The 2004 Suzuki Verona has no open NHTSA recalls. Owners report 6 recurring issue clusters, led by “Rear seat belt lock-up and retraction failure.” Suzuki stopped selling cars in the United States after 2013, though its motorcycle and marine business stayed. For owners the practical effect is that dealer service is gone and parts come through independent suppliers, so knowing what your car actually is saves money. The Samurai, Sidekick, Vitara, Grand Vitara, Swift, Esteem, Aerio, SX4, and Kizashi are Suzuki's own engineering, and their small four-cylinder engines are known for lasting when the oil is kept clean. The Forenza, Reno, and Verona were built by GM in Korea and take Daewoo-lineage parts. The Equator is a Nissan Frontier with a different grille, so Nissan specs apply to it. None of these have an oil life monitor, so the intervals below are fixed.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 2004 Suzuki Verona.
SEAT BELTS
8 NHTSA complaints · 2004-03 → 2011-06
“PASSENGER REAR SEAT BELTS ARE IN AN OUT POSITION, AND WILL NOT RETRACT”
“THE SEAT BELTS IN THE BACK SEAT WILL NOT WORK PROPERLY. I HAVE 2 OUT OF THE 3 TO LOCK UP AND NOT WORK”
“ALL THE SEAT IN THE BACKSEAT EXCEPT THE MIDDLE BELT HAVE STOPPED WORKING”
ENGINE AND ENGINE COOLING
6 NHTSA complaints · 2004-10 → 2011-10
“AT SPEEDS OF 65-75 MPH ON THE HIGHWAY AFTER ABOUT 15 MINUTES SLOWING DOWN TO GET OFF THE HIGHWAY, THE ENGINE IS LOUD AND SOUNDS LIKE A DIESEL ENGINE”
“NOTICED EARLY ON THAT THE ENGINE SOUNDED TOO LOUD”
“I AM HAVING SERIOUS PROBLEMS WITH MY LIFTERS WHERE THERE IS A CONTINUOUS RATTLING SOUND, AS WELL AS A CONTINUOUS TAPPING SOUND”
EXTERIOR LIGHTING
5 NHTSA complaints · 2004-09 → 2015-08
“THE CONTACT STATED WHILE ACTIVATING THE LEFT TURN SIGNAL AT ANY SPEED THE SWITCH FAILED TO DISENGAGE AFTER THE TURN IS COMPLETED”
“WHILE DRIVING TAIL LIGHTS FAILED INTERMITTENTLY”
“THE CONTACT STATED THAT THE HEADLIGHTS WOULD INTERMITTENTLY FAIL”
ENGINE AND ENGINE COOLING
83 NHTSA complaints · 2003-12 → 2019-10
“WHILE DRIVING AT ANY SPEED, THE VEHICLE WILL SUDDENLY SHUT OFF. THE VEHICLE WAS ABLE TO RESTART IMMEDIATELY AFTER THE FAILURE”
“VEHICLE CAN BE DRIVEN AT ANY SPEED AND IT WILL STALL. THIS WILL CAUSE VEHICLE TO LOSE STEERING AND BRAKING POWER”
“THE CONSUMER COMPLAINED ABOUT AN ONGOING STALLING PROBLEM WHENEVER THE VEHICLE CAME TO A STOP. THE CONSUMER WAS ABLE TO RESTART VEHICLE”
VEHICLE SPEED CONTROL
12 NHTSA complaints · 2004-04 → 2014-07
“THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE ACCELERATED WITHOUT WARNING CAUSING THE CONTACT TO CRASH”
“THE VEHICLE HESITATED TO ACCELERATE FROM A STOP AND SURGED FORWARD WHEN THE CONTACT APPLIED THE BRAKES”
“INCIDENTS HAVE OCCURRED WHERE THE CAR SURGES AND/OR STALLS WHILE IN OPERATION. WHEN USING CRUISE CONTROL THE CAR SURGES”
AIR BAGS
5 NHTSA complaints · 2003-10 → 2008-08
“AFTER BEING STRUCK BY ANOTHER VEHICLE, THEN STRIKING A CONCRETE POST, THE AIR BAGS DID NOT DEPLOY”
“DRIVER FRONT AIR BAG FAILED TO DEPLOY PROPERLY AFTER FRONTAL CRASH TEST ON 2003 SUZUKI VERONA WAS PERFORMED”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Suzuki published 3,750 miles under its severe schedule and 7,500 under normal use. Most American driving is severe by the manual's own definition, and these engines are small and work hard, so 3,750 to 5,000 miles is the honest number. Change once a year at minimum.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate every 7,500 miles. On the Samurai, Sidekick, Vitara, and Grand Vitara, check the spare too. These carry it outside on the tailgate, where sun and weather age it faster than the tires on the ground.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect pads, rotors, hoses, and lines at every service. Rear drums on the smaller cars and on the older four-wheel-drive models seize when a vehicle sits, and rusted hard lines are the common failure on anything that saw winter roads.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Replace every 2 years. Suzuki called for this in the manual and it is one of the few intervals here that is genuinely time-based rather than mileage-based.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Drain and fill every 45,000 miles. The fluid spec varies more than you would expect across this lineup: Suzuki automatic fluid on the older models, a specific CVT fluid on the Kizashi if it has the continuously variable transmission, GM Dexron on the Forenza, Reno, and Verona, and Nissan Matic fluid on the Equator. Confirm which one before service.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Around 60,000 miles on conventional plugs and up to 100,000 on iridium, depending on the engine. Replace the plug wires or coil boots at the same time on the older engines. Brittle insulation causes misfires that read as a failing coil.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Most Suzuki designed engines in this catalog use a timing chain, which is not a scheduled replacement item. A rubber belt does appear on some of the GM Korea built cars and on certain older engines. Check your specific engine before assuming either way, and if the car has a belt with no documented replacement, treat it as due.
Estimated cost — typical U.S. ranges
Dealer
~$935–$1175
Shop
~$655–$825
DIY
Pro only
On interference engines, a snapped belt destroys valves. Worth doing on schedule. Bundle water pump + tensioner — labor is already there.
Replace every 30,000 miles, or every 15,000 if you drive dusty or unpaved roads. Small engines are less forgiving of a restricted filter than large ones.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Applies to any four-wheel-drive model. Change every 30,000 miles, and immediately after any water crossing. These are real four-wheel-drive systems and the gear oil is cheap next to a transfer case.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
Extends the life of your vehicle and improves comfort
Every 3 to 5 years depending on the coolant type your car came with. Later models use a long-life green formula. Ask the shop to inspect the radiator end tanks and the hoses while it is drained, since plastic and rubber this old fail without much warning.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Test the battery and alternator once a year, and clean the ground connections while you are there. Corroded grounds are a frequent cause of odd electrical behavior on these.
Estimated cost — typical U.S. ranges
Dealer
~$225–$390
Shop
~$160–$280
DIY
~$130–$250
Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2004 Suzuki Verona reflects Suzuki's published service intervals. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.