Wrench.Pro

2002 Mitsubishi Galant Recalls, Problems & Maintenance

The 2002 Mitsubishi Galant has no open NHTSA recalls. Owners report 6 recurring issue clusters, led by “Brake squeal, grinding and rotor wear.” Mitsubishi publishes short, conservative intervals: oil every 7,500 miles normal / 3,750 severe, and — unlike many rivals — an explicit CVT fluid replacement schedule rather than a 'lifetime fill' claim. Read the severe-service column honestly: stop-and-go city trips, short hops, and hot climates all qualify, and they describe how most Mirages actually live. The 10-year/100,000-mile powertrain warranty stays intact only with documented on-schedule service.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2002 Mitsubishi Galant.

Reported to NHTSA

Brake squeal, grinding and rotor wear

SERVICE BRAKES, HYDRAULIC

27 NHTSA complaints · 2002-08 → 2007-05

“I RECENTLY PURCHASED A USED 2002 GALANT. 2 DAYS AFTER PURCHASE THE BRAKES STARTED SQUEALING. BRAKE PADS WERE REPLACED AND 3 WEEKS LATER THEY STARTED SQUEALING AGAIN”
— Owner report, NHTSA ODI #10171482
“FRONT BRAKE ROTORS WARPED AFTER 15000 MILES, AND THE PROBLEM RESURFACED AGAIN AT 29000 MILES ALONG WITH EXCESSIVE BRAKE NOISE”
— Owner report, NHTSA ODI #10008481
“RECURRING AND SEVERE FRONT BRAKE CHATTER. DESPITE REPEATED REPAIR, THE FRONT BRAKES CHATTER ON BRAKING SO MUCH THAT THE STEERING WHEEL SHAKES”
— Owner report, NHTSA ODI #10152018

Read all complaints on NHTSA →

Heater control motor clicking and loss of heat

VISIBILITY

24 NHTSA complaints · 2006-02 → 2009-10

“2002 MITSHUBISHI GALANT- HEAT STOPPED WORKING AT 75,000 MILES. WHEN TURNING ON HEAT CAR BEGAN MAKING A "GARGLING" NOISE AND THEN EVENTUALLY STOPPED WORKING ALL TOGETHER”
— Owner report, NHTSA ODI #10207264
“THE HEATER CONTROL MOTOR IS FAILING. THE PART IS CHEAP BUT YOU HAVE TO REMOVE MOST OF THE DASH BOARD TO REPLACE IT”
— Owner report, NHTSA ODI #10186807
“THE HEATER CONTROL MOTOR ON MY CAR HAS FAILED TWICE SINCE I BOUGHT THE CAR A YEAR AND A HALF AGO”
— Owner report, NHTSA ODI #10206996

Read all complaints on NHTSA →

Paint fading, peeling and oxidation

STRUCTURE

15 NHTSA complaints · 2004-11 → 2010-04

“PAINT TURNING WHITE A PEELING OVER ENTIRE VEHICLE”
— Owner report, NHTSA ODI #10327769
“PAINT DEFECT LEADS T RAPID OXIDATION AND RUSTING OF CAR”
— Owner report, NHTSA ODI #10286326
“I BOUGHT MY CAR BRAND NEW (02 MITS. GALANT - BLACK) AND THE PAINT AND CLEAR COAT HAS BEEN FADING”
— Owner report, NHTSA ODI #10234282

Read all complaints on NHTSA →

Steering wheel vibration at highway speed

STEERING, SUSPENSION

3 NHTSA complaints · 2002-06 → 2007-01

“MY 2002 MITSUBISHI GALANT STEERING WHEEL AND THE ENTIRE CAR STARTS SHAKING WHEN IT REACHES 60 AND ABOVE MPH”
— Owner report, NHTSA ODI #10178175
“SEVERE STEERING VIBRATIONS AT HIGHWAY SPEEDS 60MPH & ABOVE”
— Owner report, NHTSA ODI #765773
“SEVERE VIBRATIONS ARE FELT ON THE STEERING WHEEL BEGINNING OVER THE SPEED OF 60 MPH AND GRADUALLY INCREASING OVER 70 MPH”
— Owner report, NHTSA ODI #762962

