The 1997 GMC Safari has no open NHTSA recalls. Owners report 7 recurring issue clusters, led by “Windshield wiper intermittent or total failure.” GMC trucks and SUVs use the GM Oil Life System (OLS) — the same algorithm as Chevrolet. Because GMC's lineup is exclusively trucks and SUVs, severe-service intervals apply to most owners (towing, hauling, off-roading). The schedule below surfaces the items most relevant to GMC's truck-focused buyer.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 1997 GMC Safari.
VISIBILITY
18 NHTSA complaints · 1997-07 → 2008-05
“AT 90000 MILES, WINDSHIELD WIPERS ON MY 97 GMC SAFARI SUDDENLY STARTED TO FAIL WHILE DRIVING IN THE RAIN”
“WINDSHIELD WIPERS FAIL TO OPERATE MOST OF THE TIME. MUST STOP ON SIDE OF ROAD AND MANUALLY START THEM”
“WHILE TRAVELING IN INCLEMENT WEATHER AND WITHOUT PRIOR WARNING WINDSHIELD WIPERS WILL COME ON AND OFF INTERMITTENTLY”
VEHICLE SPEED CONTROL
8 NHTSA complaints · 1999-07 → 2005-08
“THE THROTTLE BODY ON OUR 1997 GMC SAFARI CAME APART SENDING PIECES INTO THE ENGINE AND FAILING IN A WIDE OPEN THROTTLE CONDITION THAT WAS NOT CONTROLLABLE BY THE DRIVER”
“WHILE TRAVELING AT APPROXIMATELY 20 MPH IN TRAFFIC VEHICLE SUDDENLY STARTED TO ACCELERATE”
“WHEN APPLYING THE GAS PEDAL ITS STAYS DOWN AND WILL NOT RETURN UNTIL IT HAS BEEN REPEATEDLY REAPPLIED”
FUEL SYSTEM, OTHER
5 NHTSA complaints · 2000-01 → 2005-03
“THE GAS GAUGE READ THAT THE VEHICLE HAD A QUARTER OF A TANK OF GAS, WHEN IN FACT THE TANK WAS EMPTY”
“GAS GAUGE FAILS TO REGISTER THE CORRECT AMOUN TOF FUEL IN FUEL TANK WHILE DRIVING”
“WHILE TRAVELING AND WITHOUT ANY INDICATION VEHICLE RAN OUT OF GAS, BUT GAS GAUGE WAS READING GAS IN TANK AS FULL”
SEAT BELTS
8 NHTSA complaints · 1997-01 → 2001-08
“MY DAUGHTER WAS ATTEMPTING TO HOOK HER SEATBELT BEFORE WE LEFT A PARKING LOT AND THE BUCKLE LITERALLY FELL APART IN HER HAND”
“THE PASSENGER'S SIDE SEAT BELT HAS BEEN REPLACED 3 TIMES BECAUSE IF FAILS TO EXTEND OUT FOR BUCKLING”
“THE SEAT BELT ON THE PASSENGER'S SIDE WILL NOT PULL OUT OF THE RETRACTOR”
STEERING, SERVICE BRAKES, HYDRAULIC
8 NHTSA complaints · 1998-08 → 2004-02
“WHILE TRAVELING ON THE FREEWAY AT 65 MPH THE FAN BELT TENSIONER PULLEY SOUNDED LIKE IT EXPLODED, THE POWER STEERING QUIT AND THE BRAKES WOULD NOT STOP THE VEHICLE”
“SHAFT ON HYDRUALIC STEERING PUMP FELL OUT, CAUSING THE VEHICLE TO LOSE THE POWER BRAKES AND POWER STEERING”
“WHILE DRIVING STEERING SYSTEM MALFUNCTIONED, AND THE VEHICLE EXPERIENCED NO BRAKING ABILITY”
POWER TRAIN
13 NHTSA complaints · 2000-02 → 2005-11
“1997 GMC SAFARI TRANSMISSION FAILURE. SUN GEAR SHELL FAILURE CAUSED NO REVERSE, SECOND OR OVERDRIVE ON THIS VEHICLE”
“TRANSMISSION OVER-PRESSURIZED AND FORCED FLUID OUT OF THE DIP STICK TUBE ONTO THE ENGINE AND EXHAUST CAUSING A LARGE AMOUNT OF SMOKE AND CREATING A FIRE HAZARD”
“TRANSMISSION JERKS BETWEEN FIRST/ SECOND AND THIRD GEARS”
SERVICE BRAKES, HYDRAULIC
5 NHTSA complaints · 1999-09 → 2014-08
“1997 GMC SAFARI BRAKE FAILED COMPLETELY NO REAR NO FRONT SUSPECT IT WAS THE ANTI LOCK CONTROL UNDER THE DRIVERS SEAT”
“THE CONSUMER STATED THAT THE BRAKES FAILED CAUSING THE VEHICLE TO HIT A PARKED VEHICLE”
“ABS BRAKING SYSTEM MALFUNCTIONED, CAUSING THE WHEELS TO LOCK UP AND THE VEHICLE TO SKID, WHICH MAY HAVE RESULTED IN A CRASH”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Change oil when OLS reaches 0% or every 12 months. dexos1-approved synthetic required on Sierra 1500 5.3L/6.2L; dexos2 specified on Duramax diesel.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 7,500 miles. Sierra and Yukon owners running 4x4 should rotate every 5,000-7,500 miles to even out drivetrain wear.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect pads, rotors, and parking brake every 7,500 miles. Towing accelerates pad wear by 30-50%; check more often if towing regularly.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
DOT 3 brake fluid: test annually, replace when moisture exceeds 3% or fluid is darker than copper.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Long-life cellulose filter rated 45,000 miles. Trucks driven on unpaved roads or construction sites should inspect at every oil change.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Severe service (towing 5,000+ lbs regularly, heavy stop-and-go): every 45,000 miles. Normal: 97,500 miles. Use Dexron-VI for 6L80/6L90, Mobil 1 LV ATF HP for 10L80/10L1000.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
On 4WD models, replace every 45,000 miles. Use GM Auto-Trak II for active 4WD; GM 9986115 for selectable 4WD.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
Replace front and rear axle fluid every 50,000 miles, or 25,000 miles if towing. G80 limited-slip rear axles require GM friction-modifier additive.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Iridium spark plugs on the L83/L84 5.3L and L86/L87 6.2L V8 are rated 100,000 miles. AFM/DFM cylinder deactivation can cause uneven plug wear — check at 75,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000. Duramax diesel uses ELC (red) — different chemistry, do not mix.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Extends the life of your vehicle and improves comfort
Replace cabin air filter every 22,500 miles. Sierra HD and Yukon XL owners in dusty work environments should replace at 15,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Occupant deaths in fatal crashes (FARS)
60 crashes 1990–2024
How the 60 occupant deaths break down
37
driver deaths
23
passenger deaths
60
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 1997 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
9
complaints mentioning a crash
3
complaints mentioning a fire
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 1997 GMC Safari reflects GMC's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.