Wrench.Pro

2005 Mitsubishi Lancer Recalls, Problems & Maintenance

The 2005 Mitsubishi Lancer has no open NHTSA recalls. Owners report 6 recurring issue clusters, led by “Electrical system malfunction.” Mitsubishi publishes short, conservative intervals: oil every 7,500 miles normal / 3,750 severe, and — unlike many rivals — an explicit CVT fluid replacement schedule rather than a 'lifetime fill' claim. Read the severe-service column honestly: stop-and-go city trips, short hops, and hot climates all qualify, and they describe how most Mirages actually live. The 10-year/100,000-mile powertrain warranty stays intact only with documented on-schedule service.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2005 Mitsubishi Lancer.

Reported to NHTSA

Electrical system malfunction

ELECTRICAL SYSTEM

2 NHTSA complaints · 2005-01 → 2019-05

“NO OUT OF THE ORDINARY EVENTS LEAD UP TO THE FAILURE. MY VEHICLE, WHICH IS A DAILY DRIVER CAR WOULD ONCE IN A WHILE "STUMBLE" THEN THROW A CHECK ENGINE LIGHT. AFTER THIS I WOULD GO TO MY DEALER OR AN AUTOSHOP AND HAVE THE "PULL THE CODE" USING A ODB II ERROR SCAN TOOL”
— Owner report, NHTSA ODI #10106279
“THE SIGNAL LIGHTS STOP WORKING ALSO THE HAZARDS. THE HORN REMAINS ON. A LOT OF PEOPLE SAY THAT IS A PROBLEM OF THE CAR INSIDE BODY THAT TAKE THE CONNECTOR OF THE JUNCTION BLOCK AND CORRODE THEM. A LOT OF PEOPLE HAVE THIS PROBLEMS. THE PROBLEM IS IN MOTION AND STATIONARY”
— Owner report, NHTSA ODI #11216924

Read all complaints on NHTSA →

Airbag non-deployment in crash

AIR BAGS

3 NHTSA complaints · 2007-06 → 2010-04

“I PURCHASED A 2005 LANCER AND MY DECISION FOR THE PURCHASE WAS BECAUSE OF THE 4 AIR BAGS. I TOTALED THE CAR AND ALL FOUR AIRBAGS DID NOT DEPLOY. THE CAR WAS TOTALED ON 6-3-07 WITH ALOT OF DAMAGE TO THE UNDERCARRIAGE. PLEASE EXPLAIN WHY THE AIRBAGS DID NOT DEPLOY. *AK”
— Owner report, NHTSA ODI #10193792
“TL*THE CONTACT OWNS A 2005 MITSUBISHI LANCER. WHILE DRIVING 60 MPH, THE CONTACT LOST CONTROL AND THE REAR DRIVER SIDE OF THE VEHICLE CRASHED INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. SHE SUSTAINED HEAD INJURIES AND THE VEHICLE WAS DESTROYED. AS OF SEPTEMBER 24, 2007, THE”
— Owner report, NHTSA ODI #10203999
“TL*THE CONTACT OWNS A 2005 MITSUBISHI LANCER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE CRASHED INTO THREE DEER. THE HEADLIGHTS WERE DESTROYED, THE FRONT FELL OFF OF THE VEHICLE, AND THE PASSENGER SIDE FENDER WAS PUSHED IN. THE AIR BAGS DID NOT”
— Owner report, NHTSA ODI #10327526

Read all complaints on NHTSA →

Airbag recall repair delay

AIR BAGS

5 NHTSA complaints · 2014-11 → 2018-02

“THE SRS LIGHT CAME ON IN MY LANCER. I HAVE BEEN TOLD BY THE MECHANIC THE PART WILL TAKE OVER A MONTH TO ARRIVE AS A RESULT OF A RECALL. I HAVE BEEN TOLD THAT THE AIR BAG NO LONGER WORKS. *TR”
— Owner report, NHTSA ODI #10660799
“TL* THE CONTACT OWNS A 2005 MITSUBISHI LANCER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V321000 (AIR BAGS); HOWEVER, THE PARTS NEEDED WERE NOT AVAILABLE. THE MANUFACTURER EXPECTED THE CONTACT TO SCHEDULE A REPAIR AT A DEALER THAT WAS OUT OF STATE AND NOT A”
— Owner report, NHTSA ODI #10726839
“RECEIVED NOTICE OF A RECALL ON THE PASS. SIDE AIRBAG. CALLED LOCAL DEALER, OUT OF BUSINESS (GREENVILLE MITSUBISHI). NEXT CLOSEST DEALER IS 2 COUNTIES AWAY (DON HERRING MITSUBISHI PLANO), SPOKE TO BENNY. SAID IT'S A 5-HOUR REPAIR AND THEY ARE OPEN ON SATURDAY, BUT WILL NOT”
— Owner report, NHTSA ODI #11071829

Read all complaints on NHTSA →

Premature brake pad wear

SERVICE BRAKES, HYDRAULIC

2 NHTSA complaints · 2005-11 → 2006-07

“BRAKE FAILURE AT 7032 MI BRAKES COMPLETELY METAL TO METAL LOSS OF MOST BRAKING FUNCTIONS VERY POOR RESPONSE TIME,BRAKE PADS REPLACED,BRAKE FAILURE AGAIN AT 13560 BRAKES AGAIN METAL TO METAL VERY POOR RESPONSE TIME,BRAKE PADS REPLACED AGAIN,BRAKE FAILURE AGAIN AT 18500 AGAIN”
— Owner report, NHTSA ODI #10142621
“2005 LANCER ES, MANUAL TRANSMISSION, PURCHASED 8-11-05 IN SOUTHERN CALIFORNIA. APPROXIMATELY 8,500 MILES, BEGAN TO HEAR RUBBING SOUNDS WHEN SLOWING FROM HIGH SPEED- THOUGHT IT NEEDED ALIGNMENT, SO TOOK IT IN, HAD WHEELS ALIGNED, AND ROTATED, (ALREADY HAD PREVIOUS ALIGNMENT AND”
— Owner report, NHTSA ODI #10162476

Read all complaints on NHTSA →

Front suspension and steering component detachment

SUSPENSION, STRUCTURE

3 NHTSA complaints · 2018-11 → 2025-11

“TL* THE CONTACT OWNS A 2005 MITSUBISHI LANCER. THE CONTACT STATED THAT THE CROSS MEMBER FRACTURED WITHOUT WARNING AND THE FRONT UPPER AND LOWER CONTROL ARMS DETACHED. THE VEHICLE WAS UNABLE TO BE DRIVEN DUE TO THE FAILURE. THE VEHICLE WAS TOWED TO BELL MITSUBISHI (1500 US-1,”
— Owner report, NHTSA ODI #11154033
“TL* THE CONTACT OWNS A 2005 MITSUBISHI LANCER. THE CONTACT STATED THAT THE CUP FROM THE BALL JOINTS, THE FRONT END, TIE ROD, UNKNOWN WIRING HARNESS AND THE DRIVER'S SIDE HEADLIGHT FAILED. THE VEHICLE WAS TAKEN TO AN UNKNOWN MITSUBISHI DEALER HOWEVER, WAS NOT DIAGNOSED NOR”
— Owner report, NHTSA ODI #11341985
“The steering column on my 2005 Mitsubishi Lancer ES detached while driving. The entire column dropped down from its mounting brackets, causing loss of control. This is a serious safety hazard. The mount bolts were intact previously, but they came loose or the bracket failed”
— Owner report, NHTSA ODI #11701340

Read all complaints on NHTSA →

Unintended acceleration

VEHICLE SPEED CONTROL

2 NHTSA complaints · 2007-10 → 2012-06

“TL*THE CONTACT OWNS A 2005 MITSUBISHI LANCER. WHILE STOPPED AT A TRAFFIC LIGHT, THE ACCELERATOR PEDAL SUDDENLY WENT STRAIGHT TO THE FLOOR. THE VEHICLE JERKED FORWARD AND THE ENGINE REVVED. THE CONTACT APPLIED THE BRAKES AND PLACED THE VEHICLE IN NEUTRAL TO PREVENT IT FROM”
— Owner report, NHTSA ODI #10206323
“TL* THE CONTACT OWNS A 2005 MITSUBISHI LANCER. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, SHE NOTICES THAT THE VEHICLE WAS ACCELERATING INDEPENDENTLY. THE CONTACT WAS ABLE TO SLOW DOWN THE VEHICLE BY UTILIZING THE EMERGENCY BRAKE. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND”
— Owner report, NHTSA ODI #10463616

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 7,500 mi

Replace every 7,500 miles normal / 3,750 severe. Mirage's 1.2L three-cylinder holds barely over 3 quarts — small sumps punish stretched intervals. 0W-20 on most recent models.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

CVT Fluid

Every 60,000 mi

Mitsubishi schedules CVT fluid replacement — commonly every 60,000 miles normal / 30,000 severe (check your year's table). Use only the specified CVT fluid (J4/CVTF-J4 family); generic ATF destroys the belt-and-pulley unit.

Estimated cost — typical U.S. ranges

Dealer

~$360–$500

Shop

~$255–$355

DIY

~$80–$180

CVT fluid is manufacturer-specific and pricey — do NOT substitute conventional ATF.

Tire Rotation

Every 7,500 mi

Rotate with every oil change. Light Mirages are easy on tires but the economy-focused OEM rubber wears fast when neglected.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors/drums, and lines at each service — Mirage G4 retains rear drums, which need periodic adjustment checks.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace every 2-3 years per the schedule. Cheap job, big ABS-unit insurance.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Spark Plugs

Every 60,000 mi

Iridium plugs commonly every 60,000 miles on the Mirage's 3A92 and Lancer's 4B11 — verify your year's table, as some engines list up to 105,000.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Air Filter

Every 15,000 mi

Mitsubishi's schedule replaces the engine air filter every 15,000 miles — shorter than most brands, and a 5-minute DIY on the Mirage.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Drive Belt

Every 60,000 mi

Inspect from 60,000 miles and replace on cracking. The Mirage's single serpentine belt also drives the A/C — a failure strands the car's accessories at once.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 15,000 mi

Replace every 15,000 miles, behind the glovebox. Often skipped at quick-lube visits — worth checking if airflow feels weak.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Coolant Replacement

Every 60,000 mi

First change around 60,000 miles, then roughly every 30,000-45,000 per the schedule. Mitsubishi long-life coolant or equivalent OAT for your year.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Battery Test & Service

Every 25,000 mi

Test annually after year 3. Small-battery economy cars have little reserve — the first cold snap finds a weak one.

Estimated cost — typical U.S. ranges

Dealer

~$225–$390

Shop

~$160–$280

DIY

~$130–$250

Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

66 crashes 1990–2024

How the 66 occupant deaths break down

42

driver deaths

24

passenger deaths

66

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2005 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

3

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2005 Mitsubishi Lancer reflects Mitsubishi's published service intervals. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →