The 1997 Ford Aerostar has no open NHTSA recalls. Owners report 6 recurring issue clusters, led by “Accelerator cable and throttle control failure.” Ford uses the Intelligent Oil-Life Monitor (IOLM) to determine when oil changes are due based on actual driving load — not just mileage. Ford's published cap is 10,000 miles or 1 year, whichever comes first. The schedule below reflects Ford's Normal service intervals; F-Series trucks and Super Duty have additional towing-specific items.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 1997 Ford Aerostar.
VEHICLE SPEED CONTROL
9 NHTSA complaints · 1997-11 → 2010-08
“VEHICLE WAS BROUGHT UP TO 65 MPH ON INTERSTATE HIGHWAY AND PLACED UNDER CRUISE CONTROL”
“CONSUMER WAS TURNING INTO A DRIVEWAY OFF OF A SMALL STREET, APPLIED BRAKES, AND THE VEHICLE SUDDENLY TOOK OFF ON ITS OWN”
“WHEN ACCELERATING CONSUMER HAD TO DEPRESS THE GAS PEDAL SEVERAL TIMES TO GET THE VEHICLE TO MOVE”
WHEELS
5 NHTSA complaints · 2000-08 → 2009-06
“WHILE LOOKING WHEEL OVER NOTICED RIM WITH CRACK”
“CONSUMER NOTICED THAT REAR DRIVER'S SIDE RIM SPOKES ARE CRACKED”
“CONSUMER'S HUSBAND DISCOVERED THAT ONE OF THE RIMS HAD CRACKED IN THREE PLACES”
SUSPENSION
3 NHTSA complaints · 2000-09 → 2002-03
“WHILE DRIVING THE RIGHT FRONT WHEEL BEARING FAILED, CAUSING DAMAGE TO THE FRONT SPINDLE ASSEMBLY, BRAKE ROTOR, CALIPER AND BALL JOINTS”
“WHILE DRIVING MY VEHICLE THE RIGHT FRONT WHEEL BEARING EXPERIENCED A CATASTROPHIC FAILURE”
“RIGHT FRONT SPINDLE AND KNUCKLE ASSEMBLY MALFUNCTIONED”
POWER TRAIN
3 NHTSA complaints · 1999-08 → 2003-04
“RECEIVED RECALL NOTICE #97V204000”
“VEHICLE WILL NOT RUN PROPERLY DUE TO THE TRANSFER CASE BEING DEFECTIVE”
“THE VEHICLE EXPERIENCED THE PROBLEM AS STATED IN RECALL # 97 V 204 000, HOWEVER THE VEHICLE IDENTIFICATION WAS NOT INCLUDED IN THE RECALL”
SERVICE BRAKES, HYDRAULIC
3 NHTSA complaints · 1998-09 → 2001-11
“CONSUMER EXPERIENCING EXCESSIVE WEAR OF THE FRONT BRAKE PADS AND SHOES/ ROTORS DUE A MALFUNCTION WITHIN THE REAR BRAKE ADJUSTERS”
“WHEN TURNING OR APPLYING BRAKES THEY WOULD MAKE LOUD NOISES FROM THE REAR WHEELS”
“FORD RECOMMENDS INCORRECT ADJUSTMENT OF REAR BRAKES, WHICH CAUSES OVERHEATING OF DRUMS AND EVENTUAL FAILURE OF AXLE SEALS, AXLE BEARINGS, AND TIRE ON THE RIM ATTACHED TO THE BRAKE DRUM”
ELECTRICAL SYSTEM
7 NHTSA complaints · 1999-05 → 2020-10
“CONSUMER HAS CONTACTED THE DEALER 4 TIMES REGARDING RECALL 99V029000, IGNITION SWITCH SHORT”
“VEHICLE DENIED RECALL WORK DUE TO LACK OF PARTS (99V-029) IGNITION SWITCH”
“MY 1997 FORD AERO STAR VAN PRODUCED A PUFF OF SMOKE FROM THE STEERING COLUMN NEAR THE IGNITION SWITCH”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Replace synthetic-blend or full-synthetic Motorcraft oil per the IOLM, or every 7,500-10,000 miles. EcoBoost engines require full synthetic; Coyote 5.0L V8 specifies SAE 5W-30.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 10,000 miles, or with every other oil change. F-150 4x4 owners should rotate every 5,000-7,500 miles to even out drivetrain bias wear.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect brake pads, rotors, and brake fluid level every 10,000 miles. Front pads on F-150 and Explorer typically last 40,000-60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Ford specifies brake fluid replacement on an inspection basis, but moisture testing every 3 years is recommended. Replace if reading exceeds 3% water content.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Replace the engine air filter every 30,000 miles. EcoBoost turbocharged engines are sensitive to airflow restriction — don't extend.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Ford 6R80, 10R80, and 8F transmissions use Mercon LV fluid rated 150,000 miles under normal service. Severe service (towing, plowing) drops this to 60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
On 4x4 models, replace transfer case fluid every 60,000 miles. Use Motorcraft XL-12 — do not substitute generic transfer case fluid.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
F-Series and Expedition: replace rear axle fluid every 100,000 miles, or 50,000 miles if towing. Limited-slip rear ends require friction-modifier additive.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Iridium spark plugs on Coyote 5.0L, EcoBoost 2.7L/3.5L, and 2.3L are rated 100,000 miles. EcoBoost engines: never exceed the interval — gap erosion causes coil failure.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Motorcraft Orange (Dex-Cool compatible) coolant: first change at 100,000 miles, then every 50,000. Older trucks with Yellow Motorcraft coolant: 50,000 miles throughout.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Extends the life of your vehicle and improves comfort
Replace the cabin air filter every 20,000 miles. On F-150, located behind the glove box; on Escape and Explorer, accessed from the passenger footwell.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 1997 Ford Aerostar reflects Ford's published service intervals and the Intelligent Oil-Life Monitor system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.