Wrench.Pro

1998 Chevrolet Malibu Recalls, Problems & Maintenance

The 1998 Chevrolet Malibu has no open NHTSA recalls. Owners report 6 recurring issue clusters, led by “Steering rack and pinion mount weld failure or leak.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 1998 Chevrolet Malibu.

Reported to NHTSA

Steering rack and pinion mount weld failure or leak

STEERING

12 NHTSA complaints · 2004-09 → 2016-01

“THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL WOULD SUDDENLY MALFUNCTION AND BECAME VERY DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE RACK AND PINION WAS FAULTY AND NEEDED TO BE REPAIRED”
— Owner report, NHTSA ODI #10641930
“I PURCHASED NEW TIRES TODAY AND THE TECHNICIANS NOTICED THERE WAS EXCESSIVE PLAY IN THE STEERING LINK VIA THE RACK AND PINION. UPON FURTHER INVESTIGATION IT WAS DISCOVERED THAT THE WELDS (WHICH ARE BOTH FACTORY AND MOST LIKELY ROBOTIC) HOLDING THE NUT THROUGH THE RACK AND PINION”
— Owner report, NHTSA ODI #10780255
“THE DEALER STATED THAT THE STEERING: RACK AND PINION WAS LEAKING AND THE CONTACT PAID $195, PLUS $470 FOR LABOR. THE CONTACT WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 03V527000 (STEERING:RACK AND PINION)”
— Owner report, NHTSA ODI #10222896

Read all complaints on NHTSA →

Intake manifold gasket coolant leak

ENGINE AND ENGINE COOLING

17 NHTSA complaints · 2004-08 → 2010-03

“THE INTAKE MANIFOLD ON MY 1998 CHEVROLET MALIBU IS LEAKING FOR A SECOND TIME. THE FIRST OCCURRED AT 36,000 MILES. THE SECOND TIME IS NOW AT 120,000 MILES. THERE ARE A LARGE NUMBER OF OCCURRENCES OF THIS GASKET LEAKING BUT NO RECALL BY GM TO ADDRESS THE ISSUE”
— Owner report, NHTSA ODI #10250979
“INTAKE MANIFOLD GASKET LEAK, CAUSING ANTI FREEZE TO MIX WITH THE OIL, CAUSING FAILURE AND EXCESSIVE WEAR TO INTERNAL MOTOR PARTS”
— Owner report, NHTSA ODI #10225483
“MY CAR HAD TO HAVE THE THERMOSTAT, PLENINUM GASKET, INTAKE GASKET, EGR GASKET, VALVE COVER GASKETS REPLACED FOR THE SECOND TIME SINCE I HAVE HAD THIS CAR. I WAS TOLD THAT IT WAS BECAUSE OF THE DEX-COOL ANTIFREEZE THAT IS USED IN THESE CARS WARPS THE GASKETS AND SEALS”
— Owner report, NHTSA ODI #10187069

Read all complaints on NHTSA →

Windshield wiper linkage failure

VISIBILITY

12 NHTSA complaints · 2004-08 → 2011-04

“THE CONTACT STATED THAT THE WINDSHIELD WIPERS ON THE VEHICLE STOPPED WORKING DURING A RAIN STORM. THE CONTACT OBSERVED THAT THE LINKAGE ON THE MOTOR FOR BOTH WINDSHIELD WIPERS WERE BROKEN. THE CONTACT WAS UNABLE TO PURCHASE THE PART FROM THE DEALER AND IS CONCERNED THAT IT WILL”
— Owner report, NHTSA ODI #10340910
“THE PASSENGER-SIDE PIVOT HOUSING HAS CRACKED, AND THE WINDSHIELD WIPERS WILL NOT OPERATE. HE CONTACTED THE DEALER AND MANUFACTURER IN REFERENCE TO RECALL # 01V068000 (VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES). UPON CONTACT HE WAS ADVISED THAT HIS VEHICLE IDENTIFICATION NUMBER”
— Owner report, NHTSA ODI #10295569
“WHILE DRIVING IN A RAINSTORM, THE CONTACT ACTIVATED THE WINDSHIELD WIPERS AND THEY BEGAN TO CROSS OVER EACH OTHER. THE CONTACT PULLED THE VEHICLE OVER AND NOTICED THAT THE PASSENGER SIDE WIPER BLADE WAS VERY LOOSE”
— Owner report, NHTSA ODI #10234796

