause harsh 1-2 shifts and torque converter shudder.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Iridium spark plugs every 60,000 miles on Skyactiv-G 2.0L and 2.5L; 45,000 miles on the 2.5L Turbo.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Mazda FL-22 (yellow): first change at 120,000 miles or 10 years, then every 60,000. Do not substitute — silicate-free formula prevents water pump damage on Skyactiv engines.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
On AWD models, replace transfer case fluid and rear differential fluid every 60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
Extends the life of your vehicle and improves comfort
Replace cabin air filter every 15,000 miles. On most models it sits behind the glove box.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Occupant deaths in fatal crashes (FARS)
137 crashes 1990–2024
How the 137 occupant deaths break down
88
driver deaths
49
passenger deaths
137
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 1994 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
19
complaints mentioning a crash
7
complaints mentioning a fire
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 1994 Mazda 626 reflects Mazda's published service intervals. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.