Wrench.Pro

2006 Pontiac Vibe Recalls, Problems & Maintenance

The 2006 Pontiac Vibe has no open NHTSA recalls. Owners report 5 recurring issue clusters, led by “Power window regulator and glass failure.” Every Pontiac is now 15+ years old, which changes the maintenance question from 'what mileage?' to 'how old is it?' — hoses, belts, coolant, and brake fluid age out even on low-mile cars. The G6 uses GM's Oil Life System (change oil when the message appears, at most every 12 months) with Dex-Cool coolant and either the 2.4L Ecotec four or the 3.5/3.9L pushrod V6. Parts remain cheap and plentiful through GM's shared platforms — these cars are inexpensive to keep healthy if the age-based items aren't ignored.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2006 Pontiac Vibe.

Reported to NHTSA

Power window regulator and glass failure

VISIBILITY

5 NHTSA complaints · 2008-03 → 2025-12

“THE CONTACT STATED THAT AS HE OPENED THE FRONT DRIVER SIDE WINDOW, THERE WAS AN ABNORMAL SCRAPING FROM THE DOOR PANEL. AS HE CLOSED THE WINDOW, THE NOISE RECURRED AND THE CONTACT NOTICED A GROOVE SCRATCHED INTO THE WINDOW”
— Owner report, NHTSA ODI #10361537
“DRIVING ON LEVEL SURFACE, ROLLED DOWN PASSENGER SIDE FRONT WINDOW. SHARP CRACK AND THUD. WINDOW SEPARATED FROM MOUNTS AND FELL INTO DOOR FRAME. HAS HAPPENED 4 TIMES”
— Owner report, NHTSA ODI #10294348
“OVER THE PAST FEW MONTHS, THE DRIVER'S SIDE WINDOW WOULD RATTLE GOING UP OR DOWN AND THEN PROGRESSED TO NOT GOING COMPLETELY UP OR COMPLETELY DOWN WHEN I PRESSED THE BUTTON”
— Owner report, NHTSA ODI #10220544

Read all complaints on NHTSA →

Takata airbag recall parts unavailability

AIR BAGS

106 NHTSA complaints · 2011-03 → 2020-12

“I RECEIVED RECALL NOTICE GM#14491A IN JULY 2015 WARNING ME THAT THE PASSENGER AIR BAG INFLATION DEVICE MAY EXPLODE AND CAUSE SERIOUS INJURY OR DEATH TO THE FRONT PASSENGER. THE WARNING STATES NOT TO USE THE FRONT PASSENGER SEAT”
— Owner report, NHTSA ODI #10779128
“TL* THE CONTACT OWNS A 2006 PONTIAC VIBE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V286000 (AIR BAGS); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE”
— Owner report, NHTSA ODI #10745123
“PASSENGER SIDE AIRBAG WAS REPLACED WITH THE SAME RECALLED AIRBAG BY DEALER SAYING THE RECALLED PROBLEM WAS REPAIRED. NOW I FIND OUT 4 YEARS LATER THAT THE PROBLEM STILL HAS NOT BEEN REMEDIED”
— Owner report, NHTSA ODI #11338477

Read all complaints on NHTSA →

Airbag warning light illumination and non-deployment

AIR BAGS

13 NHTSA complaints · 2014-05 → 2020-10

“THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A GUARDRAIL. AS A RESULT, THE FRONT OF THE VEHICLE WAS DAMAGED AND THE FRONT DRIVER'S SIDE SEAT RAIL WAS FRACTURED. THE AIR BAGS DID NOT DEPLOY”
— Owner report, NHTSA ODI #10995100
“THE CONTACT STATED THAT THE AIR BAG LIGHT ON THE DRIVER SIDE REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE DRIVER SIDE AIR BAG NEEDED TO BE REPLACED”
— Owner report, NHTSA ODI #10733641
“FRONT PASSAGER AIR BAGS MAKING POPPING NOISES”
— Owner report, NHTSA ODI #10905833

Read all complaints on NHTSA →

Engine stalling and powertrain control module failure

ENGINE AND ENGINE COOLING, POWER TRAIN

34 NHTSA complaints · 2008-02 → 2023-01

“THE CONSUMER STATED ON JUNE 23, 2009, THE PCM UNIT FAILED ON THE VEHICLE AND IT HAD TO BE TOWED. THE REPAIR SHOP WAS INFORMED BY THE DEALER, THAT THE PCM UNIT WAS NOT UNDER WARRANTY, SO THE CONSUMER HAD TO PAY $429.30”
— Owner report, NHTSA ODI #10427255
“NO WARNING. DRIVING ON HWY. WHEN I THOUGHT I SEEN THE DASH FLASH, WENT OVER HILL LOST ALL POWER & ABILITY TO MANEUVER VEHICLE ON ICY HWY. VEHICLE HAD SHUT DOWN”
— Owner report, NHTSA ODI #10218590
“THE CONTACT WAS DRIVING 15 MPH AND ATTEMPTING A LEFT TURN WHEN THE VEHICLE STALLED WITHOUT WARNING. ANOTHER VEHICLE CRASHED INTO THE FRONT OF THE CONTACT'S VEHICLE”
— Owner report, NHTSA ODI #10352303

Read all complaints on NHTSA →

Brake failure and unintended acceleration

SERVICE BRAKES

8 NHTSA complaints · 2007-10 → 2020-01

“THE CONTACT STATED THAT WHILE ATTEMPTING TO MERGE INTO TRAFFIC SHE ENGAGED THE BRAKES BUT IT FAILED TO STOP THE VEHICLE. THE CONTACT MENTIONED THAT SHE HAD TO SHIFT INTO NEUTRAL IN ORDER TO MAINTAINED CONTROL OF THE VEHICLE”
— Owner report, NHTSA ODI #10479365
“THE CONTACT WAS DRIVING AT 10 MPH WHEN THE ACCELERATOR PEDAL BECAME STUCK IN THE OPEN THROTTLE POSITION. THE CONTACT STATED THE FAILURE WOULD OCCUR INTERMITTENTLY AND AS RESULT, THE CONTACT WAS INVOLVED IN TWO CRASHES”
— Owner report, NHTSA ODI #10349696
“THE CONTACT WAS STOPPED WITH THE BRAKES DEPRESSED AND THE VEHICLE IN DRIVE. WHEN REMOVING HIS FOOT FROM THE BRAKE PEDAL, THE VEHICLE INDEPENDENTLY ACCELERATED”
— Owner report, NHTSA ODI #10347623

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (Oil Life System)

Every 5,000 mi

Change when the Oil Life System calls it, and at least every 12 months. On engines this age, many mechanics suggest a practical 5,000-mile ceiling — aging seals and PCV systems contaminate oil faster.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate every 7,500 miles. Check tire date codes too — sidewall age (6+ years) retires tires on old cars before tread wear does.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors, and especially brake hoses and hard lines at every service — line corrosion is a real failure mode on 15-year-old northern cars.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 24,000 mi

Replace every 2 years. Decade-old fluid is the hidden cause of soft pedals and seized calipers on aging GM sedans.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Automatic Transmission Fluid (4T45-E / 4T65-E)

Every 45,000 mi

Drain-and-fill every 45,000 miles with Dexron VI. On high-mile units that have never been serviced, prefer repeated drain-and-fills over a pressure flush.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 100,000 mi

Iridium plugs at 100,000 miles on the G6's engines. Replace wires/boots on the pushrod V6 at the same time — they're brittle at this age.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Serpentine Belt & Tensioner

Every 60,000 mi

At this age, replace the belt AND tensioner as a pair on any evidence of cracking or noise — a weak tensioner eats new belts.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Engine Air Filter

Every 30,000 mi

Replace every 30,000 miles — a cheap, 5-minute job on the G6.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Coolant Replacement (Dex-Cool)

Every 100,000 mi

Dex-Cool is rated 5 years / 150,000 miles — but on cars this old the interval is effectively 'every 5 years.' Check for intake and water-pump seepage while it's drained; use Dex-Cool only, never mixed with green coolant.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Battery & Charging System Test

Every 25,000 mi

Test the battery and alternator annually. Parasitic drains from aging body modules are common on this era of GM — a healthy battery masks them until it doesn't.

Estimated cost — typical U.S. ranges

Dealer

~$225–$390

Shop

~$160–$280

DIY

~$130–$250

Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

78 crashes 1990–2024

How the 78 occupant deaths break down

62

driver deaths

16

passenger deaths

78

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2006 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

6

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2006 Pontiac Vibe reflects Pontiac's published service intervals and the GM Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →