Wrench.Pro

2003 Ford Windstar Recalls, Problems & Maintenance

The 2003 Ford Windstar has no open NHTSA recalls. Owners report 5 recurring issue clusters, led by “Front subframe and engine cradle corrosion.” Ford uses the Intelligent Oil-Life Monitor (IOLM) to determine when oil changes are due based on actual driving load — not just mileage. Ford's published cap is 10,000 miles or 1 year, whichever comes first. The schedule below reflects Ford's Normal service intervals; F-Series trucks and Super Duty have additional towing-specific items.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2003 Ford Windstar.

Reported to NHTSA

Front subframe and engine cradle corrosion

STRUCTURE

12 NHTSA complaints · 2015-10 → 2025-04

“THE PASSENGER SIDE SUB FRAME HAS RUSTED THROUGH. THE DEALER HAD DONE THE RECALL REPAIR AND STILL RIGHT IN THE SPOT OF THE REPAIR THE SUB FRAME CRACKED AND SPLIT. FORD SAYS THERE IS NOTHING THEY CAN DO EVEN THOUGH THIS IS A KNOWN ISSUE AND THEIR REPAIR DIDN'T RESOLVE THE ISSUE”
— Owner report, NHTSA ODI #10970291
“The rear wheel well is corroded and the corrosion is into the structure that the seat belt is mounted to and it ruined the REM(rear electronic module) there is supposed to be a recall on it but all the ford garages say its been done but it hasn't”
— Owner report, NHTSA ODI #11429900

Read all complaints on NHTSA →

ABS control module cold solder joint failure

SERVICE BRAKES

26 NHTSA complaints · 2015-12 → 2024-07

“I HAVE THE FAMILIAR 9 C CODES FOR THE ABS CONTROL MODULE WITH THE COLD SOLDER JOINTS THAT EFFECTS THE ABS FUNCTION. THERE IS A 23 PAGE 2CARSPRO.COM FORUM WITH INDIVIDUALS SHARING THIS EXACT SAME ISSUE DEFECT ON THEIR WINDSTAR VEHICLES”
— Owner report, NHTSA ODI #11157183
“ANTI-LOCK BRAKING SYSTEM CONTROL MODULE FAILURE AT 102,000 MILES. APPEARS TO BE A CONTINUING TREND WITH VARIOUS FORD MODELS, AND REPAIR IS EXPENSIVE; APPROXIMATELY $2,000. IF ABS CONTROL MODULE IS FAILING, ABS NO LONGER WORKS”
— Owner report, NHTSA ODI #11000070

Read all complaints on NHTSA →

Transmission slipping and failure to engage

POWER TRAIN

8 NHTSA complaints · 2015-11 → 2022-05

“TRANSMISSION PROBLEM. THE TRANSMISSION WAS REPLACED 4 TIMES WITHIN 60K MILE INTERVAL WHILE FOLLOWING THE 30K TRANSMISSION FLUID FLUSH. A FLASHING O/D LIGHT COMES ON AND THE TRANSMISSION WILL DIE OUT OF NOWHERE AND THE PAST FEW TIMES IT HAS BEEN ON THE HIGHWAY GOING 75 MPH”
— Owner report, NHTSA ODI #11112950
“On May 23rd 2022 I was driving on interstate 45 the speed limit through where I was driving was 75 all of a sudden with no warning no engine light on my transmission stopped working and I could not break I was able to safely get over thank goodness but there is a recall”
— Owner report, NHTSA ODI #11465824