Read all complaints on NHTSA →

Air bags not deploying in collisions

AIR BAGS

18 NHTSA complaints · 2002-02 → 2022-08

“2002 GALANT SUSTAINED HEAD-ON COLLISION AT APX. 45MPH”
— Owner report, NHTSA ODI #10231827
“A FRONT END COLLISION WITH A TRUCK GOING 40 MPH IN AN INTERSECTION. THE AIR BAGS DID NOT DEPLOY RESULTING IN HEAD, CHEST, NECK, AND BACK INJURY”
— Owner report, NHTSA ODI #10072956
“I HAVE A 2002 MITSIBUSHI GALANT ES AND I WAS INVOLVED IN A WRECK INVOLVING 3 AUTOS AND I HIT THE BACK END OF THE SECOND CAR, CRUSHING THE GRILL IN TOWARD THE RADIATOR, AND NEITHER OF THE AIRBAGS DEPLOYED”
— Owner report, NHTSA ODI #10251126

Read all complaints on NHTSA →

Passenger door panel smoke and fire

ELECTRICAL SYSTEM

7 NHTSA complaints · 2005-08 → 2012-10

“SON WAS DRIVING HOME FROM COLLEGE AND THE PASSENGER SIDE DOOR CAUGHT ON FIRE AS HE WAS LEAVING THE PARKING LOT”
— Owner report, NHTSA ODI #10258161
“DT: THE CONTACT STATED WHILE DRIVING NOTICED SMOKE COMING FROM UNDERNEATH THE FRONT RIGHT PANEL”
— Owner report, NHTSA ODI #10145184
“TL* THE CONTACT OWNS A 2002 MITSUBISHI GALANT. THE CONTACT STATED THAT THE FRONT PASSENGER DOOR CAUGHT ON FIRE AS THE CONTACT STARTED THE VEHICLE AND OPENED THE FRONT PASSENGER WINDOW”
— Owner report, NHTSA ODI #10449742

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 7,500 mi

Replace every 7,500 miles normal / 3,750 severe. Mirage's 1.2L three-cylinder holds barely over 3 quarts — small sumps punish stretched intervals. 0W-20 on most recent models.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

CVT Fluid

Every 60,000 mi

Mitsubishi schedules CVT fluid replacement — commonly every 60,000 miles normal / 30,000 severe (check your year's table). Use only the specified CVT fluid (J4/CVTF-J4 family); generic ATF destroys the belt-and-pulley unit.

Estimated cost — typical U.S. ranges

Dealer

~$360–$500

Shop

~$255–$355

DIY

~$80–$180

CVT fluid is manufacturer-specific and pricey — do NOT substitute conventional ATF.

Tire Rotation

Every 7,500 mi

Rotate with every oil change. Light Mirages are easy on tires but the economy-focused OEM rubber wears fast when neglected.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors/drums, and lines at each service — Mirage G4 retains rear drums, which need periodic adjustment checks.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace every 2-3 years per the schedule. Cheap job, big ABS-unit insurance.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Spark Plugs

Every 60,000 mi

Iridium plugs commonly every 60,000 miles on the Mirage's 3A92 and Lancer's 4B11 — verify your year's table, as some engines list up to 105,000.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Air Filter

Every 15,000 mi

Mitsubishi's schedule replaces the engine air filter every 15,000 miles — shorter than most brands, and a 5-minute DIY on the Mirage.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Drive Belt

Every 60,000 mi

Inspect from 60,000 miles and replace on cracking. The Mirage's single serpentine belt also drives the A/C — a failure strands the car's accessories at once.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 15,000 mi

Replace every 15,000 miles, behind the glovebox. Often skipped at quick-lube visits — worth checking if airflow feels weak.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Coolant Replacement

Every 60,000 mi

First change around 60,000 miles, then roughly every 30,000-45,000 per the schedule. Mitsubishi long-life coolant or equivalent OAT for your year.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Battery Test & Service

Every 25,000 mi

Test annually after year 3. Small-battery economy cars have little reserve — the first cold snap finds a weak one.

Estimated cost — typical U.S. ranges

Dealer

~$225–$390

Shop

~$160–$280

DIY

~$130–$250

Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

161 crashes 1990–2024

How the 161 occupant deaths break down

114

driver deaths

47

passenger deaths

161

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2002 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

22

complaints mentioning a crash

10

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2002 Mitsubishi Galant reflects Mitsubishi's published service intervals. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →