2000 Volvo S80 Recalls, Problems & Maintenance

The 2000 Volvo S80 has no open NHTSA recalls. Owners report 8 recurring issue clusters, led by “Engine surge and erratic idle with throttle module faults.” Volvo schedules maintenance every 10,000 miles or 12 months, whichever comes first — the cluster's service reminder counts down to it. Drive-E four-cylinder engines (2015+) require Volvo-spec 0W-20; the older five-cylinder turbos (XC70, C30) run on a timing belt with a firm replacement interval, not a chain. AWD Volvos use a Haldex-style rear coupling whose fluid service is the difference between an AWD system that lasts and a four-figure pump-and-clutch repair.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2000 Volvo S80.

Reported to NHTSA

Engine surge and erratic idle with throttle module faults

VEHICLE SPEED CONTROL

29 NHTSA complaints · 2005-08 → 2014-08

“WHILE STOPPED AT A STOP LIGHT, THE ENGINE WOULD SPEED UP AND SLOW DOWN”
— Owner report, NHTSA ODI #10136189
“200 S80 WAS ACCELERATING SPONTANEOUSLY AND LUNGING FORWARD”
— Owner report, NHTSA ODI #10146168
“SURGING ENGINE RPM NOTED ON NUMEROUS OCCASIONS WHILE STOPPED”
— Owner report, NHTSA ODI #10138034

Read all complaints on NHTSA →

Fuel odor and leakage at the fuel pump

FUEL SYSTEM, GASOLINE

12 NHTSA complaints · 2008-07 → 2015-12

“THE CONTACT DISCOVERED AN EXCESSIVE AMOUNT OF FUEL LEAKING ON THE GROUND NEAR THE REAR SIDE OF THE VEHICLE UNDER THE FUEL TANK”
— Owner report, NHTSA ODI #10782160
“THE VEHICLE WAS STOPPED AND THE CONTACT NOTICED THAT FUEL WAS LEAKING THROUGH CRACKS IN THE FUEL PUMP, TRAVELING UP TO THE FRONT PASSENGER SEAT”
— Owner report, NHTSA ODI #10413383
“SURE ENOUGH, I TAKE IT TO A MECHANIC AND THE FUEL PUMP IS VISIBLY MOIST ON THE EXTERIOR FROM AN OBVIOUS FUEL LEAKAGE”
— Owner report, NHTSA ODI #10644582

Read all complaints on NHTSA →

Brake booster hissing and loss of brake assist

SERVICE BRAKES, HYDRAULIC

3 NHTSA complaints · 2007-08 → 2011-01

“A HISSING SOUND COMING FROM THE BRAKE PEDAL AREA BEGAN OCCURING AND I TOOK TO THE CAR TO THE DEALER AND WAS INFORMED THAT IT WAS A DEFECTIVE "BRAKE BOOSTER"”
— Owner report, NHTSA ODI #10200049
“THE SOUND IS COMING FROM THE BRAKE BOOSTER”
— Owner report, NHTSA ODI #10375405
“MY WIFE LEFT FOR WORK & GOT TO THE END OF THE DRIVEWAY & HAD NO BRAKE ASSIST IE VERY HARD PEDAL”
— Owner report, NHTSA ODI #10234275

Read all complaints on NHTSA →

Sunroof glass breaking during automatic car wash

VISIBILITY

3 NHTSA complaints · 2008-02 → 2009-10

“THE SUNROOF ON MY VOLVO S80 EXPLODED IN THE CARWASH UNDER THE DRYER”
— Owner report, NHTSA ODI #10287163
“I TOOK MY CAR TO A CAR WASH IN FEB. 2008 AND THE SUNROOF EXPLODED”
— Owner report, NHTSA ODI #10264489
“WHILE PROCEEDING THROUGH AUTOMATIC CAR WASH, THE SUNROOF SHATTERED DURING THE BLOWER/DRYER OPERATION”
— Owner report, NHTSA ODI #10217634

Read all complaints on NHTSA →

ABS control module failure

SERVICE BRAKES, HYDRAULIC

3 NHTSA complaints · 2005-09 → 2008-08

“2000 VOLVO S80 2.9L HAD ABS MODULE FAILED TWICE AT 25K MILES (2006) AND 50K (8/2008) MILES”
— Owner report, NHTSA ODI #10238348
“THE ABS CONTROL MODULE FUNCTIONS INTERMITTENTLY AND IS USUALLY IN THE FAILURE MODE”
— Owner report, NHTSA ODI #10137392

Read all complaints on NHTSA →

Stalling and sudden power loss with throttle module faults

VEHICLE SPEED CONTROL

52 NHTSA complaints · 2005-08 → 2012-02

“A 2000 VOLVO S80 THROTTLE CONTROL MODULE FAILED CAUSING THE CAR TO SUDDENLY DECELERATE”
— Owner report, NHTSA ODI #10141501
“CAR WOULD DIE WHEN DRIVING WITHOUT WARNING”
— Owner report, NHTSA ODI #10139499
“THE VEHICLE STALLS INADVERTENTLY AND HAS STRANDED ME IN THE MIDDLE OF TRAFFIC WHERE I NARROWLY MISSED BEING HIT BY A TRACTOR TRAILER”
— Owner report, NHTSA ODI #10154908

Read all complaints on NHTSA →

Air bag warning light and control module failure

AIR BAGS

5 NHTSA complaints · 2006-07 → 2020-08

“I CHANGED THE BATTERY AND THE AIRBAG WARNING LIGHT WENT ON”
— Owner report, NHTSA ODI #10482329
“AFTER TAKING IT TO THE DEALER, THEY CONFIRMED AN INTERNAL FAULT WITH SRS CONTROL MODULE”
— Owner report, NHTSA ODI #10161900
“THE CONTACT STATED THAT AFTER PARKING THE VEHICLE AND EXITING, THE DRIVER'S SIDE, PASSENGER'S SIDE AND THE CURTAIN AIR BAGS DEPLOYED INADVERTENTLY”
— Owner report, NHTSA ODI #10500978

Read all complaints on NHTSA →

Smoke and fire originating under the hood

ELECTRICAL SYSTEM

4 NHTSA complaints · 2005-08 → 2009-05

“WHEN THE CONTACT ARRIVED HOME, SHE NOTICED SMOKE UNDER THE HOOD OF THE VEHICLE”
— Owner report, NHTSA ODI #10268477
“WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED SMOKE AND PULLED THE VEHICLE OFF THE ROAD”
— Owner report, NHTSA ODI #10248573
“WHILE DRIVING 35 MPH, THE CONTACT NOTICED SMOKE COMING FROM UNDERNEATH THE HOOD OF THE VEHICLE”
— Owner report, NHTSA ODI #10193589

Read all complaints on NHTSA →

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (Annual Service)

Every 10,000 mi

Replace every 10,000 miles or 12 months with Volvo-spec oil (VCC 0W-20 on Drive-E engines). Turbo five-cylinders in the older XC70/C30 are harder on oil — many specialists suggest 7,500 miles on those.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Timing Belt (5-Cylinder — XC70, C30)

Every 105,000 mi

Volvo's five-cylinder engines use a timing belt: replace around 105,000 miles or 10 years (verify your year's exact interval). Interference engine — do the tensioner and idlers in the same job. Drive-E four-cylinders (2015+) use a chain instead.

Estimated cost — typical U.S. ranges

Dealer

~$935–$1175

Shop

~$655–$825

DIY

Pro only

On interference engines, a snapped belt destroys valves. Worth doing on schedule. Bundle water pump + tensioner — labor is already there.

Tire Rotation

Every 10,000 mi

Rotate at every annual service. AWD models: replace tires in matched sets — tread mismatch works the Haldex coupling constantly.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 10,000 mi

Inspect pads, rotors, and hoses at every service. Heavy XC90s wear front pads quickly in city duty; check electronic parking-brake function on 2016+ models.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 24,000 mi

Replace DOT 4 fluid every 2 years regardless of miles — standard practice for the moisture-absorbing fluid, and cheap insurance for the ABS unit.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

AWD Coupling Fluid (Haldex)

Every 40,000 mi

AWD models: replace the rear coupling's fluid roughly every 40,000 miles (Volvo's published interval varies by generation — check your manual). Skipping it clogs the pump filter and kills the AWD unit; whirring from the rear axle is the classic late symptom.

Estimated cost — typical U.S. ranges

Dealer

~$220–$290

Shop

~$155–$205

DIY

~$40–$90

VW/Audi/Volvo AWD coupling — specific fluid required. Filter usually swapped at the same time.

Automatic Transmission Fluid

Every 60,000 mi

The Aisin 8-speed is labeled long-life, but Volvo specialists broadly recommend fluid service around 60,000 miles — sooner with towing. Use the specified JWS/Toyota WS-type fluid for your gearbox.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 60,000 mi

Drive-E turbo fours: plugs around every 60,000 miles. Supercharged+turbocharged T6/T8 engines run higher cylinder pressures — don't stretch the interval.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Air Filter

Every 30,000 mi

Replace roughly every 30,000 miles; inspect annually in dusty climates.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 10,000 mi

Volvo specifies frequent cabin-filter replacement — annually on most models, in keeping with the brand's air-quality focus (CleanZone on newer cars).

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Engine Coolant

On condition / lifetime

Volvo long-life coolant typically runs ~10 years on the schedule; refresh with Volvo-spec coolant around 100,000 miles per independent-specialist practice.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

37 crashes 1990–2024

How the 37 occupant deaths break down

23

driver deaths

14

passenger deaths

37

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2001 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

18

complaints mentioning a crash

8

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2000 Volvo S80 reflects Volvo's published service intervals and the Volvo Service Reminder system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.