Wrench.Pro

2007 Jeep Wrangler Recalls, Problems & Maintenance

The 2007 Jeep Wrangler has no open NHTSA recalls. Owners report 6 recurring issue clusters, led by “Manual transmission pops out of first gear.” Jeep vehicles use the Oil Change Indicator system to signal when oil is due. Wrangler and Gladiator owners who actually use 4WD off-road should treat the schedule below as Schedule A (severe) — water crossings, sand, and rock crawling demand differential and transfer case service at half the published intervals. Grand Cherokee and Cherokee follow the standard Mopar schedule.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2007 Jeep Wrangler.

Reported to NHTSA

Manual transmission pops out of first gear

POWER TRAIN

7 NHTSA complaints · 2016-12 → 2020-05

“VEHICLE WILL JUMP OUT OF 1ST GEAR AFTER 10 FEET INTO AN INTERSECTION WHEN TAKING OFF FROM A STOP, LEAVING YOU IN THE MIDDLE OF ONCOMING SIDE TRAFFIC WHILE IN NEUTRAL. I HAVE ALMOST BEEN HIT MULTIPLE TIMES”
— Owner report, NHTSA ODI #10991628
“I HAVE A 2007 JEEP WRANGLER WITH A MANUAL TRANSMISSION. RECENTLY IT HAS STARTED TO OCCASIONALLY AND VIOLENTLY POP OUT OF FIRST GEAR. THE ISSUE ONLY HAPPENS FROM A STANDSTILL INTO A ROLLING START SUCH AS AT A STOP SIGN OR TRAFFIC LIGHT”
— Owner report, NHTSA ODI #11268017

Read all complaints on NHTSA →

Takata airbag recall repair parts unavailable

AIR BAGS

50 NHTSA complaints · 2016-06 → 2025-03

“I HAVE A CURRENT RECALL FOR A DEFECTIVE AIRBAG IN MY 2007 JEEP WRANGLER. THE AIRBAG IS CURRENTLY NOT OPERATIONAL. EVERY 1-2 MINUTES WHILE DRIVE THE AIRBAG LIGHT WILL COME ON AND DING. THIS IS A SERIOUS SAFETY ISSUE AND IT MAKES THE VEHICLE INCREDIBLY ANNOYING TO DRIVE”
— Owner report, NHTSA ODI #11342604
“TL* THE CONTACT OWNS A 2007 JEEP WRANGLER. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 16V290000 (AIR BAGS) THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR”
— Owner report, NHTSA ODI #11013320
“CLOCKSPRING FAILURE. AIRBAG LIGHT BLINKS AND CHIMES IN NORMAL DRIVING. NOT OFFROAD. PART IS INFERIOR AND NEEDS TO BE REPLACED SEVERAL TIMES OVER THE LIFE OF THE VEHICLE. *TR”
— Owner report, NHTSA ODI #10933760

Read all complaints on NHTSA →

Fuel overflow from filler neck during refueling

FUEL/PROPULSION SYSTEM

29 NHTSA complaints · 2016-07 → 2022-06

“DURING REFUELING, WHEN TANK IS FULL FUEL OVERFLOWS OUT OF THE FILLER AS THE PUMP SHUTS OFF. EVERY TIME AT EVERY GAS STATION. VERY DANGEROUS, GAS ON THE SIDE OF JEEP AND ON THE GROUND”
— Owner report, NHTSA ODI #11140143
“WHEN EVER I FILL UP THE FUEL TANK IT OVER FLOWS OR SPITS UP GAS, AFTER THE GAS PUMP SHUTS OFF”
— Owner report, NHTSA ODI #11062309
“PUMPING GAS TO FILL THE TANK ALWAYS OVERFLOWS. THE SENSOR THAT TELLS THE PUMP TO SHUT OFF DOESN'T WORK CAUSING GAS TO OVERFLOW ALL OVER THE CAR, MYSELF AND THE GROUND. WHAT A WASTE OF PRICEY GAS”
— Owner report, NHTSA ODI #10885976

Read all complaints on NHTSA →

High-speed steering and suspension wobble

STEERING, SUSPENSION

24 NHTSA complaints · 2016-06 → 2024-10

“JEEP DEATH WOBBLE IN MY 2007 JEEP WRANGLER. NO RHYME OR REASON, CAR WILL BEGIN TO VIOLENTLY SHAKE BETWEEN 45 - 65 MPH. I HAVE TO COMPLETELY STOP AND PULL CAR TO SIDE OF ROAD IN ORDER TO MAKE THIS STOP”
— Owner report, NHTSA ODI #10954312
“MY JEEP IS EXPERIENCING THE "DEATH WOBBLE". IT ALMOST TURNED OVER ON I-85 OUTSIDE OF ATLANTA. MY DAUGHTER WAS DRIVING AT 55MPH AND THERE WAS A SMALL DIP IN THE ROAD. THE JEEP BEGAN TO SHAKE UNCONTROLLABLY. SHE COULD HARDLY CONTROL THE STEERING WHEEL OR THE JEEP”
— Owner report, NHTSA ODI #11173008
“VEHICLE IS EXHIBITING AN UNSAFE SPEED WOBBLE WHILE DRIVING ABOVE 40 MPH, VEHICLE ONLY HAS 50K MILES, I ALREADY HAD ALL OF THE SUSPENSION COMPONENTS REPLACED AND THE CONDITION REMAINS”
— Owner report, NHTSA ODI #10876310