Read all complaints on NHTSA →

Ignition switch and anti-theft system causing engine stall

ELECTRICAL SYSTEM

50 NHTSA complaints · 2004-10 → 2019-01

“THE CONTACT OWNS A 1998 CHEVROLET MALIBU. WHILE DRIVING 70 MPH, THE ANTI-THEFT SYSTEM ENGAGED AND THE ENGINE SEIZED. THE CONTACT WAS NOT ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO HIS HOME. THE MANUFACTURER WAS NOTIFIED, BUT WAS UNABLE TO ASSIST”
— Owner report, NHTSA ODI #11171731
“IGNITION SWITCH NOT SHUTTING OFF AND AT TIMES NOT TURNING TO START CAR. SHIFT LEVER HAS TO BE WIGGLED TO ALLOW KEY TO TURN TO OFF POSITION. KEY CYLINDER SHUTTING OFF IN START POSITION”
— Owner report, NHTSA ODI #10945175
“THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART AFTER SEVERAL ATTEMPTS. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS INCLUDED IN NHTSA”
— Owner report, NHTSA ODI #10692621

Read all complaints on NHTSA →

Front coil spring fracture puncturing tire

SUSPENSION

36 NHTSA complaints · 2004-07 → 2014-10

“I HAVE A 1998 CHEVY MALIBU, AND THE SPRING STRUT SNAPPED IN HALF AND POPPED A HOLE IN MY TIRE, I HAD NO CONTROL OF THE VEHICLE AND ALMOST HAD A HEAD ON COLLISION WITH ANOTHER CAR GOING 45 MPH. LUCKILY THE CAR MOVED JUST IN TIME, I AM VERY SCARED FOR OTHER PEOPLE WHO OWN THIS CAR”
— Owner report, NHTSA ODI #10344135
“DRIVING AT APPROXIMATELY 10 MPH ON A SMOOTH DRY ROAD SUDDENLY THE FRONT RIGHT SIDE SPRING BROKE DAMAGING THE STRUT AND TIRE. THANKFULLY, THIS WAS AT A SLOW SPEED OR SOMEONE COULD HAVE BEEN KILLED. THE TIRE, SPRING AND STRUT WERE REPLACED”
— Owner report, NHTSA ODI #10236489
“THE FRONT LEFT, DRIVER SIDE, SPRING BROKE WHILE DRIVING AT APPROXIMATELY 5 MILES PER HOUR ON A SMOOTH PAVED ROAD. THIS WAS THE 2ND TIME THIS HAS HAPPENED ON THE SAME CAR. THE FIRST TIME WAS THE RIGHT FRONT SIDE. I WAS DRIVING SLOWER SO THE TIRE DID NOT BLOW FROM THE SHARP BROKEN”
— Owner report, NHTSA ODI #10236497

Read all complaints on NHTSA →

Airbag inadvertent deployment or failure to deploy

AIR BAGS

11 NHTSA complaints · 2004-11 → 2015-07

“THE CONTACT OWNS A 1998 CHEVROLET MALIBU. WHILE THE VEHICLE WAS AT A COMPLETE STOP, THE FRONT PASSENGER AND DRIVER SIDE AIR BAGS DEPLOYED WITHOUT WARNING AND SHATTERED THE FRONT PASSENGER SIDE OF THE WINDSHIELD”
— Owner report, NHTSA ODI #10735113
“THE CONTACT STATED WHILE TRAVELING 35 MPH, THE VEHICLE WAS INVOLVED IN A FRONT IMPACT CRASH, AND THE AIRBAGS DID NOT DEPLOY. ADDITIONALLY, THE CONTACT WAS WEARING A SEAT BELT, AND THE BUCKLE ASSEMBLY FRACTURED UPON INITIAL IMPACT”
— Owner report, NHTSA ODI #10175219
“WHILE DRIVING, THE AIR BAG DEPLOYED AND CRACKED THE WINDSHIELD”
— Owner report, NHTSA ODI #10101481

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

On 4WD models, replace transfer case fluid every 45,000 miles — sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

494 crashes 1990–2024

How the 494 occupant deaths break down

349

driver deaths

144

passenger deaths

1

not recorded by seat

494

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 1998 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

39

complaints mentioning a crash

5

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 1998 Chevrolet Malibu reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →