The 1997 Eagle Talon carries 4 open NHTSA recalls — most recently covering fuel pump and lower ball joint. Owners report 4 recurring issue clusters, led by “Transfer case leakage and lockup.” Eagle was Chrysler's badge for other companies' cars, so maintenance follows whoever built yours. The Talon is a Mitsubishi Eclipse twin, and its 4G63 engine lives or dies by timing-belt discipline: belt, tensioner, and the small balance-shaft belt every 60,000 miles, because a snapped balance belt takes the timing belt with it. The Summit is a Mitsubishi Mirage with the same belt-era rules. The Vision is a Chrysler LH sedan, chain-driven with the 3.3 V6 and belt-driven with the 3.5. Premier and Medallion are Renault-derived and poorly documented; treat them as annual-service classics and lean on a specialist. Every figure here is decades old, so age now governs as much as mileage.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Campaign #07E055000 · Jul 26, 2007
Issue: CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.
Risk: IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.
Fix: AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Campaign #00V421002 · Dec 18, 2000
Issue: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.
Risk: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.
Fix: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.
POWER TRAIN:AUTOMATIC TRANSMISSION
Campaign #98V069002 · Jul 4, 1998
Issue: VEHICLE DESCRIPTION: PASSENGER VEHICLES. LOCKUP OF THE TRANSFER CASE CAN OCCUR DUE TO INSUFFICIENT LUBRICATION.
Risk: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Fix: DEALERS WILL INSPECT THE VEHICLES FOR ADEQUACY OF THE TRANSFER CASE OIL VOLUME, TRANSFER CASE OIL LEAKAGE, AND OPERATIONAL DEGRADATION OF THE TRANSFER CASE MECHANISM. IF OIL VOLUME IS INSUFFICIENT, THE APPROPRIATE AMOUNT OF OIL WILL BE ADDED. IF THERE IS TRANSFER CASE OIL LEAKAGE, AFFECTED COMPONENTS WILL BE REPLACED. IF THE TRANSFER CASE SHOWS OPERATIONAL DEGRADATION, THE TRANSFER CASE WILL BE REPLACED.
SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
Campaign #97V081002 · Aug 8, 1997
Issue: THE HEADREST GUIDE BRACKET WAS IMPROPERLY WELDED TO THE SEAT BACK FRAME ON THE PASSENGER SIDE SEAT BACK ASSEMBLIES ONLY.
Risk: THE HEADREST SUPPORT BRACKET CAN BREAK, INCREASING THE RISK OF PERSONAL INJURY.
Fix: DEALERS WILL REPLACE THE PASSENGER SEAT BACK ASSEMBLY WITH A NEW ASSEMBLY.
What drivers and federal regulators have officially reported about the 1997 Eagle Talon.
POWER TRAIN
6 NHTSA complaints · 1998-01 → 2009-03
“THE LEAK ON THE YOKE OF THE TRANSFER CASE ALLOWS ENOUGH OF THE GEAR LUBRICANT IN THE TRANSFER CASE TO SEEP OUT THAT IT WILL EVENTUALLY HAVE NO LUBRICANT AND WILL SEIZE”
“THERE IS OIL LEAKING AND THE TRANSFER CASE LOCKS UP, MAKING IT IMPOSSIBLE TO DRIVE THE CAR, THE WHEELS WILL NOT BUDGE”
“CONSUMER STATED THAT TRANSMISSION FLUID IS LEAKING FROM THE TRANSFER CASE”
POWER TRAIN
3 NHTSA complaints · 2004-11 → 2009-03
“A RECALL FOR THE TRANSFER CASE WAS ISSUED. THE CONSUMER VEHICLE IDENTIFICATION NUMBER WAS INCLUDED, HOWEVER THE DEALER REFUSED TO REPAIR THE VEHICLE”
“DAIMLER CHYSLER REFUSES TO ACKNOWLEDGNE HTSA RECALL CAMPAIGN 98V069002”
SUSPENSION
4 NHTSA complaints · 2001-07 → 2004-03
“A MECHANIC EXAMINED VEHICLE AND DETERMINED THAT FRONT/RIGHT BALL JOINT HAD FAILED, AND FRONT/ LEFT BALL JOINT WAS LOOSE”
“DEALER WAS UNABLE TO COMPLETE WORK BECAUSE PARTS WERE UNAVAILABLE UNTIL FURTHER NOTICE”
“THE MECHANIC REPLACED THE REAR LOWER BALL JOINTS DUE TO WORN PARTS”
ENGINE AND ENGINE COOLING
2 NHTSA complaints · 2000-12 → 2004-06
“THE FAILURE WAS THE CRANKSHAFT THAT HAD CONSIDERABLE FRON END PLAY”
“IT IS PHYSICALLY MOVABLE BY HAND LEFT AND RIGHT AND UP AND DOWN INSTEAD OF BEING STATIONARY”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 1, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Chrysler's era schedule: 7,500 miles normal, 3,000 severe. Turbo Talons should live on the severe schedule; turbos of this era cook oil. Any surviving Eagle deserves at least an annual change regardless of miles.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Talon 4G63 (turbo and not): every 60,000 miles including tensioner, idlers, and the balance-shaft belt, the item whose failure causes most 4G63 belt disasters. Summit engines: same 60,000-mile discipline. Vision 3.5 V6: 60,000 miles on pre-1997 cars, inspect at 60 and replace by 90 on later ones, water pump with it. Vision 3.3: chain, no service. These are mostly interference engines; on a 25+ year old car, replace on age if history is unknown.
Estimated cost — typical U.S. ranges
Dealer
~$935–$1175
Shop
~$655–$825
DIY
Pro only
On interference engines, a snapped belt destroys valves. Worth doing on schedule. Bundle water pump + tensioner — labor is already there.
Annual inspection of belts, hoses, cooling system, and suspension. Rubber and coolant age out on cars this old regardless of mileage.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free with any paid service. A flashlight and 10 minutes covers the basics yourself.
Every 2 years is sound practice for this era; no published factory interval survives.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
With each oil service. AWD Talons: keep tire diameters matched to protect the driveline.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Keeps your vehicle running smoothly and efficiently
Conventional plugs of the era ran about 30,000 miles. No verified Eagle-specific figure survives; check the manual if you have one.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Extends the life of your vehicle and improves comfort
Green coolant of the era: every 2 years or 30,000 miles. Old coolant eats water pumps and radiators quietly.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Roughly every 30,000 miles, inspected at services.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Era automatics like fresh fluid; every 30,000 miles is the safe habit, and the Vision's 42LE needs the correct ATF+ spec. Manual gearboxes: change on condition.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Inspect at every service, replace on age. On cars this old, original rubber anywhere is overdue.
Estimated cost — typical U.S. ranges
Dealer
~$195–$235
Shop
~$135–$165
DIY
~$20–$50
DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 1997 Eagle Talon reflects Eagle's published service intervals. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.