The 2002 Volkswagen Cabrio has no open NHTSA recalls. Owners report 4 recurring issue clusters, led by “Power door lock and electrical accessory failure.” Volkswagen's modern TSI turbo engines (1.4T, 1.5T, 2.0T) require oil meeting VW 502 00 or VW 508 00 specification — generic 5W-30 will not protect under load. DSG dual-clutch transmissions (Jetta GLI, Golf GTI/R, Tiguan) require fluid service every 40,000 miles regardless of dealer claims of 'lifetime fill.' Haldex AWD models add their own coupling-fluid schedule.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 2002 Volkswagen Cabrio.
ELECTRICAL SYSTEM
5 NHTSA complaints · 2002-11 → 2010-11
“THE DRIVER AND PASSENGER DOORS FAILED TO LOCK”
“2002 VW CABRIO CONVERTIBLE, WHEN IT RAINS THE LIGHTS, ELECTRICAL LOCKS AND DOME LIGHTS TURN ON AND OFF, THE WHOLE ELECTRICAL LIGHTING AND ELECTRONIC SWITCH FAILURE OCCURS”
EXTERIOR LIGHTING
3 NHTSA complaints · 2005-03 → 2008-05
“2002 VOLKSWAGEN CABRIO EXPERIENCING RECALL SYMPTOMS. CONSUMER STATES THAT HER TURN SIGNAL AND HAZARD FLASHERS HAVE STOPPED FUNCTIONING”
“MY TURN SIGNAL AND HAZARD FLASHER HAVE STOPPED FUNCTIONING. INITIALLY IT WAS INTERMITTENT, BUT IT HAS FINALLY STOPPED WORKING”
“MULTIPLE PROBLEMS WITH REAR TAIL LIGHTS”
POWER TRAIN
3 NHTSA complaints · 2007-05 → 2008-03
“AUTOMATIC TRANSMISSION FAILED TO GO INTO DRIVE AND REVERSE GEARS. SLOW TO GO INTO GEAR”
“AFTER ONLY DRIVING THE CAR SOME 29,000 MILES THE TRANSMISSION WENT OUT”
“WHILE DRIVING 60 MPH, THE CLUTCH FAILED. THE CONTACT PULLED OFF THE FREEWAY AND PARKED THE VEHICLE”
AIR BAGS
4 NHTSA complaints · 2002-08 → 2007-08
“I HAVE AA2002 VW CABRIOLET AND THE AIR BAG LIGHT WENT ON. THE DIAGNOSTIC TEST SHOWED IT WAS THE DRIVER SIDE AIRBAG AND HARNESS”
“DRIVER'S AIRBAG DID NOT DEPLOY WITH AN IMPACT OF 30-35 MILES PER HOUR AND $6,000 DAMAGE TO THE FRONT END”
“VEHICLE HIT REAR OF A TRAILER AT 20-30 MPH. UPON IMPACT, NEITHER AIR BAG DEPLOYED”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Replace VW 502 00 / 508 00 spec full-synthetic oil every 10,000 miles. GTI/Golf R and Jetta GLI: 5,000 miles under hard driving. Never substitute non-spec oil — it cokes the EA888 PCV system.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 10,000 miles. Golf R and Tiguan with 4Motion AWD: 7,500 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect brake pads, rotors, and parking brake every 10,000 miles. GTI and Golf R front pads typically last 30,000-40,000 miles under spirited driving.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
DSG dual-clutch transmissions on GTI, Golf R, Jetta GLI, Tiguan, and Atlas Cross Sport: replace fluid and filter every 40,000 miles. VW spec G 052 182 (DQ250 wet clutch) or G 052 512 (DQ200 dry clutch) — never substitute. Skipping this destroys the mechatronic unit.
Estimated cost — typical U.S. ranges
Dealer
~$470–$640
Shop
~$330–$450
DIY
Pro only
VW/Audi DSG service needs a fluid-fill procedure at a specific temperature — shop equipment territory.
Tiguan 4Motion, Atlas 4Motion, Golf R: replace Haldex coupling fluid every 20,000 miles. Independent VW shops report Haldex pump failure within 60,000 miles when service is skipped.
Estimated cost — typical U.S. ranges
Dealer
~$220–$290
Shop
~$155–$205
DIY
~$40–$90
VW/Audi/Volvo AWD coupling — specific fluid required. Filter usually swapped at the same time.
Replace DOT 4 brake fluid every 2 years regardless of mileage. Required for ABS pump and electronic parking brake longevity.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Replace engine air filter every 40,000 miles. EA888 turbo engines: inspect every 20,000 miles to prevent boost leak symptoms.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Iridium spark plugs every 40,000 miles on TSI engines. Naturally aspirated VR6 and 2.5L 5-cylinder: 60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
EA888 Gen 1/2 (2008-2014) had timing chain tensioner failures — inspect by 80,000 miles. Gen 3 (2015+) and EA211 are upgraded designs with no scheduled service.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Pro only
Timing chains are normally lifetime. Listen for rattle on cold start — that's the actionable signal. Replacement is major work, quote separately.
Extends the life of your vehicle and improves comfort
Replace cabin air filter every 20,000 miles. Behind the glove box on Jetta, Passat, Golf, and Atlas.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
VW G13 coolant (lilac/pink) is labeled lifetime fill. Independent VW specialists recommend replacement every 5 years or 100,000 miles to prevent water pump impeller wear.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Occupant deaths in fatal crashes (FARS)
85 crashes 1990–2024
How the 85 occupant deaths break down
59
driver deaths
26
passenger deaths
85
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 2002 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
4
complaints mentioning a crash
3
complaints mentioning a fire
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2002 Volkswagen Cabrio reflects Volkswagen's published service intervals. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.