Wrench.Pro

2006 Audi S4 Recalls, Problems & Maintenance

The 2006 Audi S4 has no open NHTSA recalls. Owners report 2 recurring issue clusters, led by “Headlight flicker and dipped-headlight shutoff.” Audi follows the VW Group Longlife service rhythm: oil and minor service every 10,000 miles or 12 months, whichever comes first, using oil that meets VW 502 00 / 504 00 (or 508 00 for newer 0W-20 engines) — generic synthetic does not qualify. S tronic dual-clutch gearboxes need fluid service every 40,000 miles despite 'lifetime fill' claims. Fully electric models (e-tron, e-tron GT) skip oil service entirely but keep brake-fluid, cabin-filter, and coolant-circuit intervals.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2006 Audi S4.

Reported to NHTSA

Headlight flicker and dipped-headlight shutoff

EXTERIOR LIGHTING

22 NHTSA complaints · 2009-12 → 2019-05

“PASSENGER HEADLIGHT STARTS ON. AFTER A FEW MINUTES I GET A HEADLIGHT DIPPED ERROR AND THE PASSENGER HEADLIGHT TURNS OFF”
— Owner report, NHTSA ODI #11207965
“RIGHT HEADLIGHT SPORADICALLY SHUTS OFF (I.E. DIPS) WHILE DRIVING. YOU HAVE TO TURN BOTH LIGHTS OFF AND ON WHEN YOU ARE DRIVING TO MAKE IT FUNCTION AGAIN”
— Owner report, NHTSA ODI #10795018
“WHEN DRIVING MY 2006 AUDI S4 AT NIGHT, ONE OR BOTH OF THE RIGHT OR LEFT FRONT DIPPED HEADLIGHTS WILL FLICKER, AND THEN TEMPORARILY FAIL”
— Owner report, NHTSA ODI #10308079

Read all complaints on NHTSA →

Takata airbag recall parts unavailable

AIR BAGS

7 NHTSA complaints · 2016-09 → 2018-07

“TAKATA RECALL NHSTA RECALL HV032, AUDI RECALL 69P6, JAN '17, LOCAL DEALER SAYS CANNOT COMPLETE RECALL WORK”
— Owner report, NHTSA ODI #11043412
“TAKATA RECALL. I RECEIVED MY FIRST NOTICE OF THIS RECALL ON 1/17/17. IT IS CURRENTLY 10/31/17 WITH THE REPAIR NOT YET AVAILABLE”
— Owner report, NHTSA ODI #11041664
“TL* TAKATA RECALL. THE CONTACT OWNS A 2006 AUDI S4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V382000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE”
— Owner report, NHTSA ODI #10927530

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (Longlife Service)

Every 10,000 mi

Replace oil and filter every 10,000 miles or 12 months with VW 502 00 / 504 00 / 508 00 spec oil. S and RS models driven hard: many owners shorten to 5,000-7,500 miles. Wrong-spec oil is the leading cause of TFSI timing-chain tensioner and PCV problems.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 10,000 mi

Rotate every 10,000 miles with the oil service. quattro models: keep all four tires within 4/32" of each other — mismatched wear stresses the center differential.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 10,000 mi

Inspect pads, rotors, and wear sensors every 10,000 miles. Audi uses electronic pad-wear sensors on most models — replace the sensor with the pads.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 24,000 mi

Replace DOT 4 brake fluid every 2 years regardless of mileage — Audi's published schedule is time-based because the fluid absorbs moisture.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

S tronic Dual-Clutch Fluid

Every 40,000 mi

S tronic (DSG) gearboxes on A3/S3/RS 3, Q3, TT, and many A5/Q5 models: replace fluid and filter every 40,000 miles with the VW Group-spec fluid for your gearbox code. Skipping this service is the most common cause of mechatronic failure.

Estimated cost — typical U.S. ranges

Dealer

~$470–$640

Shop

~$330–$450

DIY

Pro only

VW/Audi DSG service needs a fluid-fill procedure at a specific temperature — shop equipment territory.

Important maintenance

Keeps your vehicle running smoothly and efficiently

quattro Coupling Fluid (Transverse Models)

Every 40,000 mi

A3/S3/RS 3, Q3, and TT use a Haldex-style rear coupling: replace its fluid roughly every 40,000 miles (some model years specify sooner — check your manual). Longitudinal quattro (A5-A8, Q5, Q8) has no coupling service; see differential fluid instead.

Estimated cost — typical U.S. ranges

Dealer

~$220–$290

Shop

~$155–$205

DIY

~$40–$90

VW/Audi/Volvo AWD coupling — specific fluid required. Filter usually swapped at the same time.

Spark Plugs

Every 40,000 mi

TFSI turbo engines: new plugs every 40,000 miles. RS models with the 2.5 TFSI five-cylinder: consider 30,000 miles under track or hard street use.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Air Filter

Every 40,000 mi

Replace every 40,000 miles; inspect at 20,000 on turbocharged engines — a clogged filter shows up as sluggish boost response first.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Timing Chain (EA888 — Inspect Tensioner)

On condition / lifetime

2.0 TFSI (EA888) engines before roughly 2013 had timing-chain tensioner failures — have the tensioner revision checked by 80,000 miles on earlier cars. Later engines carry the updated design with no scheduled service.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Pro only

Timing chains are normally lifetime. Listen for rattle on cold start — that's the actionable signal. Replacement is major work, quote separately.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Differential Fluid (Longitudinal quattro)

Every 60,000 mi

Q5, Q8, and A5-A8 quattro: independent Audi specialists recommend front/rear differential fluid service around 60,000 miles even where Audi lists it as lifetime fill.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Dust & Pollen Filter

Every 20,000 mi

Replace the cabin air filter every 20,000 miles or 2 years. Audi specifies an activated-carbon filter on most models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

G12evo / G13 Coolant

On condition / lifetime

Audi coolant is labeled lifetime fill. Independent VW/Audi specialists recommend a refresh around 5 years or 100,000 miles to protect the water pump and thermostat housing — and only with the correct pink/lilac VW Group coolant.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

1 crashes 1990–2024

How the 1 occupant deaths break down

1

driver deaths

0

passenger deaths

1

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2015 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

0

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2006 Audi S4 reflects Audi's published service intervals and the Audi Service Interval Display system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →