The 2000 BMW 328i has no open NHTSA recalls. Owners report 6 recurring issue clusters, led by “Rear subframe and differential mount cracking.” BMW vehicles use Condition-Based Service (CBS) — the dashboard shows each service item with its own remaining mileage and time, calculated by sensors. The schedule below shows BMW's underlying targets. BMW Ultimate Care covers the first 3 years / 36,000 miles of factory-scheduled maintenance on most new vehicles.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 2000 BMW 328i.
STRUCTURE
28 NHTSA complaints · 2004-12 → 2018-12
“SUBFRAME FAILURE ON BMW E46. ON MY REAR 2 DIFFERENTIAL MOUNTS OF THE SUBFRAME WERE CRACKS THAT WERE SPREADING”
“2000 BMW 328I SUBSTANTIAL SUBFRAME CRACKING AT REAR DIFFERENTIAL AREA”
“REAR SUB FRAME MOUNTING POINTS ARE TEARING THROUGH THE FLOOR PAN”
POWER TRAIN
23 NHTSA complaints · 2007-03 → 2016-10
“THE REVERSE GEAR IN THE TRANSMISSION WILL NOT GO IN GEAR. ALL OTHER GEARS RESPOND”
“MY 2000 BMW 328I REVERSE GEAR JUST WENT OUT. WHEN I PUT IT IN REVERSE TO BACK UP THERE IS NO POWER”
“2000 BMW 328I TRANSMISSION WON'T GO INTO REVERSE”
VISIBILITY
4 NHTSA complaints · 2003-11 → 2011-01
“THE WINDOW REGULATORS ON MY CAR HAVE BEEN REPLACED A TOTAL OF 9 TIMES”
“ALL FOUR WINDOW REGULARS NEEDED TO BE REPLACED”
“THERE HAVE BEEN THREE POWER WINDOW MECHANISM FAILURES ON THIS CAR”
ELECTRICAL SYSTEM
3 NHTSA complaints · 2010-03 → 2017-06
“2000 BMW 328I (E46) DOORS WILL NOT UNLOCK WHEN TEMPERATURE RISES (WEATHER GETS HOT) AFTER RESEARCH FOUND OUT THE MG5 OR MODULE MUST BE CHANGED AND REPROGRAMMED BY BMW DEALER”
“THERES A PROBLEM WITH THE GM5 MODULE INSIDE BMW'S THAT NEED TO BE RECALLED AND FIXED MY CURRENTLY ISN'T WORKING AND NONE OF MY DOORS WILL OPEN WHICH I CONSIDER A HUGE SAFETY HAZARD”
AIR BAGS
14 NHTSA complaints · 2000-11 → 2021-06
“THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE PASSENGER SIDE AIR BAG DEPLOYED WITHOUT WARNING”
“WHILE DRIVING AT 75 MPH SIDE AIRBAG INADVERTENTLY DEPLOYED”
“WHEN THE VEHICLE TURNED A CORNER THE SIDE AIR BAGS DEPLOYED”
AIR BAGS
11 NHTSA complaints · 2014-12 → 2020-08
“THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR”
“SINCE FEBRUARY 18,2020 I'VE BEEN TRYING TO HAVE BMW AGENT DEALER / CAR MAINTENANCE SERVICES IN CONCORD CA TO PERFORM THE REMEDY CONCERNING THIS ISSUE WITH NO RESULTS ( IT'S ALWAYS THE SAME REASON : SPARE PARTS ARE NOT AVAILABLE)”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Replace BMW Longlife-04 (LL-04) full-synthetic oil and filter every 10,000 miles or annually — whichever the CBS system signals first. M-series engines may require shorter intervals; check the vehicle-specific iDrive screen.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Replace DOT 4 LV brake fluid every 2 years regardless of mileage. CBS triggers based on time, not miles, due to moisture absorption.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Multi-point inspection covering brakes, suspension, steering, exhaust, fluids, lighting, and underbody. CBS signals every 30,000 miles or 2 years.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free with any paid service. A flashlight and 10 minutes covers the basics yourself.
Replace engine air filter every 40,000 miles. Higher-performance N55, B58, and S58 engines should be inspected at every oil service.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
B48 (2.0L turbo) and B58 (3.0L turbo) require new spark plugs every 60,000 miles. N20/N55 engines often spec 45,000 miles. M-series typically 30,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
BMW labels the ZF 8HP automatic as 'lifetime fill,' but independent transmission specialists strongly recommend replacement every 60,000 miles. Use BMW-spec ZF Lifeguard 8 — no substitutes.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
RWD and xDrive AWD: replace rear diff fluid every 60,000 miles, sooner with M-Sport or active differential. M-cars require BMW SAF-XO synthetic.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
BMW xDrive AWD: replace transfer case fluid every 60,000 miles. Skipping this causes the most common xDrive failure — actuator stuck in 100/0 split.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
Extends the life of your vehicle and improves comfort
Replace the activated-carbon microfilter every 30,000 miles. Most BMWs have a single combined cabin/charcoal filter behind the engine bay firewall.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
BMW labels coolant as lifetime fill on most modern vehicles. Independent BMW specialists recommend replacement every 4-5 years to prevent water-pump and thermostat housing degradation.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Occupant deaths in fatal crashes (FARS)
109 crashes 1990–2024
How the 109 occupant deaths break down
68
driver deaths
41
passenger deaths
109
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 2000 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
6
complaints mentioning a crash
2
complaints mentioning a fire
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2000 BMW 328i reflects BMW's published service intervals and the Condition-Based Service system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.