Read all complaints on NHTSA →

TIPM-linked electrical and stalling failures

ELECTRICAL SYSTEM

15 NHTSA complaints · 2017-01 → 2026-08

“NO TURN SIGNALS, NO PARKING LIGHTS, NO HORN, DOORS DO NOT UNLOCK/ LOCK, CRANKS FOR SEVERAL SECONDS BEFORE STARTING OR DOES NOT START, HAZARD INDICATORS TURN ON WITHOUT PROMPTING. THESE ISSUES MAKE FOR EXTREMELY DANGEROUS DRIVING. DEALER SAID I NEED A TIPM REPLACEMENT”
— Owner report, NHTSA ODI #11281299
“TL* THE CONTACT OWNS A 2007 JEEP WRANGLER. THE CONTACT STATED WHILE DRIVING AT 55 MPH, WHEN THE ENGINE STALLED. THE CONTACT STATED THE WINDSHIELD WIPERS AND HEAD LIGHTS FLICKERED. THE CONTACT SAW SMOKE COMING FROM UNDER THE FRONT OF THE VEHICLE AND SAW FIRE SHORTLY AFTER”
— Owner report, NHTSA ODI #11217088
“THE VEHICLE WILL NOT SHUT OFF. DROVE IT INTO THE CARPORT TURNED OFF THE IGNITION AND THE VEHICLE WOULD NOT STOP RUNNING, EVEN WITH THE KEY TURNED OFF AND REMOVED FROM THE IGNITION... ALL GAUGES WERE RANDOMLY TURNING ON AND OFF, AND THE HORN WAS INTERMITTENTLY BLARING”
— Owner report, NHTSA ODI #11161839

Read all complaints on NHTSA →

Brake pedal loss and ABS module failure

SERVICE BRAKES

7 NHTSA complaints · 2016-11 → 2025-09

“ABS UNIT FAILED. YELLOW DASHBOARD WARNING LIGHT ILLUMINATED. RED BRAKE WARNING LIGHT WAS NOT ILLUMINATED. THE BRAKE PEDAL WHEN PUSHED TRAVELED TO THE FLOOR. FRONT WHEEL BRAKES BECAME COMPLETELY INOPERATIVE AS VERIFIED BY JACKING UP THE FRONT WHEELS AND TESTING”
— Owner report, NHTSA ODI #11256117
“TL* THE CONTACT OWNS A 2007 JEEP WRANGLER. WHILE DRIVING AT 10 MPH, THE BRAKES FAILED WITHOUT WARNING AS A RESULT, THE CONTACT COLLIDED WITH ANOTHER VEHICLE. NO INJURIES OCCURRED AND A POLICE REPORT WAS NOT FILED”
— Owner report, NHTSA ODI #11245470

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 8,000 mi

Pentastar 3.6L: SAE 0W-20 every 8,000 miles. Wrangler 392 6.4L HEMI: SAE 5W-20 every 8,000 miles. EcoDiesel 3.0L: 10,000 miles. 4xe plug-in hybrid: 8,000 miles or annually.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 8,000 mi

Rotate tires every 8,000 miles. Wrangler with 33+ inch off-road tires: rotate every 5,000 miles to prevent uneven wear from solid axles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 8,000 mi

Inspect pads, rotors, and parking brake every 8,000 miles. Wrangler and Gladiator pads wear faster than Grand Cherokee due to higher curb weight per axle.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Front Differential Fluid

Every 60,000 mi

Replace front differential fluid every 60,000 miles. Wrangler off-road use (water crossings, sand): inspect every 30,000 miles for water contamination.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Rear Differential Fluid

Every 60,000 mi

Rear axle fluid every 60,000 miles. Limited-slip differentials require Mopar friction modifier. Wrangler Rubicon with locking differentials: same schedule.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Transfer Case Fluid (4WD)

Every 60,000 mi

Replace transfer case fluid every 60,000 miles. Use Mopar ATF+4 for NV3500 and NV245. Wrangler Rock-Trac: 60,000 mi normal, 30,000 mi with regular off-road use.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Brake Fluid

Every 24,000 mi

Replace DOT 3 brake fluid every 2 years regardless of mileage. Wrangler off-road use accelerates moisture intake — annual fluid testing recommended.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Automatic Transmission Fluid (ZF 8HP)

Every 60,000 mi

Severe service: ZF 8HP fluid every 60,000 miles. Normal: 120,000 miles. Use Mopar ATF+4 — never substitute.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Engine Air Filter

Every 30,000 mi

Replace engine air filter every 30,000 miles. Wrangler driven in dust or sand: inspect at every oil change and replace early.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Spark Plugs

Every 100,000 mi

Pentastar 3.6L: 16 spark plugs total, replace at 100,000 miles. Wrangler 392 6.4L HEMI: 16 plugs at 100,000 miles. EcoDiesel: glow plug inspection only.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Mopar HOAT Coolant

Every 50,000 mi

Mopar HOAT (purple) for gas engines: first change at 100,000 miles, then every 50,000. Do not mix with green or orange coolants.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 20,000 mi

Replace cabin air filter every 20,000 miles. Grand Cherokee, Cherokee, and Compass: behind the glove box. Wrangler/Gladiator: optional cabin filter on later models only.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

91 crashes 1990–2024

How the 91 occupant deaths break down

65

driver deaths

26

passenger deaths

91

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2007 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

24

complaints mentioning a crash

32

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2007 Jeep Wrangler reflects Jeep's published service intervals and the Oil Change Indicator system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →