Wrench.Pro

2007 Mercury Milan Recalls, Problems & Maintenance

The 2007 Mercury Milan has no open NHTSA recalls. Owners report 4 recurring issue clusters, led by “Brake pedal travel to floor after ABS activation.” Ford closed Mercury in 2011, which is good news for owners: nearly every part is a Ford part. The Grand Marquis is a Crown Victoria, the Sable is a Taurus, the Mountaineer is an Explorer, the Milan is a Fusion, and the Mariner is an Escape. Any competent Ford shop can work on one, and parts pricing follows the Ford volume. Two models break the pattern. The Villager is a rebadged Nissan Quest with a Nissan V6 and a timing belt that must be replaced on schedule. The Mariner Hybrid carries the same high-voltage battery and continuously variable transaxle as the Escape Hybrid, so it needs a shop with hybrid training. Cars from roughly 2007 on use Ford's Intelligent Oil-Life Monitor. Earlier ones run fixed intervals.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2007 Mercury Milan.

Reported to NHTSA

Brake pedal travel to floor after ABS activation

SERVICE BRAKES, HYDRAULIC

60 NHTSA complaints · 2017-12 → 2023-06

“Brake pedal going almost to the floor once, then later did so again and almost didn’t stop, almost crashed”
— Owner report, NHTSA ODI #11499446
“The contact owns a 2007 Mercury Milan. The contact stated while pulling out of the driveway, the contact depressed the brake pedal because of an oncoming vehicle however, the vehicle failed to stop as needed”
— Owner report, NHTSA ODI #11486957
“WHILE DRIVING NORMALLY ON HIGHWAY BRAKES FAILED , PEDAL WENT TO FLOOR NO BRAKING . PUMPED BRAKES PEDAL HEIGHT CAME BACK UP AND SEEMED TO WORK NORMALLY AFTER . SCARED TO DEATH , NO CONFIDENCE IN BRAKES . HAPPENED TODAY 2/27/2020 . RECEIVED RECALL NOTICE ON BRAKES LAST WEEK”
— Owner report, NHTSA ODI #11311974

Read all complaints on NHTSA →

Takata airbag inflator recall parts unavailability

AIR BAGS

125 NHTSA complaints · 2017-10 → 2022-03

“RECEIVED NOTICE OF RECALL MARCH 2017. WAITING FOR PARTS. RECALL SHOULD BE DONE IN A TIMELY MANNER THIS IS TAKING TOO LONG”
— Owner report, NHTSA ODI #11098400
“TAKATA RECALL - RECEIVED RECALL LETTER JUNE 2016...PARTS STILL NOT AVAILABLE OCTOBER 2017”
— Owner report, NHTSA ODI #11035589
“TAKATA RECALL - IT HAS BEEN 2 YEARS WITH NO PARTS AVAILABLE. MY WIFE IS NOW RIDING IN THE BACK SEAT WITH OUR INFANT. WHAT ARE OUR OTHER OPTIONS TO GET THIS FIXED? 2 YEARS SEEMS A BIT RIDICULOUS FOR SUCH A SERIOUS ISSUE”
— Owner report, NHTSA ODI #11092065

Read all complaints on NHTSA →

Sudden loss of engine power at highway speed

VEHICLE SPEED CONTROL

6 NHTSA complaints · 2018-09 → 2023-05

“WHILE DRIVING AT INTERSTATE SPEEDS, THERE IS A SUDDEN DROP IN POWER (LIMP MODE), AFTER RESETTING THE CAR FULL POWER IS RESTORE. ERROR CODE REFERS TO THROTTLE BODY SENSORS”
— Owner report, NHTSA ODI #11131137
“MY WRENCH LIGHT CAME ON AND CAR SHIFTS HARD AND WON'T GO INTO OVERDRIVE”
— Owner report, NHTSA ODI #11161807
“The car will lose speed and I have to try to get off the highway with out being slammed by other vehicles it is extremely dangerous and I have seen lots of people are having the same problem PLEASE FIX THIS PROBLEM BEFORE WE GET KILLED”
— Owner report, NHTSA ODI #11427677

Read all complaints on NHTSA →

Engine stall from ignition coil and PCM failure

POWER TRAIN

5 NHTSA complaints · 2018-01 → 2019-08

“MY MOM WAS DRIVING ON THE FREEWAY AT 65-70/MPH AND ALL OF A SUDDEN THE CAR JERKED AND SHUT OFF WHILE IT WAS ROLLING DOWN THE ROAD. THERE WAS NO WARNING! SHE COULD HAVE BEEN KILLED! THE CAR SUDDENLY LOST ACCELERATION POWER AND THE WHEEL LOCKED UP ON HER”
— Owner report, NHTSA ODI #11245076
“ISSUE WITH PCM BEING SHORT CIRCUITED. RESULTING IN HAVING TO REPLACE IGNITION COILS, FUEL INJECTOR AND PCM. VEHICLE WAS IN THE PROCESS OF ACCELERATING, STOPPED ACCELERATING, AND STARTED RUNNING TERRIBLY. KEPT CUTTING OFF AND CHECK ENGINE LIGHT FLASHED AND EVENTUALLY STAYED ON”
— Owner report, NHTSA ODI #11115068
“SERPENTINE BELT COME OFF MAKING THE CAR UNABLE TO DRIVE. OIL ACCUMULATES ON THE BELT PULLEY CAUSES THE BELT TO COME OFF”
— Owner report, NHTSA ODI #11091748

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 5,000 mi

On 2007 and later models, follow the Intelligent Oil-Life Monitor and change at least once a year. Earlier cars were specified at 5,000 miles under Ford's severe schedule, which covers most real driving. Given the age of these engines, 5,000 miles is the sensible ceiling either way.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 5,000 mi

Rotate every 5,000 miles, and every oil change on the rear-drive Grand Marquis and Marauder, where the rear tires wear faster. Check sidewall date codes as well, since age retires tires on these cars before tread depth does.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors, hoses, and lines at every service. The Panther platform cars under the Grand Marquis are heavy, and rear rotors and parking brake hardware seize on cars that sit.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace every 3 years. Ford did not always publish this as a hard interval, but water in old fluid is the reason aging calipers drag and ABS units fail.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Timing Belt (Villager only)

Every 105,000 mi

This applies only to the 1993 to 2002 Villager, which uses a Nissan 3.0 or 3.3 V6 with a rubber timing belt due at 105,000 miles. Every other Mercury in this catalog uses a timing chain that is not a scheduled item. If you drive a Villager and cannot document the belt, budget for it now.

Estimated cost — typical U.S. ranges

Dealer

~$935–$1175

Shop

~$655–$825

DIY

Pro only

On interference engines, a snapped belt destroys valves. Worth doing on schedule. Bundle water pump + tensioner — labor is already there.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Automatic Transmission Fluid

Every 50,000 mi

Drain and fill every 50,000 miles. Fluid type matters here: Mercon V for most of the lineup, Mercon LV on later models, and the Villager takes Nissan-spec fluid. The wrong fluid causes shudder and eventually failure.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 100,000 mi

100,000 miles on platinum plugs. On the 4.6 V8 in the Grand Marquis, plugs left in aluminum heads for a decade can seize and break on removal. A shop that soaks them and works them out cold is worth the extra labor hour.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Air Filter

Every 30,000 mi

Replace every 30,000 miles, or sooner on dusty roads. Straightforward on every model in the lineup.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Coolant Replacement

Every 100,000 mi

Every 5 years on a car this age. Ford used a gold or yellow long-life coolant on later models and green on earlier ones. Have the shop pressure test at the same time. The plastic intake manifold crossover on some 1996 to 2001 4.6 V8s is a known coolant leak point.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Axle Fluid (rear-drive and 4WD models)

Every 100,000 mi

Applies to the Grand Marquis, Marauder, Mountaineer, and any four-wheel-drive model. Change every 100,000 miles, or every 30,000 if you tow. Limited-slip axles need the friction modifier added.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Battery & Charging System Test

Every 25,000 mi

Test annually. On the Mariner Hybrid this is the 12-volt battery only. The high-voltage pack is a separate system and should be checked by a hybrid-trained shop.

Estimated cost — typical U.S. ranges

Dealer

~$225–$390

Shop

~$160–$280

DIY

~$130–$250

Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

79 crashes 1990–2024

How the 79 occupant deaths break down

57

driver deaths

22

passenger deaths

79

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2007 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

17

complaints mentioning a crash

5

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2007 Mercury Milan reflects Mercury's published service intervals and the Intelligent Oil-Life Monitor system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →