The 2001 Pontiac Sunfire has no open NHTSA recalls. Owners report 7 recurring issue clusters, led by “Ignition switch and anti-theft system disabling vehicle.” Every Pontiac is now 15+ years old, which changes the maintenance question from 'what mileage?' to 'how old is it?' — hoses, belts, coolant, and brake fluid age out even on low-mile cars. The G6 uses GM's Oil Life System (change oil when the message appears, at most every 12 months) with Dex-Cool coolant and either the 2.4L Ecotec four or the 3.5/3.9L pushrod V6. Parts remain cheap and plentiful through GM's shared platforms — these cars are inexpensive to keep healthy if the age-based items aren't ignored.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 2001 Pontiac Sunfire.
ELECTRICAL SYSTEM
7 NHTSA complaints · 2004-07 → 2017-04
“LOCK ANTI-THEFT SYSTEM INTERMITTENTLY DISABLES CAR. SOMETIMES THE SYSTEM WILL RESET ITSELF”
“CONSUMER RECEIVED RECALL 04V036000 CONCERNING IGNITION SWITCH. CONSUMER COMPLAINED THAT RECALL REPAIRS WERE DONE ONCE, BUT THE PROBLEM RECURRED”
“THE DEALER REPLACED THE BATTERY AND THE IGNITION SWITCH, BUT THE FAILURE CONTINUED”
ENGINE AND ENGINE COOLING
4 NHTSA complaints · 2004-11 → 2008-08
“TIMING CHAIN GUIDES WENT OUT AFTER ONLY 50,000 MILES”
“THIS IS THE SECOND TIME I HAVE HAD TO CHANGE THE TIMING CHAIN ON MY CAR IN THE PAST TWO YEARS”
“LEAK IN BOTH UPPER AND LOWER INTAKE MANIFOLD GASKETS”
VISIBILITY
3 NHTSA complaints · 2001-02 → 2005-03
“BOTH REAR WINDOWS HAVE FAILED ON THIS CAR”
“WHILE TRYING TO ROLL WINDOW DOWN ON DRIVER'S SIDE, WINDOW FELL OFF TRACK AND WENT DOWN INTO DOOR”
“DRIVER SIDE POWER WINDOW BECAME STUCK AND WOULDN'T ROLL DOWN”
ENGINE AND ENGINE COOLING
12 NHTSA complaints · 2001-07 → 2014-10
“WHILE DRIVING VEHICLE WILL STALL, RESULTING IN LOSS OF PROPER STEERING AND BRAKING CONTROL”
“AT HIGHWAY SPEEDS VEHICLE WILL AUTOMATICALLY SHUT OFF. ALL LIGHTS WILL GO OUT EXCEPT DASHBOARD LIGHTS”
“WHILE DRIVING VARIOUS SPEEDS, THE ENGINE STALLED”
AIR BAGS
4 NHTSA complaints · 2002-09 → 2004-09
“IN A FRONTAL COLLISION NONE OF THE AIR BAGS DEPLOYED ON IMPACT, CAUSING MAJOR INJURIES TO DRIVER”
“HAD A FRONTAL COLLISION, MY ENTIRE FRONT END WAS EFFECTED BY THE HIT NEITHER AIR BAG DEPLOYED NOR DID MY SEAT BELT KEEP ME AGAINST THE SEAT”
“AIRBAGS DID NOT DEPLOY IN A FRONT-END COLLISION. THE VEHICLE WAS TOTALED”
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
5 NHTSA complaints · 2002-08 → 2011-03
“2001 PONTIAC SUNFIRE RUNNING LIGHTS WILL NOT WORK. THEY WILL FLICKER WHEN THE CAR IS PUT INTO GEAR AND THEN SHUT OFF COMPLETELY”
“WHILE TRAVELING ON HIGHWAY TURNED TURN SIGNAL ON AND HEADLIGHTS WILL COME ON INTERMITTENTLY”
“HAVE HAD THE VEHICLE TO THE DEALER A NUMBER OF TIMES (3) FOR MULTIPLE FRONT END LIGHTING SYSTEM FAILURES OF VARIOUS COMPONENTS”
SERVICE BRAKES, HYDRAULIC
6 NHTSA complaints · 2001-03 → 2013-06
“WHEN THE ROADS ARE ICY/SNOWY, THE BRAKE PEDAL DOESN'T GO TO THE FLOOR BUT WILL LOCK UP, MAKE NOISE, AND GO OUT OF CONTROL”
“WHEN APPLYING THE BRAKES ON A BUMPY SURFACE BRAKES FAILED, RESULTING EXTENDED STOPPING DISTANCE”
“WHILE ATTEMTPING TO MAKE A NORMAL OR QUICK STOP ABS WILL VIBRATE AND VEHICLE WILL KEEP ROLLING AT LOW RATE SPEED ON DRY OR WET PAVEMENT”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Change when the Oil Life System calls it, and at least every 12 months. On engines this age, many mechanics suggest a practical 5,000-mile ceiling — aging seals and PCV systems contaminate oil faster.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate every 7,500 miles. Check tire date codes too — sidewall age (6+ years) retires tires on old cars before tread wear does.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect pads, rotors, and especially brake hoses and hard lines at every service — line corrosion is a real failure mode on 15-year-old northern cars.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Replace every 2 years. Decade-old fluid is the hidden cause of soft pedals and seized calipers on aging GM sedans.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Drain-and-fill every 45,000 miles with Dexron VI. On high-mile units that have never been serviced, prefer repeated drain-and-fills over a pressure flush.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Iridium plugs at 100,000 miles on the G6's engines. Replace wires/boots on the pushrod V6 at the same time — they're brittle at this age.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
At this age, replace the belt AND tensioner as a pair on any evidence of cracking or noise — a weak tensioner eats new belts.
Estimated cost — typical U.S. ranges
Dealer
~$195–$235
Shop
~$135–$165
DIY
~$20–$50
DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.
Replace every 30,000 miles — a cheap, 5-minute job on the G6.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Extends the life of your vehicle and improves comfort
Dex-Cool is rated 5 years / 150,000 miles — but on cars this old the interval is effectively 'every 5 years.' Check for intake and water-pump seepage while it's drained; use Dex-Cool only, never mixed with green coolant.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Test the battery and alternator annually. Parasitic drains from aging body modules are common on this era of GM — a healthy battery masks them until it doesn't.
Estimated cost — typical U.S. ranges
Dealer
~$225–$390
Shop
~$160–$280
DIY
~$130–$250
Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.
Occupant deaths in fatal crashes (FARS)
220 crashes 1990–2024
How the 220 occupant deaths break down
157
driver deaths
63
passenger deaths
220
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 2001 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
8
complaints mentioning a crash
2
complaints mentioning a fire
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2001 Pontiac Sunfire reflects Pontiac's published service intervals and the GM Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.