The 2004 Nissan Frontier has no open NHTSA recalls. Owners report 8 recurring issue clusters, led by “Steering stiffness and component failure.” Nissan owner's manuals split service into Schedule 1 (severe) and Schedule 2 (normal). Most US drivers fall under Schedule 1. The biggest preventable failure on Nissan vehicles is CVT transmission damage from extended fluid intervals — owners of Altima, Rogue, Sentra, Pathfinder, and Murano with CVT should not skip it.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 2004 Nissan Frontier.
STEERING
4 NHTSA complaints · 2010-01 → 2014-10
“POWERING STEERING BOX FAILURE ON A 2004 NISSAN FRONTIER. MY VEHICLE HAS ONLY 49,000 MILES ON IT AND WAS PURCHASED NEW”
“WHILE DRIVING APPROXIMATELY 60 MPH THE STEERING WHEEL BECAME VERY STIFF”
“WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING WHEEL JERKED VIOLENTLY AND THE VEHICLE BEGAN TO WANDER OUT OF ITS LANE”
POWER TRAIN
5 NHTSA complaints · 2004-03 → 2004-10
“WHEN DRIVING FROM 50- 70 MPH VEHICLE VIBRATED UNDER THE FLOOR BOARD. THE DEALER REPLACED THE DRIVE SHAFT, HOWEVER PROBLEM RECURRED”
“WHILE DRIVING 65 MPH VEHICLE VIBRATED UNCONTROLLABLY”
“BRAND NEW VEHICLE ON WAY HOME AFTER PURCHASE STARTED TO SHIMMY AND SHAKE AT SPEEDS BETWEEN 60-80 MPH ON OPEN HIGHWAY”
VEHICLE SPEED CONTROL, ENGINE
3 NHTSA complaints · 2005-04 → 2022-12
“This vehicle suddenly starts to accelerate on its own like it's in cruise control only it's not and I'm not pressing the gas pedal”
“I just started from a left hand turned at a stop light”
“ON THE INITIAL DATE OF 6/25/2004, I BEGAN TO NOTE THAT WHEN THE VEHICLE WAS OPERATING ON CRUISE CONTROL, DURING A DOWNSHIFT INTO A PASSING GEAR, SUCH AS CLIMBING A GRADE, THE MOTOR INCREASES TO 3500 RPMS”
FUEL SYSTEM, GASOLINE
3 NHTSA complaints · 2008-08 → 2009-01
“THE VEHICLE FAILED INSPECTION BECAUSE THE FUEL TANK WAS LEAKING VAPORS”
“I HAD IT CHECKED AND IT TURNS OUT THE GAS TANK/ HOSE CONNECTION TO THE TANK IS RUSTED CAUSING A FUME LEAK”
“THE CONTACT SMELLED FUEL COMING FROM THE VEHICLE WHILE IT WAS PARKED IN HIS GARAGE”
TIRES
3 NHTSA complaints · 2005-03 → 2008-07
“AFTER 28,000 MILES, THEY WOULD JUST PEEL OFF ON THE TOP LAYER AND LEAVE THE REST OF THE TIRE INTACT”
“I'VE HAD 2 GENERAL AW GRABBER TIRES LOSE THE TREAD ON ME WHILE DRIVING”
“THE REAR BF GOODRICH TIRE BLEWOUT ON THE CONSUMER'S NEW 2004 NISSAN FRONTIER”
EQUIPMENT
3 NHTSA complaints · 2006-02 → 2009-01
“CD PLAYER WILL NOT EJECT DISC ONLY MAKES CLICKING SOUNDS”
“CD PLAYER FAILURE. FAILS TO CD. ONLY CLICKING SOUND”
“MY CD PLAYER FAILS TO WORK THE TRUCK IS OUT OF WARRANTY BECAUSE I COMMUTE TO WORK FOR A LONG DISTANCE MY MILEAGE EXCEEDS THE WARRANTY NOW BEFORE THE 3 YEARS”
AIR BAGS
4 NHTSA complaints · 2009-04 → 2015-12
“MY TRUCK WAS IN AN ACCIDENT AND IT IS CONSIDERED A TOTAL LOSS. THE TRUCK WAS HIT ON THE LEFT SIDE AND THE AIR BAG DID NOT DEPLOY”
“I HAVE A 2004 NISSAN FRONTIER CREW CAB, LONG BED (6') AND THE AIR BAGS (BOTH DRIVER & PASSENGER) DID NOT DEPLOY. THE ENTIRE FRONT END OF THE TRUCK SUFFERED DAMAGE”
“THE CONTACT STATED THAT WHILE DRIVING 40 MPH, A DEER RAN OUT OF THE BUSH AND CRASHED INTO THE FRONT PASSENGER'S SIDE OF THE VEHICLE”
SERVICE BRAKES, HYDRAULIC, EQUIPMENT
3 NHTSA complaints · 2011-02 → 2014-04
“NISSAN 2004 FRONTIER XE BRAKES FAILED WITHOUT WARNING CAUSING A COLLISION INTO AN APARTMENT COMPLEX ENTRY SIGN MADE OUT OF CEMENT BLOCKS”
“BRAKE PEDAL WENT TO FLOOR WITHOUT THE TRUCK STOPPING”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Replace synthetic-blend or full-synthetic oil every 5,000 miles under Schedule 1. Schedule 2: 7,500 miles. VR30DDTT (3.0L twin-turbo): full synthetic only.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 5,000 miles. Front-wheel-drive Nissans (Altima, Sentra, Versa) wear front tires fast — don't skip rotations.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Nissan officially calls CVT fluid 'lifetime,' but independent technicians and Nissan TSBs recommend replacement every 60,000 miles to prevent CVT failure. Use Nissan NS-3 fluid only — substitutes destroy the belt-and-pulley system.
Estimated cost — typical U.S. ranges
Dealer
~$360–$500
Shop
~$255–$355
DIY
~$80–$180
CVT fluid is manufacturer-specific and pricey — do NOT substitute conventional ATF.
Inspect brake pads, rotors, and parking brake every 7,500 miles. Rogue and Pathfinder front pads typically last 35,000-50,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Replace DOT 3 brake fluid every 30,000 miles or 2 years. Dark or amber fluid indicates moisture contamination.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Replace engine air filter every 30,000 miles, sooner if driving on dusty unpaved roads.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Iridium-tipped spark plugs are rated 105,000 miles on QR25, MR20, and VQ35 engines. VR30DDTT: 60,000 miles due to higher cylinder pressures.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Nissan Long-Life Antifreeze/Coolant (blue/green): first change at 105,000 miles, then every 75,000. Do not mix with other coolant chemistries.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
On AWD and 4WD models, replace transfer case fluid and rear differential fluid every 60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
Extends the life of your vehicle and improves comfort
Replace cabin air filter every 15,000 miles. Located behind the glove box on Altima, Rogue, and Sentra.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Occupant deaths in fatal crashes (FARS)
146 crashes 1990–2024
How the 146 occupant deaths break down
123
driver deaths
23
passenger deaths
146
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 2004 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
8
complaints mentioning a crash
3
complaints mentioning a fire
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2004 Nissan Frontier reflects Nissan's published service intervals and the Maintenance Reminder system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.