Wrench.Pro

2007 Chevrolet Suburban Recalls, Problems & Maintenance

The 2007 Chevrolet Suburban has no open NHTSA recalls. Owners report 5 recurring issue clusters, led by “Takata airbag recall repair parts unavailable.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2007 Chevrolet Suburban.

Reported to NHTSA

Takata airbag recall repair parts unavailable

AIR BAGS

134 NHTSA complaints · 2017-06 → 2023-05

“TL* TAKATA RECALL. THE CONTACT OWNED A 2007 CHEVROLET SUBURBAN. WHILE DRIVING OUT OF THE DRIVEWAY AT 5 MPH AND MAKING A LEFT TURN, ANOTHER VEHICLE CRASHED INTO THE DRIVER'S SIDE WHEEL OF THE CONTACT'S VEHICLE. THE AIR BAGS FAILED TO DEPLOY”
— Owner report, NHTSA ODI #11281779
“TAKATA RECALL FOR MY 2007 SUBURBAN HAS NOT BEEN RESOLVED. I AM CONCERNED IF BEING IN A ACCIDENT, THE SAFETY OF MY PASSENGER IS AT SEVERE RISK”
— Owner report, NHTSA ODI #11115295
“TAKATA RECALL ISSUED JULY 2016 AND AIRBAGS HAVE NOT BEEN REPLACED AND IT IS JANUARY 2018”
— Owner report, NHTSA ODI #11061090

Read all complaints on NHTSA →

Dashboard cracking near passenger airbag area

UNKNOWN OR OTHER

30 NHTSA complaints · 2017-07 → 2026-04

“Cracked dashboard. Continues to get worse. Cracks get bigger and more cracks appear”
— Owner report, NHTSA ODI #11632929
“MY SUBURBANS DASH HAS CRACKED IN TWO SPOTS. ONE BY THE PASSENGER AIRBAG AND ONE TO THE LEFT/UPPER OF THE DRIVER SIDE CLUSTER”
— Owner report, NHTSA ODI #11301422
“THE DASH BOARD IS CRACKED IN MULTIPLE AREAS THAT COULD IMPACT THE PROPER AIRBAG DEPLOYMENT”
— Owner report, NHTSA ODI #11413410

Read all complaints on NHTSA →

AFM/DOD lifter failure causing engine misfire

ENGINE

13 NHTSA complaints · 2017-07 → 2026-08

“The engine has a collapsed lifter that has failed. This problem is placing us at risk of breaking down while driving”
— Owner report, NHTSA ODI #11544422
“WE HAVE A 2007 SUBURBAN WITH THE 5.3L ENGINE. AFTER, MUCH RESEARCH ON THE INTERNET, MY WIFE AND I HAVE FOUND THAT THERE EVIDENTLY IS A DESIGN FLAW WITH THE AFM LIFTERS”
— Owner report, NHTSA ODI #11004288
“ACTIVE FUEL MANAGEMENT (AFM) LIFTERS JAM/SEIZE CAUSING PUSH RODS TO REMAIN COLLAPSED AND CAUSING ENGINE MISFIRES THROUGHOUT THE ENGINE AND EXCESSIVE OIL BURNING, POSSIBLE DAMAGE TO CATALYTIC CONVERTERS, AND PREMATURE ENGINE WEAR”
— Owner report, NHTSA ODI #11175746

Read all complaints on NHTSA →

Electrical system malfunction and wiring failure

ELECTRICAL SYSTEM

10 NHTSA complaints · 2017-07 → 2025-10

“My suburban 2007 drains battery overnight, tried different alternator and batteries but continuously drains battery’s”
— Owner report, NHTSA ODI #11601299
“TL* THE CONTACT OWNED A 2007 CHEVROLET SUBURBAN. WHILE THE VEHICLE WAS PARKED, THE CONSOLE CAUGHT ON FIRE DUE TO AN ELECTRICAL SHORTAGE FROM THE CIGARETTE LIGHTER. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND FILED A REPORT”
— Owner report, NHTSA ODI #11175743
“THE CAR JUST SHUT OFF. IT'S NOW MAKING RANDOM CLICKING NOISES. STATIONARY”
— Owner report, NHTSA ODI #11364747

Read all complaints on NHTSA →

Steering and suspension corrosion and failure

STEERING

4 NHTSA complaints · 2020-10 → 2024-04

“The contact owns a 2007 Chevrolet Suburban. The contact stated while driving at various speeds, the vehicle lost power steering assist. The contact stated that the failure was only experienced whenever the vehicle was slowed to approximately 5 MPH”
— Owner report, NHTSA ODI #11452261
“Customer has a 2007 Suburban, the steering angle sensor is faulty causing diagnostic trouble code C0455 and traction control inoperative , tested sensor directly to verify fault, the part is no longer available from GM nor aftermarket”
— Owner report, NHTSA ODI #11427758
“I HAVE THIS VEHICLE FOR ONLY A YEAR I WENT TO GET MY BRAKES DONE TO BE TOLD BY THE MECHANIC THAT IT NEEDS WORK ON THE SUSPENSION FROM RUST ALMOST MY WHOLE ENTIRE SUSPENSION SYSTEM AND A AUTO SHOP TOLD MY FINANCE COMPANY THAT THERE ARE NO PROBLEMS BUT CLEARLY THERE IS”
— Owner report, NHTSA ODI #11372348

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

On 4WD models, replace transfer case fluid every 45,000 miles — sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

73 crashes 1990–2024

How the 73 occupant deaths break down

40

driver deaths

33

passenger deaths

73

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2007 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

6

complaints mentioning a crash

12

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2007 Chevrolet Suburban reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →