1996 Honda Passport Recalls, Problems & Maintenance

The 1996 Honda Passport has no open NHTSA recalls. Owners report 6 recurring issue clusters, led by “Frame corrosion and rust perforation.” Honda vehicles use the Maintenance Minder system — your dashboard displays a Code A (oil change) or Code B (oil change plus inspections) along with sub-codes 1-6 for additional services. Intervals adjust based on how you drive. The schedule below reflects Honda's underlying targets.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 1996 Honda Passport.

Reported to NHTSA

Frame corrosion and rust perforation

STRUCTURE

12 NHTSA complaints · 2010-07 → 2015-07

“SEVERE FRAME RUST NEAR THE REAR OF THE VEHICLE. AREAS OF THE BOX FRAME AROUND THE RIGHT REAR SHOCK MOUNT ARE COMPLETELY MISSING AND FALLING OFF DUE TO RUST”
— Owner report, NHTSA ODI #10345059
“THIS VEHICLE IS EXPERIENCING EXTREME FRAME CORROSION OF BOTH THE FORWARD AND REAR FRAME MEMBER”
— Owner report, NHTSA ODI #10440544
“THE CONTACT STATED AFTER HAVING HIS VEHICLE SERVICED FOR ROUTINE MAINTENANCE HE WAS ADVISED THAT THE FRAME WAS SEVERELY COVERED WITH RUST”
— Owner report, NHTSA ODI #10432302

Read all complaints on NHTSA →

Engine oil consumption and oil leaks

ENGINE AND ENGINE COOLING

3 NHTSA complaints · 2002-02 → 2012-04

“CUSTOMER STATES THE VEHICLE IS CONSUMING A TREMENDOUS AMOUNT OF OIL, OIL DRIPPING FROM TAIL PIPE, AND ON SEVERAL OCCASIONS THE ENGINE WOULD RUN ROUGH AND MAKE A KNOCKING NOISE”
— Owner report, NHTSA ODI #564243
“BEARINGS FAIL, SEALS FAIL, LASH ADJUSTERS FAIL, EXCESSIVE OIL CONSUMPTION, POORLY DESIGNED OIL CIRCULATION SYSTEM”
— Owner report, NHTSA ODI #10455984
“THE VEHICLE LEAKED OIL FROM UNDERNEATH THE VEHICLE FROM THE OIL PAN”
— Owner report, NHTSA ODI #10021668

Read all complaints on NHTSA →

Hard power steering and power steering leaks

STEERING

3 NHTSA complaints · 1996-10 → 1996-10

“POWER STEERING LEAKS AND IS HARD TO TURN”
— Owner report, NHTSA ODI #510485
“PURCHASED CAR NEW, CAN'T TURN THE STEERING WHEEL AND IT MAKES NOISE”
— Owner report, NHTSA ODI #803276

Read all complaints on NHTSA →

Air bags not deploying in frontal collisions

AIR BAGS

6 NHTSA complaints · 1997-03 → 2006-08

“DURING FRONTAL IMPACT 30 TO 35 MPH, THE DRIVER'S AND PASSENGER'S SIDE AIR BAGS DID NOT DEPLOY, RESULTIN GIN INJURIES”
— Owner report, NHTSA ODI #821892
“UPON IMPACT, DURING FRONTAL CRASH AT APPROX, 40MPH, 12:00 ON FRONT BUMPER, DUAL AIRBAGS FAILED TO DEPLOY, DRIVER SUSTAINED BACK INJURY”
— Owner report, NHTSA ODI #810256
“NO DEPLOYMENT OF AIRBAG DURING COLLISION, CAUSING INJURIES”
— Owner report, NHTSA ODI #523646

Read all complaints on NHTSA →

Sudden acceleration and high idle speed

VEHICLE SPEED CONTROL

2 NHTSA complaints · 1999-09 → 2000-08

“WHILE DRIVING AT 60 MPH VEHICLE SUDDENLY ACCELERATED UP TO 90 MPH, CAUSING LOSS OF CONTROL”
— Owner report, NHTSA ODI #847157
“INTERMITTENTLY VEHICLE IDLES AT 2400-2600 RPMS AND WILL ACCELERATE SUDDENLY”
— Owner report, NHTSA ODI #867276

Read all complaints on NHTSA →

Brake and antilock brake system failure

SERVICE BRAKES, HYDRAULIC

3 NHTSA complaints · 1996-11 → 1997-09

“POOR ABS BRAKE PERFORMANCE, THE BRAKE PEDAL WENT TO THE FLOOR AND COMPLETE BRAKE FAILURE WAS EXPERIENCED”
— Owner report, NHTSA ODI #804832
“WHILE DRIVING BRAKING SYSTEM IS FAILING, CAUSING COMPUTER TO SHUT DOWN THE VEHICLE”
— Owner report, NHTSA ODI #816067

Read all complaints on NHTSA →

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (Code A)

Every 7,500 mi

Replace 0W-20 full-synthetic oil and filter. The Maintenance Minder triggers Code A between 7,500 and 10,000 miles depending on driving conditions.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation (Sub-code 1)

Every 7,500 mi

Rotate tires front-to-back to even out wear. Honda triggers Sub-code 1 alongside every other oil change.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection (Code B)

Every 15,000 mi

Inspect brake pads, rotors, and parking brake. Code B includes a multi-point inspection of brakes, suspension, and fluids.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid (Sub-code 5)

Every 45,000 mi

Replace DOT 3 brake fluid every 3 years regardless of mileage to prevent moisture absorption and corrosion of ABS components.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Automatic Transmission / CVT Fluid (Sub-code 3)

Every 30,000 mi

Replace ATF or CVT fluid. Honda CVT models (Civic, HR-V, Accord LX) use Honda HCF-2 — do not substitute. The Maintenance Minder triggers earlier under heavy stop-and-go.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Rear Differential Fluid (AWD models, Sub-code 5)

Every 30,000 mi

AWD CR-V, Pilot, Passport, Ridgeline: replace rear diff fluid every 30,000 miles, sooner if towing.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Engine Air Filter (Sub-code 4)

Every 30,000 mi

Replace the engine air filter every 30,000 miles. Honda uses a long-life cellulose element on most port-injected engines.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Spark Plugs (Sub-code 6)

Every 105,000 mi

Honda uses iridium-tipped plugs rated for 100,000+ miles. Replace at 105,000 miles or whenever Sub-code 6 displays.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Coolant (Sub-code 5)

Every 60,000 mi

Honda Long-Life Type 2 (blue) coolant: first change at 120,000 miles, then every 60,000 miles. Do not mix with other coolant types.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter (Sub-code 3)

Every 15,000 mi

Replace the cabin air filter — accessible behind the glove box on most Hondas. Honda recommends 15,000 miles in dusty conditions, longer in clean climates.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Valve Clearance Adjustment (Sub-code 6)

Every 105,000 mi

Inspect and adjust valve clearances at 105,000 miles. Critical on K-series and L-series engines to prevent valve recession.

Estimated cost — typical U.S. ranges

Dealer

~$495–$535

Shop

~$345–$375

DIY

Pro only

Mechanical-bucket valvetrains (many Honda 4-cyls, older Toyotas) need this. Hydraulic lifters don't. Shop work — feeler-gauge precision required.

Timing Chain — No Replacement

On condition / lifetime

Modern Honda engines (K-series, L-series, R-series, plus all Earth Dreams 1.5T and 2.0T) use a timing chain designed to last the life of the engine. No scheduled replacement.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Pro only

Timing chains are normally lifetime. Listen for rattle on cold start — that's the actionable signal. Replacement is major work, quote separately.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

55 crashes 1990–2024

How the 55 occupant deaths break down

42

driver deaths

13

passenger deaths

55

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 1997 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

8

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 1996 Honda Passport reflects Honda's published service intervals and the Maintenance Minder system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.