The 1995 Ford Bronco has no open NHTSA recalls. Owners report 6 recurring issue clusters, led by “Brake rotor and pad wear with vibration or pull.” Ford uses the Intelligent Oil-Life Monitor (IOLM) to determine when oil changes are due based on actual driving load — not just mileage. Ford's published cap is 10,000 miles or 1 year, whichever comes first. The schedule below reflects Ford's Normal service intervals; F-Series trucks and Super Duty have additional towing-specific items.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 1995 Ford Bronco.
SERVICE BRAKES, HYDRAULIC
15 NHTSA complaints · 1995-05 → 1997-07
“COMPOSITION OF FRONT PADS IS RESULTING IN WARPING ROTORS. THIS CAUSES EXCESSIVE VIBRATION AND PULLING WHEN BRAKING. PLEASE DESCRIBE DETAILS. TT”
“VEHICLE SHUDDERS SEVERELY AND PULLS TO SIDE WHEN BRAKING. *DSH”
“VERY VIOLENT SHAKING IN FRONT END WHEN SLOWING DOWN GRADUALLY TO A STOP RELEASE BRAKES AND IT SUBSIDES”
POWER TRAIN
8 NHTSA complaints · 1995-05 → 2002-07
“COMPLETE FAILURE OF REAR DIFFERENTIALS - ALL INTERNAL PARTS DESTROYED. FORD DEALER THAT REPAIRED VEHICLE GAVE NO REASON FOR FAILURE. NO EXTERNAL DAMAGE. VEHICLE USED NORMALLY - NO OFF-ROAD OR HEAVY TRAILER USE. CONTACTED FORD VICE PRESIDENT, NOT COMPENSATION OFFERED. PA”
“2ND TIME 4- WHEEL DRIVE HAS FAILED TO ENGAGE, 1ST TIME HUB WAS PROBLEM, LOUD NOISES COMING FROM TRANSER CASE. AXEL IS NOT BENT OR TWISTED. LOUD WINDING NOISE, EVEN AFTER DISENGAGE AUTO HUBS. LOUD "CLUNK" OCCURRED JUST PRIOR TO FAILURE. FAILURE OCCURRED AS VEHICLE WAS AS”
“TRANSMISSION DOES NOT GET INTO GEAR QUICKLY ENOUGH. TRANSMISSION WOULD GO INTO DRIVE OR REVERSE. CONTACTED DEALER, AND DEALER CHANGED TRANSMISSION. PROBLEM STILL OCCURS.*AK”
VEHICLE SPEED CONTROL
11 NHTSA complaints · 2005-07 → 2015-09
“THE CONTACT OWNED A 1995 FORD BRONCO. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN IT ENGULFED INTO FLAME AND BURNED DOWN HIS HOME. THE CONTACT ALSO STATED THAT THE VEHICLE WAS COMPLETELY DESTROYED. IN ADDITION, AN INVESTIGATOR DETERMINED THAT THE FIRE WAS CAUSED”
“THE CONTACT OWNS A 1995 FORD BRONCO. THE CONTACT STATED THAT THE VEHICLE WAS PARKED FOR THREE DAYS AND THEN CAUGHT FIRE. THE FIRE DEPARTMENT STATED THAT THE FAILURE WAS CAUSED BY THE CRUISE CONTROL MODULES. NHTSA CAMPAIGN ID NUMBER: 05V388000 (VEHICLE SPEED CONTROL) WAS”
“DT: THE CONSUMER STATES THAT T 1995 FORD BRONCO CAUGHT ON FIRE AND BURNT ON JULY 14, 2005. THE VEHICLE HAD BEEN DRIVEN TO WORK. THE VEHICLE WAS PARKED AND TURNED OFF. THE VEHICLE HAD BEEN PARKED FOR ABOUT ONE HOUR AND A HALF. THE DRIVER HEARD A LOUD POPPING SOUND AND SA”
ELECTRICAL SYSTEM
5 NHTSA complaints · 2000-10 → 2011-06
“THE VEHICLE WAS PARKED WHEN ALL OF A SUDDEN THE ENGINE COMPARTMENT CAUGHT ON FIRE. RESULTS SHOWED THAT THERE WAS AN ELECTRICAL SHORTAGE IN THE ENGINE. *JB *BF”
“VEHICLE CAUGHT ON FIRE WHILE PARKED IN PARKING LOT WITH ENGINE OFF. LOCAL FIRE DEPARTMENT ARRIVED TO EXTINGUISH THE FIRE. FIRE DEPARTMENT BELIEVED THAT FIRE WAS DUE TO AN ELECTRICAL SHORTAGE UNDER HOOD. MANUFACTURER NOTIFIED, AND INFORMED THAT VEHICLE WAS OUT OF ITS WAR”
“THIS VEHICLE CAUGHT FIRE IN MY DRIVEWAY DURING THE NIGHT AFTER SITTING FOR OVER 8 HOURS. BY THE TIME THE FIRE DEPARTMENT AND POLICE CAME AND WOKE ME UP IT WAS TOTALLY DESTROYED AS WELL AS THE BOAT SITTING NEXT TO IT AND PART OF MY BRAND NEW HOUSE. THE FIRE DESTROYED THE”
SERVICE BRAKES, HYDRAULIC
14 NHTSA complaints · 1995-04 → 2000-10
“WHILE DRIVING THE VEHICLE THE ABS BRAKES GRIND AND WHEN TRYING TO SLOW DOWN, THEN BRAKES GO ALL THE WAY TO THE FLOOR. VEHICLE WILL NOT STOP. *AK”
“WHILE DRIVING IN TOWN TRAVELING 25MPH WENT TO APPLY BRAKES. THEY MADE A FUNNY NOISE, AND PEDAL WENT STRAIGHT TO THE FLOOR.*AK”
“ABS BRAKE SYSTEM FAILED 4 TIMES, ONCE RESULTING IN A COLLISION”
STEERING
6 NHTSA complaints · 1995-01 → 2010-05
“TL*THE CONTACT OWNS A 1995 FORD BRONCO. WHILE DRIVING APPROXIMATELY 40 TO 45 MPH, THE VEHICLE WOULD CONTINUE TO MOVE TO THE LEFT. THE CONTACT HAD TO HOLD BOTH HANDS ON THE STEERING WHEEL TO AVOID A CRASH. THE CONTACT ALSO HEARD A NOISE IN THE STEERING WHEEL WHILE DRIVIN”
“(FRONT ALIGNMENT) THE VECHILE WANDERS ON THE HIGHWAY. PLEASE DESCRIBE. *AK”
“100 MILES INTO THE VEHICLE IT STARTED TO PULL TO THE LEFT. TT”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Replace synthetic-blend or full-synthetic Motorcraft oil per the IOLM, or every 7,500-10,000 miles. EcoBoost engines require full synthetic; Coyote 5.0L V8 specifies SAE 5W-30.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 10,000 miles, or with every other oil change. F-150 4x4 owners should rotate every 5,000-7,500 miles to even out drivetrain bias wear.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect brake pads, rotors, and brake fluid level every 10,000 miles. Front pads on F-150 and Explorer typically last 40,000-60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Ford specifies brake fluid replacement on an inspection basis, but moisture testing every 3 years is recommended. Replace if reading exceeds 3% water content.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Replace the engine air filter every 30,000 miles. EcoBoost turbocharged engines are sensitive to airflow restriction — don't extend.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Ford 6R80, 10R80, and 8F transmissions use Mercon LV fluid rated 150,000 miles under normal service. Severe service (towing, plowing) drops this to 60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
On 4x4 models, replace transfer case fluid every 60,000 miles. Use Motorcraft XL-12 — do not substitute generic transfer case fluid.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
F-Series and Expedition: replace rear axle fluid every 100,000 miles, or 50,000 miles if towing. Limited-slip rear ends require friction-modifier additive.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Iridium spark plugs on Coyote 5.0L, EcoBoost 2.7L/3.5L, and 2.3L are rated 100,000 miles. EcoBoost engines: never exceed the interval — gap erosion causes coil failure.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Motorcraft Orange (Dex-Cool compatible) coolant: first change at 100,000 miles, then every 50,000. Older trucks with Yellow Motorcraft coolant: 50,000 miles throughout.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Extends the life of your vehicle and improves comfort
Replace the cabin air filter every 20,000 miles. On F-150, located behind the glove box; on Escape and Explorer, accessed from the passenger footwell.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Occupant deaths in fatal crashes (FARS)
62 crashes 1990–2024
How the 62 occupant deaths break down
38
driver deaths
24
passenger deaths
62
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 1995 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
9
complaints mentioning a crash
18
complaints mentioning a fire
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 1995 Ford Bronco reflects Ford's published service intervals and the Intelligent Oil-Life Monitor system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.