The 1999 Dodge Ram Van has no open NHTSA recalls. Owners report 6 recurring issue clusters, led by “Frame rust at steering component mounts.” Dodge uses Stellantis' Oil Change Indicator — it watches engine load and duty cycle and messages when to change oil, capped at 10,000 miles or 12 months. Know your engine: the 3.6L Pentastar V6 goes 100,000 miles on plugs, while HEMI V8s carry sixteen plugs (two per cylinder) on a roughly 30,000-mile interval — that's a real cost difference at the service counter. HEMI models with MDS cylinder deactivation are especially sensitive to overdue oil.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 1999 Dodge Ram Van.
STEERING, STRUCTURE
7 NHTSA complaints · 2012-07 → 2016-03
“WHILE DRIVING THE VAN THE STEERING BECAME UNCERTAIN, THE VAN WOULD NOT RESPOND TO THE WHEEL”
“THE CONTACT STATED THAT THE ENTIRE FRONT FRAME WAS COMPLETELY RUSTED AND HAD BEEN EATEN AWAY BY CORROSION”
“THE VEHICLE WAS LATER TOWED AND HE WAS INFORMED THAT THE STEERING LINKAGE FRACTURED DUE TO THE FRAME BEING RUSTED”
ENGINE AND ENGINE COOLING
3 NHTSA complaints · 2005-08 → 2010-05
“MAY 1, 2010 THE REPLACEMENT ENGINE WITH 36,000 MILES EXPERIENCED A SUDDEN LOSS OF OIL THAT REGISTERED ON MY OIL PRESSURE GAUGE”
“WHEN I STOPPED AT THE GAS STATION TO CHECK THE OIL, I DISCOVERED MY OIL WAS ABOUT 3 QUARTS LOW”
“WE JUST TOOK A TRIP TO CALIFORNIA, AND WENT THROUGH ALMOST A CASE OF OIL!”
SEATS
3 NHTSA complaints · 2004-01 → 2005-04
“THE SEAT BACK ON THE DRIVER'S SIDE COLLAPSED WHILE DRIVING 30 MPH”
“WHILE DRIVING DRIVER'S SEAT BACK FELL BACK, CAUSING THE DRIVER TO LOSE CONTROL OF THE VEHICLE TEMPORARILY”
“THE DRIVER'S SEAT ANCHORAGE FAILED AND CAUSED THE SEAT TO COLLAPSE”
SERVICE BRAKES, HYDRAULIC
3 NHTSA complaints · 2002-03 → 2006-04
“THE CONTACT STATED THE EXTERIOR METAL ON THE BRAKE LINES RUSTED THROUGH”
“IT APPEARS THAT THE BATTERY BEING RIGHT ABOVE THE VALVING HAS ALLOWED BATTERY ACID TO DETERIORATE THE BRAKE LINES”
“BRAKE HOSE HAS CONTINUOUSLY BEEN RUBBING ON UPPER CONTROL, VEHICLE HAS BEEN LEAKING BRAKE FLUID”
TIRES
3 NHTSA complaints · 2000-10 → 2001-05
“CONSUMER HAS TAKEN VEHICLE INTO DEALERSHIP FOR REALIGNMENT 7 TIMES BECAUSE VEHICLE CONTINUES TO PULL TO LEFT, AND TIRES KEEP WEARING EXCESSIVELY”
“TIRES ARE WEARING OUT, THERE ARE BALD SPOTS”
“IT IS NOT MADE FOR HEAVY DUTY CONVERSION VANS. VAN WILL NOT STAY IN ALIGNMENT”
ELECTRICAL SYSTEM
11 NHTSA complaints · 2004-08 → 2009-01
“THE VERIZON VEHICLE HAD AN UNDERHOOD FIRE WHILE BEING DRIVEN WHICH ORIGINATED IN THE ABS MODULE AREA”
“WHEN DIAGNOSING THE COMPLAINT THE MECHANIC DISCOVERED THAT THE ABS MODULE CONNECTOR AND WIRING WERE BURNT”
“THE VAN HAD AN UNDER HOOD FIRE THAT ORIGINATED IN THE ABS MODULE AREA WHILE PARKED”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Change when the indicator says so — never beyond 10,000 miles or 12 months. Pentastar 3.6L: 0W-20. HEMI 5.7L: 5W-20 (0W-40 for 6.4L SRT). MDS-equipped HEMIs punish stretched oil intervals with lifter and cam wear.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate every 8,000 miles. Charger/Challenger R/T and Scat Pack: staggered-width setups can't rotate front-to-rear — budget rear tires accordingly.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect pads and rotors at every oil change. Heavy Durangos used for towing and hard-driven Chargers both run through rear pads faster than the front-pad-first rule of thumb suggests.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Keeps your vehicle running smoothly and efficiently
HEMI 5.7L: sixteen plugs roughly every 30,000 miles — check your year's manual. Pentastar 3.6L (Charger/Challenger V6, Durango V6, Journey, Grand Caravan): 100,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Grand Caravan/Journey (62TE): ATF+4 service every 60,000 miles in family duty. Charger/Challenger/Durango with the TorqueFlite 8-speed: no published normal interval, but specialists recommend service around 60,000-100,000 miles — sooner with towing.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
RWD Charger/Challenger and AWD Durango: replace rear diff fluid around 60,000 miles, sooner with towing or drag-strip duty. Limited-slip units need the friction-modifier additive.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Replace every 30,000 miles. HEMIs pull serious airflow — a clogged filter costs measurable power before it throws a code.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Inspect from 60,000 miles, replace on cracking or glazing. On the HEMI, a shredded belt can take the cooling drive with it mid-drive.
Estimated cost — typical U.S. ranges
Dealer
~$195–$235
Shop
~$135–$165
DIY
~$20–$50
DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.
Extends the life of your vehicle and improves comfort
Replace every 20,000 miles where equipped (behind the glovebox on most models). Some earlier Journeys and Avengers shipped without one — check before buying a filter.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Stellantis OAT coolant is scheduled for 10 years / 150,000 miles; shops commonly refresh by 100,000. OAT-compatible coolant only — mixing chemistries gels the system.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Test annually after year 3. Big-audio Chargers and tow-package Durangos lean on the battery hard; weak batteries surface as gremlins in the electronics before they fail to crank.
Estimated cost — typical U.S. ranges
Dealer
~$225–$390
Shop
~$160–$280
DIY
~$130–$250
Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.
Occupant deaths in fatal crashes (FARS)
94 crashes 1990–2024
How the 94 occupant deaths break down
46
driver deaths
48
passenger deaths
94
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 1998 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
6
complaints mentioning a crash
11
complaints mentioning a fire
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 1999 Dodge Ram Van reflects Dodge's published service intervals and the Oil Change Indicator System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.