The 2000 Mazda Millenia has no open NHTSA recalls. Owners report 4 recurring issue clusters, led by “Ignition coil failure with misfire.” Mazda's Skyactiv engines use unusually high compression ratios (13:1 to 16:1) and require strict adherence to oil intervals — extending oil life on a Skyactiv engine accelerates carbon buildup on intake valves. Mazda's published Schedule 1 (severe) covers most US driving conditions.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 2000 Mazda Millenia.
ENGINE AND ENGINE COOLING
2 NHTSA complaints · 2004-04 → 2006-05
“THE IGNITION COILS IN MY CAR ARE GOING BAD. ONE RIGHT AFTER THE OTHER”
“THERE ARE 6 COILS & I HAVE REPLACED 3 SO FAR, 1 IN 12/04 & 2 IN 4/06 ALONG WITH ALL THE PLUGS”
“IN OCTOBER, 2003 MY CAR MIS-FIRED AND THE CHECK ENGINE LIGHT CAME ON. THE DIAGNOSIS WAS THAT THE IGNITION COIL FOR CYLINDER #2 WAS BAD AND NEEDED REPLACING”
LATCHES/LOCKS/LINKAGES
2 NHTSA complaints · 2006-01 → 2012-06
“THE CONTACT STATED THE PASSENGER SIDE DOOR ACTUATOR BROKE AND THE DOOR WILL NOT OPEN FROM THE INSIDE”
“THE FIRST TIME I HAD A PROBLEM WITH THE DOOR LOCKS THE L/R DOOR WOULD NOT OPEN”
“A FEW MONTHS LATER THE R/R DOOR WOULD NOT UNLOCK. I COULD NOT UNLOCK THE DOOR FROM EITHER INSIDE OR OUTSIDE, THIS MAKES 2 DOORS INOPERABLE”
POWER TRAIN
2 NHTSA complaints · 2003-05 → 2004-10
“WHILE DRIVING ,THE CAR WILL DOWN SHIFT RAPIDLY AND CAUSE A QUICK DECREASE IN OPERATING SPEED”
“WHILE SHIFTING CONSUMER NOTICED THAT THE GEARS ENGAGED SLOWLY, THEN HESITATED”
FUEL SYSTEM, GASOLINE
2 NHTSA complaints · 2000-09 → 2003-06
“FUEL CUTS OUT TO ENGINE AT 2000-2500 RPM. RESULTS IN SEVERE BUCKING AND NO CAPABILITY TO ACCELERATE, CREATING A VERY DANGEROUS CONDITION”
“WE OWN A 2000 MAZDA MILLENIA THAT STALLS AT ABOUT 50 MPH AND HAS HAD THIS PROBLEM SINCE WE BOUGHT THE CAR”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Replace 0W-20 full-synthetic oil every 5,000 miles under Schedule 1. Schedule 2 (highway-only): 7,500 miles. Turbo engines: 5,000 miles regardless of schedule.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 7,500 miles; every 5,000 on AWD models, where the front-biased coupling wears tires unevenly.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect brake pads, rotors, and parking brake at every oil change. Front pads typically last 35,000-50,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Replace DOT 3 brake fluid every 30,000 miles or 36 months.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Replace engine air filter every 30,000 miles. Skyactiv-G direct injection is sensitive to airflow restriction — inspect at every oil change.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Replace ATF every 60,000 miles severe / 100,000 normal. Use Mazda FZ ATF — substitutes cause harsh 1-2 shifts and torque converter shudder.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Iridium spark plugs every 60,000 miles on Skyactiv-G 2.0L and 2.5L; 45,000 miles on the 2.5L Turbo.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Mazda FL-22 (yellow): first change at 120,000 miles or 10 years, then every 60,000. Do not substitute — silicate-free formula prevents water pump damage on Skyactiv engines.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
On AWD models, replace transfer case fluid and rear differential fluid every 60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
Extends the life of your vehicle and improves comfort
Replace cabin air filter every 15,000 miles. On most models it sits behind the glove box.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2000 Mazda Millenia reflects Mazda's published service intervals. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.