The 1997 Chevrolet C/K Pickup has no open NHTSA recalls. Owners report 7 recurring issue clusters, led by “Erratic power steering assist and steering jerk.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 1997 Chevrolet C/K Pickup.
STEERING
26 NHTSA complaints · 1999-07 → 2009-09
“THE POWER STEERING ASSIST IS ERRATIC”
“THE PROBLEM STARTED WITH WHAT SEEMED LIKE SLACK AND AN OCCASIONAL PHANTOM JERK”
“REDUCED STEERING EFFORT WHILE DRIVING. FEELS LIKE YOU HAVE NO CONTROL OVER THE STEERING, LIKE THERE IS NO RESISTANCE IN THE WHEEL”
LATCHES/LOCKS/LINKAGES
4 NHTSA complaints · 2003-03 → 2005-11
“DRIVER'S SIDE DOOR HANDLE BROKE OFF AT 35,000 MILES”
“BOTH OF THESE TRUCKS HAVE HAD SEVERAL REPLACEMENT INTERIOR DOOR HANDLES INSTALLED OVER THE YEARS”
“EVENTUALLY THE DOOR HANDLE WOULD NO LONGER OPEN THE DOOR”
ENGINE AND ENGINE COOLING
3 NHTSA complaints · 2003-05 → 2005-03
“ENGINE COOLANT LEAK FROM THE INTAKE MANIFOLD AREA”
“THE QUICK DISCONNECT HEATER HOSE FITTING SCREWED INTO THE INTAKE MANIFOLD OF VORTEC 4.3, 5.0, 5.7 ENGINES 1996--2000”
“FAILURE CAUSES ENGINE OVERHEATING THAT CAN BE A HAZARD WHILE VEHICLE IS IN USE”
VISIBILITY
46 NHTSA complaints · 1999-09 → 2012-05
“WINDSHIELD WIPER MOTOR FAILS TO OPERATE. WORKS SOMETIME AND ALL OF A SUDDEN STOPS WORKING”
“THE WINDSHIELD WIPERS ON MY 1997 CHEVROLET C1500 PICKUP TRUCK WILL STOP WORKING WHILE I AM DRIVING. THIS HAS HAPPENED SEVERAL TIMES”
“RECENTLY HAD WIPERS FAIL DURING HEAVY STORM WHILE ON FREEWAY. NEARLY CAUSED CRASH. CONDITION IS INTERMITTENT”
SERVICE BRAKES, HYDRAULIC
7 NHTSA complaints · 1998-06 → 2009-01
“ANTI LOCK BRAKES ENGAGE AT SLOW SPEEDS (LESS THAN 5 MPH) ON DRY PAVEMENT. VEHICLE STOPPING DISTANCE WAS INCREASED CAUSING LOW SPEED COLLISION”
“EA94038, ABS BRAKING SYSTEM FAILURE; WHEN APPLYING BRAKES ON ANY TYPE OF ROAD SURFACE, DURING NORMAL BRAKING, THERE IS A VIBRATION IN THE PEDAL, THE TRUCK SHAKES AND MORE BRAKING DISTANCE IS REQUIRED”
“WHEN APPLYING BRAKES ABS WOULD ENGAGE AND FORCE THE BRAKE PEDAL TO BACK UP INTERMITTENTLY”
FUEL SYSTEM, GASOLINE
3 NHTSA complaints · 1999-08 → 2005-07
“THE FUEL PUMP WAS REPLACED COMPLETELY BECAUSE THE CONECTORS INSIDE THE FUEL TANK HAD OVERHEATED, CAUSING THE PUMP AND TRUCK TO FALL”
“WHILE DRIVING AND WITHOUT WARNING VEHICLE CAME TO A COMPLETE STOP”
“THE CONSUMER'S SON IN-LAW INSPECTED THE VEHICLE AND FOUND BURNED WIRES THAT HAD FALLEN OFF AND WENT DOWN IN THE FUEL TANK”
AIR BAGS
3 NHTSA complaints · 2002-06 → 2009-05
“VEHICLE LEFT THE ROAD AND HIT A TREE HEAD ON AND AIR BAGS DID NOT DEPLOY”
“AIR BAGS FAILED TO DEPLOY UNPON IMPACT ON A TREE”
“SHE T-BONED HIM ON DRIVER'S SIDE DOOR, AND DRIVER'S SIDE AIRBAG DIDN' T DEPLOY”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
On 4WD models, replace transfer case fluid every 45,000 miles — sooner if towing or off-roading. Use GM Auto-Trak II fluid.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Extends the life of your vehicle and improves comfort
Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Occupant deaths in fatal crashes (FARS)
1,328 crashes 1990–2024
How the 1,328 occupant deaths break down
987
driver deaths
336
passenger deaths
5
not recorded by seat
1,328
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 1996 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
4
complaints mentioning a crash
0
complaints mentioning a fire
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 1997 Chevrolet C/K Pickup reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.