Read all complaints on NHTSA →

Erratic headlights, wipers, and instrument gauges

ELECTRICAL SYSTEM

10 NHTSA complaints · 2015-12 → 2019-01

“WHILE DRIVING AT NIGHT ON THE INTERSTATE OR ANY OTHER ROAD, THE HEADLIGHTS SUDDENLY WENT OFF FOR ABOUT 10 SECONDS. I HEARD A CLICKING SOUND UNDER THE LEFT SIDE OF THE DASH LIKE THE SOUND OF A RELAY ENGAGING. THIS HAPPENED SEVERAL TIMES”
— Owner report, NHTSA ODI #11005859
“STARTED HAVING WIPER ISSUES (INTERMITTENT DID NOT WORK) RANDOMLY FOR A COUPLE WEEKS, THEN HEADLIGHTS WENT OUT ON HIGHWAY AT NIGHT WITH NO OTHER CARS, FIRST FOR A COUPLE SECONDS OFF THEN ON THEN OFF FOR GOOD AFTER A FEW MORE SECONDS”
— Owner report, NHTSA ODI #11165003

Read all complaints on NHTSA →

Rear axle fracture after recall bracket repair

SUSPENSION

114 NHTSA complaints · 2015-09 → 2026-04

“The contact owns a 2003 Ford Windstar. The contact stated that while driving over a railroad track at 40 MPH, the rear axle snapped. The wheel hub to the axle was barely connected”
— Owner report, NHTSA ODI #11729112
“VEHICLE WAS IN MOTION AT 45MPH WHEN THE REAR AXLE FRACTURED COMPLETELY, CAUSING ME TO VEER INTO ONCOMING TRAFFIC (LUCKILY THERE WAS NO ACCIDENT)”
— Owner report, NHTSA ODI #11003646
“TL* THE CONTACT OWNS A 2003 FORD WINDSTAR. THE CONTACT STATED THAT THERE WAS A FAILURE IN WHICH THE REAR AXLE PREMATURELY CRACKED WITHOUT WARNING. THE DEALER REPAIRED THE VEHICLE ACCORDING TO NHTSA CAMPAIGN NUMBER: 12V195000 (SUSPENSION), BUT IT DID NOT REMEDY THE FAILURE”
— Owner report, NHTSA ODI #10787632

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 7,500 mi

Replace synthetic-blend or full-synthetic Motorcraft oil per the IOLM, or every 7,500-10,000 miles. EcoBoost engines require full synthetic; Coyote 5.0L V8 specifies SAE 5W-30.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 10,000 mi

Rotate tires every 10,000 miles, or with every other oil change. F-150 4x4 owners should rotate every 5,000-7,500 miles to even out drivetrain bias wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 10,000 mi

Inspect brake pads, rotors, and brake fluid level every 10,000 miles. Front pads on F-150 and Explorer typically last 40,000-60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

Ford specifies brake fluid replacement on an inspection basis, but moisture testing every 3 years is recommended. Replace if reading exceeds 3% water content.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace the engine air filter every 30,000 miles. EcoBoost turbocharged engines are sensitive to airflow restriction — don't extend.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 150,000 mi

Ford 6R80, 10R80, and 8F transmissions use Mercon LV fluid rated 150,000 miles under normal service. Severe service (towing, plowing) drops this to 60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD models)

Every 60,000 mi

On 4x4 models, replace transfer case fluid every 60,000 miles. Use Motorcraft XL-12 — do not substitute generic transfer case fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Rear Differential Fluid

Every 100,000 mi

F-Series and Expedition: replace rear axle fluid every 100,000 miles, or 50,000 miles if towing. Limited-slip rear ends require friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs

Every 100,000 mi

Iridium spark plugs on Coyote 5.0L, EcoBoost 2.7L/3.5L, and 2.3L are rated 100,000 miles. EcoBoost engines: never exceed the interval — gap erosion causes coil failure.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Coolant

Every 50,000 mi

Motorcraft Orange (Dex-Cool compatible) coolant: first change at 100,000 miles, then every 50,000. Older trucks with Yellow Motorcraft coolant: 50,000 miles throughout.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 20,000 mi

Replace the cabin air filter every 20,000 miles. On F-150, located behind the glove box; on Escape and Explorer, accessed from the passenger footwell.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

186 crashes 1990–2024

How the 186 occupant deaths break down

112

driver deaths

74

passenger deaths

186

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2002 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

33

complaints mentioning a crash

27

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2003 Ford Windstar reflects Ford's published service intervals and the Intelligent Oil-Life Monitor system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →