1997 Ford Expedition Recalls, Problems & Maintenance

“MISCELLANEOUS ELECTRICAL PROBLEMS CAUSED BY WATER LEAKING FROM DRIVER'S SIDE WINDSHIELD INTO THE FUSE BOX CAUSING, WINDSHIELD WIPERS TO QUIT. DOOR LOCK WON'T WORK, RADIO QUIT. PROBLEM IS NEVER THE SAME, DEPENDS ON WHERE THE WATER LEAK OCCURS”

“CAR WAS DEAD WHEN I WOKE UP. JUMPED IT, SPEEDOMETER DIDN'T WORK AFTERWARD. LIGHTS IN RIGHT HAND CORNER BLINK ON AND OFF I WAS TOLD BY THE FORD DEALER IT IS A GEM MODULE IS GETTING WATER IN IT BUT I DO NOT HAVE A LEAK IN MY WINDSHIELD”

“MY 1997 FORD EXPEDITION HAS BEEN HAVING SERIOUS ELECTRICAL PROBLEMS. I HAVE HAD THE GEM MOD REPLACED AS WELL AS THE FUSE BOX. IT SEEMS AS THOUGH WATER IS LEAKING INTO THESE PARTS FROM THE WINDSHIELD”

“THE REAR LOWER TRAILING ARMS THAT HOLD THE REAR AXLE IN PLACE ARE MADE TOO THIN AND WITH CORROSION WILL FAIL. THIS WILL CAUSE THE REAR AXLE TO MOVE BACKWARD AND BREAK THE DRIVE SHAFT”

“TL* THE CONTACT OWNS A 1997 FORD EXPEDITION. WHILE DRIVING AT 10 MPH, AN ABNORMAL SOUND WAS HEARD FROM THE REAR DRIVER SIDE TIRE. THE FAILURE RECURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED”

“TL*THE CONTACT OWNS A 1997 FORD EXPEDITION. THE CONTACT NOTICED THAT THE VEHICLE WAS LEANING TO ONE SIDE. THE CONTACT'S HUSBAND INSPECTED IT AND NOTICED THAT THE TORSION BAR WAS BROKEN”

“DT*: THE CONTACT STATED THE CHILD SAFETY LOCKS ON THE REAR DOORS ENGAGED THEMSELVES. THE CONTACT MUST EXIT THE VEHICLE AND OPEN THE DOORS FOR PASSENGERS. THE DEALERSHIP REPAIRED THE PROBLEM, BUT IT IS OCCURRING AGAIN”

“1997 FORD EXPEDITION. REAR CHILD DOOR LOCKS. ONE SIDE EVENTUALLY LOCKS BY ITSELF. REAR OCCUPANTS CANNOT GET OUT,MUST OPEN DOOR FROM OUTSIDE. DEALER SAID NOTHING WRONG WITH IT AND NO RECALL”

“CHILD SAFETY LOCKS ON BOTH REAR DOORS AUTOMATICALLY ENGAGE AFTER THE DOOR IS SHUT, OR THE CAR IS DRIVEN FOR SEVERAL MILES. SOMETIMES THE SWITCH IS HARD TO FLIP BACK TO UNLOCK WITHOUT JIGGLING THE OUTSIDE DOOR HANDLE”

“THE STRAPS HOLDING THE GAS TANK IN PLACE HAVE RUSTED OUT CAUSING THE GAS TANK TO SEPARATE FROM THE VEHICLE”

“OUR SPARE TIRE THAT WAS MOUNTED UNDERNEATH THE CAR, -FELL OFF- WHILE DRIVING THROUGH A RESIDENTIAL NEIGHBORHOOD. THE CABLE "BROKE" THAT WAS HOLDING IT IN PLACE UNDERNEATH THE CAR. THANK GOODNESS WE WERE NOT ON THE FREEWAY”

“TL*- THE CONTACT STATED THAT WHILE DRIVING THE 1997 FORD EXPEDITION INTO THE DRIVEWAY THE CABLE THAT HELD THE SPARE TIRE SNAPPED, CAUSING THE SPARE TIRE TO FALL ONTO THE GROUND WHILE GOING UP OVER THE CURB”

“WHILE DRIVING AT APPROXIMATELY 65 MPH # 2 SPARK PLUG POPS OUT OF THE HEAD”

“SPARK PLUG BLOWN OUT OF HEAD BY FORCE OF THE ENGINE, LOSS OF POWER AN MAJOR DAMAGE”

“#4 SPARK PLUG BLEW THRU HEAD”

“1997 FORD EXPEDITION CAUGHT FIRE TODAY 09-09-2008. THE VEHICLE HAD BEEN PARKED FOR SEVERAL HOURS, NO KEY IN IGNITION. FIRE DEPARTMENT TOLD ME TO CHECK ON THE RECALLS, I DID & IT HAD A FIRE RECALL ON THE MAKE, MODEL & YEAR OF THE VEHICLE I DID OWN. IT IS SALVAGE NOW”

“DT: THE CONSUMER STATED 1997 FORD EXPEDITION. CAUGHT ON FIRE. THE FIRE STARTED UNDER THE HOOD, AND WAS IN THE CRUISE CONTROL AREA. THE VEHICLE WAS PARKED AND TURNED OFF. THE DRIVER EXITED THE VEHICLE ABOUT THREE MINUTES EARLIER”

“DT:THE CONTACT STATED VEHICLE CAUGHT FIRE WHILE DRIVING. HE RECEIVED RECALL 05V388000 CONCERNING VEHICLE SPEED CONTROL:CRUISE CONTROL. SMOKE WAS COMING FROM THE AIR VENTS”

“DRIVER SIDE TIE-ROD SEPERATION '97 FORD EXPEDITION WHILE DRIVING AT 50 MPH ON HIGHWAY. LOSE OF STEERING CONTROL. SERIOUS ACCIDENT AVOIDED ONLY BECAUSE OF EMERGENCY BRAKING”

“TIE ROD THREADS STRIPPED LEADS TO COMPLETE LOSS OF STEERING AND NEAR-DEATH EXPERIENCE”

“THE STEERING ON THE VEHICLE IS LOOSE AND WONDERS ALL OVER THE ROAD CONTACTED A MECHANIC AND HE TOLD ME WHERE STEERING SHAFT SLIDES TOGETHER IS REALLY LOOS AND STEERING SHAFT NEEDS REPLACED”

“THE BRAKE LINES RUPTURE WITH NO WARNING. THE VEHICLE HAS ABSOLUTELY NO BRAKES. THE BRAKE PEDAL GOES STRAIGHT TO THE FLOOR. IF IN TRAFFIC, THIS BRAKE LINE RUPTURE COULD CAUSE SERIOUS INJURY OR DEATH. BRAKE LINES HAD TO BE REPLACED”

“RUBBER BRAKE LINE SEPARATED AT THE CALIPER. CAUSED TOTAL LOSS OF BRAKING POWER. LUCKILY I WAS PULLING INTO THE DRIVEWAY AT A SLOW SPEED WHEN THIS HAPPENED”

“IN DRIVEWAY UPON DEPRESSING THE BRAKE PEDAL, TO PUT CAR IN GEAR, BRAKE PEDAL WENT TO THE FLOOR. NO BRAKES AT ALL. NO WARNING. NO LIGHTS INDICATING FAILURE AHEAD OF TIME. BOTH BRAKE LINES THAT GO FROM MASTER CYL, TO ABS UNIT RUSTED THROUGH”