The 2000 Chevrolet Suburban has no open NHTSA recalls. Owners report 6 recurring issue clusters, led by “Corroded steel brake lines and loss of brake fluid.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 2000 Chevrolet Suburban.
SERVICE BRAKES, HYDRAULIC
11 NHTSA complaints · 2010-07 → 2014-11
“STEEL BRAKE LINE ALONG RIGHT REAR FRAME MEMBER CORRODED AND FAILED RESULTING IN LOSS OF BRAKE FLUID AND BRAKING ACTION”
“THE BRAKE LINE ON THE DRIVER SIDE HAS CORRODED AND CAUSED A LOSS OF BRAKE FLUID”
“REAR BRAKE LINES NEEDED TO BE REPLACE DUE TO CORROSION IN JUNE 2012. NOW THE FRONT BRAKE LINES NEED TO BE REPLACED DUE TO CORROSION JULY 2013”
SERVICE BRAKES
12 NHTSA complaints · 2002-07 → 2019-11
“I PRESSED ON THE BRAKE PEDAL BUT IT WENT STRAIGHT TO THE FLOOR”
“APPLIED BRAKES BUT BRAKE PEDAL DEPRESSED TO THE FLOOR WITH ONLY VERY MINOR BRAKING”
“WHILE DRIVING AT 30 MILES PER HOUR APPLIED THE BRAKES AND BRAKE PEDAL BECAME SOFT AND WENT TO THE FLOOR”
SERVICE BRAKES, HYDRAULIC
14 NHTSA complaints · 2002-12 → 2016-02
“MY 2000 CHEVROLET SUBURBAN AT LOW SPEEDS (AROUND 10 MILES PER HOUR)THE ABS BRAKING SYSTEM WILL ENGAGE FOR NO REASON”
“ABS WOULD IMPROPERLY ENGAGE WHEN APPLY BRAKES AT SPEEDS OF 5-7 MPH CAUSING LONGER BRAKING DISTANCES”
“2000 CHEROLET SUBURBAN AT SLOW SPEEDS WHEN BRAKING THE ABS IS ACTIVATED, WHICH INCREASES MY STOPPING DISTANCE”
FUEL SYSTEM, GASOLINE
4 NHTSA complaints · 2002-09 → 2004-10
“AFTER FUELING VEHICLE FUEL TANK LEAKED. HAD VEHICLE SERVICED,THERE WAS A LEAK IN FUEL TANK”
“FILLED THE TANK OF 2003, SUBURBAN WITH 41,776 MILES ON IT, BUT DID NOT TOP IT OFF”
PARKING BRAKE
21 NHTSA complaints · 2002-11 → 2013-09
“EMERGENCY PARKING BRAKES FAILS TO PERFORM ITS FUNCTION. WHEN THE PARKING BRAKES IS ENGAGED VEHICLE ROLLS”
“AFTER BEING SERVICED TWICE IN THE PAST YEAR, THE EMERGENCY BRAKE HAS FAILED TO SECURE THE REAR WHEELS WHEN PARKED ON AN INCLINE”
“I BOUGHT THE VEHICLE FROM A PRIVATE SELLER AND SOON FOUND THAT THE PARKING BRAKE PEDAL WOULD GO TO THE FLOOR WITH NO RESISTANCE AND WOULD NOT HOLD THE VEHICLE ON EVEN THE SLIGHTEST GRADE WITH THE TRANSMISSION IN NEUTRAL”
FUEL SYSTEM, GASOLINE
26 NHTSA complaints · 2003-01 → 2025-12
“FUEL PUMP FAILED WHILE DRIVING ON INTERSTATE FREEWAY CAUSING ENGINE TO SHUT DOWN”
“FUEL PUMP WIRES MELTING TOGETHER AND CAUSING VEHICLE TO STOP SUDDENLY AND SHORTING OUT PCM BOARD”
“THE FUEL PUMP MODULE WAS DEFECTIVE. THE WIRING ON THE FUEL PUMP MODULE OFTEN MELTED WHEN THE FUEL TANK WAS ROUTINELY RUN BELOW A QUARTER TANK OF GASOLINE”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
On 4WD models, replace transfer case fluid every 45,000 miles — sooner if towing or off-roading. Use GM Auto-Trak II fluid.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Extends the life of your vehicle and improves comfort
Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Occupant deaths in fatal crashes (FARS)
187 crashes 1990–2024
How the 187 occupant deaths break down
97
driver deaths
90
passenger deaths
187
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 2000 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
15
complaints mentioning a crash
7
complaints mentioning a fire
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2000 Chevrolet Suburban reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.