Wrench.Pro

2007 Toyota Yaris Recalls, Problems & Maintenance

The 2007 Toyota Yaris has no open NHTSA recalls. Owners report 7 recurring issue clusters, led by “Rear axle beam corrosion and failure.” Toyota's owner's manual splits service into Schedule 1 (severe) and Schedule 2 (normal). Most US drivers fall under Schedule 1 because it covers short trips, extreme temperatures, dusty roads, or heavy idling. The intervals below reflect Schedule 1 — the schedule Toyota recommends for typical real-world use.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2007 Toyota Yaris.

Reported to NHTSA

Rear axle beam corrosion and failure

SUSPENSION

10 NHTSA complaints · 2018-03 → 2024-08

“The rear axle has failed due to corrosion. Loss of right rear wheel assembly was narrowly avoided. Noticed the wheel was squatting oddly and upon inspection the wheel assembly was nearly removed by hand”
— Owner report, NHTSA ODI #11526903
“REAR AXLE BEAM CRACKED ON LEFT SIDE AT A WELD, NOTICED VEHICLE NOT TRACKING PROPERLY AND HAD CHECKED AT A SHOP AND THEY FOUND THIS”
— Owner report, NHTSA ODI #11311482
“REAR AXLE CORROSION CAUSED THE REAR DRIVER'S SIDE WHEEL TO FALL OFF. THANKFULLY THIS HAPPENED JUST AS THE VEHICLE WAS BEING PARKED. THE ENTIRE REAR AXLE ASSEMBLY NEEDED TO BE REPLACED. VEHICLE REPAIRED BY L&M AUTO OF EAST OTIS, MA 01029”
— Owner report, NHTSA ODI #11080081

Read all complaints on NHTSA →

Front control arm bolt corrosion

SUSPENSION

7 NHTSA complaints · 2012-01 → 2016-09

“CLUNKING NOISE HEARD DURING VEHICLE OPERATION OVER ROADWAY BUMPS OR APPLICATION OF BRAKES. INSPECTED TO FIND FRONT LOWER CONTROL ARM BOLT CORRODED AND CRACKED”
— Owner report, NHTSA ODI #10851243
“BOLTS THAT HOLDS A-ARMS ARE GONE RUSTED COMPLETELY OFF SUSPENSION IS POPPING TOYOTA REFUSES TO FIX THE PROBLEM EVEN AFTER KNOWING IT?S A MANUFACTURING DEFECT ESTIMATED COST FOR REPAIR IS 2,500+ FOR A 7 YEAR OLD CAR THAT ONLY HAS 132K MILES”
— Owner report, NHTSA ODI #10664835
“DURING ROLLING BUMPER TO BUMPER TRAFFIC, HEARD A LOUD POP FROM THE FRONT END. AFTERWARDS THE FRONT END KEPT MAKING A ODD GRIND SOUND WHEN I PUT ON THE BRAKES OR WENT OVER A SLIGHT BUMP”
— Owner report, NHTSA ODI #10504554

Read all complaints on NHTSA →

Seat belt retractor and latch failure

SEAT BELTS

10 NHTSA complaints · 2012-02 → 2022-05

“The contact owns a 2007 Toyota Yaris. The contact stated that the front driver's side and the front passenger's side seat belts failed to latch securely”
— Owner report, NHTSA ODI #11463308
“VEHICLE PARKED, SEAT BELT WILL NOT RETRACT, WILL STAY OUT UNTIL I FEED IT BACK TO THE SLOT. I HAVE A COUPLE OF YEARS WITH THIS PROBLEM HOPING THAT THERE WAS GOING TO BE A RECALL”
— Owner report, NHTSA ODI #11142488
“TL* THE CONTACT OWNS A 2007 TOYOTA YARIS. THE CONTACT STATED THAT THE REAR PASSENGER SEAT BELT DETACHED WHILE FASTENING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SEAT BELT WAS OLD AND NEEDED TO BE REPLACED”
— Owner report, NHTSA ODI #10969636

Read all complaints on NHTSA →

Rear wheel ABS sensor corrosion

SERVICE BRAKES

15 NHTSA complaints · 2012-01 → 2019-10

“THERE IS A WELL-KNOWN DEFECT ON TOYOTA YARIS MODELS (USA MODEL YEARS 2007 TO PRESENT) THAT OCCASIONALLY IN COLD, SNOWY WEATHER, THE REAR ABS CONNECTOR WILL HAVE DEBRIS 'GUNK UP' THE CONNECTION, DISABLING THE ABS - OBVIOUSLY A VERY HUGE SAFETY ISSUE IN THE WINTER”
— Owner report, NHTSA ODI #10490478
“ABS AND EMERGENCY BRAKE LIGHT INDICATORS TURNED ON AND STAYED ON. BROUGHT CAR INTO MECHANIC, TOLD CODE C0215 WAS SHOWN - REAR SPEED SENSOR LH CIRCUIT - AND THAT TOYOTA HAS ISSUED A TECHNICAL SERVICE BULLETIN (TSB) AS THIS IS APPARENTLY A COMMON PROBLEM FOR THE 2007-2008 YARIS”
— Owner report, NHTSA ODI #10445040
“DROVE CAR TO TRAIN STATION DURING SNOW STORM. VEHICLE SAT PARKED ALL DAY. CLEANED OFF SNOW THAT EVENING AND BEGAN DRIVE HOME. SEVERAL MINUTES INTO TRIP BOTH ABS AND BRAKE LIGHTS ILLUMINATED”
— Owner report, NHTSA ODI #10563366

Read all complaints on NHTSA →

Takata airbag recall part unavailability

AIR BAGS

46 NHTSA complaints · 2016-07 → 2019-06

“TAKATA RECALL RECEIVED WRITTEN AUTHORIZATION FROM CORPORATE TOYOTA TO UNDERGO A ZONE A TAKATA RECALL REPAIR”
— Owner report, NHTSA ODI #10944170
“TAKATA RECALL - HAS BEEN 3.5 MONTHS NOT ALLOWED TO USE FRONT PASSENGER SEAT. NO REMEDY TO DATE FOR THIS HIGH RISK FLORIDA CAR”
— Owner report, NHTSA ODI #10905487
“TAKATA RECALL. WE HAVE BEEN WAITING FOR MORE THAN THREE MONTHS FOR A FIX. MEANWHILE, WE ARE NOT ALLOWED TO USE THE FRONT, RIGHT (PASSENGER) SEAT. IT'S AS IF 25% OF OUR CAR IS MISSING!”
— Owner report, NHTSA ODI #10901968

Read all complaints on NHTSA →

Airbag warning light from spiral cable failure

AIR BAGS

18 NHTSA complaints · 2012-04 → 2015-01

“AIRBAG WARNING LIGHT. DIAGNOSTIC CODE 51 SUGGESTS SPIRAL CABLE PROBLEM”
— Owner report, NHTSA ODI #10564488
“THE AIR BAG WARNING LIGHT BLINKED ON THE WENT OUT. NOW IT IS ON ALL THE TIME. TOYOTA DEALER SAYS IT IS A CLOCK SPRING IN THE STEERING COLUMN THAT HAS GONE BAD”
— Owner report, NHTSA ODI #10516066
“TL* THE CONTACT OWNS A 2007 TOYOTA YARIS. THE CONTACT WAS DRIVING 30 MPH WHEN THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER CONFIRMED THE SPIRAL CABLE ASSEMBLY FAILED AND NEEDED TO BE REPLACED”
— Owner report, NHTSA ODI #10454138

Read all complaints on NHTSA →

Airbag non-deployment during a crash

AIR BAGS

14 NHTSA complaints · 2012-02 → 2022-09

“Side-impact on the passenger side, car flipped over and landed upside down. Airbags did not deploy”
— Owner report, NHTSA ODI #11486785
“TL* THE CONTACT OWNS A 2007 TOYOTA YARIS. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS SHE LOST CONTROL OF THE VEHICLE DUE TO ICY ROADS. THE CONTACT CRASHED INTO A TELEPHONE POLE AND UPON IMPACT THE AIR BAGS DID NOT DEPLOY”
— Owner report, NHTSA ODI #10495189
“THE OPERATOR WAS DRIVING A 2007 TOYOTA YARIS (4-DOOR SEDAN) AROUND A SLIGHT TURN IN THE ROADWAY AT APPROXIMATELY 35 TO 40 MPH WHEN THE VEHICLE ENCOUNTERED "BLACK ICE" AND LOST TRACTION”
— Owner report, NHTSA ODI #10447230

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 5,000 mi

Replace 0W-20 full-synthetic oil and filter every 5,000 miles under Schedule 1, or 10,000 miles under Schedule 2. Toyota covers the first 2 oil changes through ToyotaCare.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 5,000 mi

Rotate tires every 5,000 miles. Toyota recommends rotation at every oil change to maximize tire life on FWD and AWD models.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 5,000 mi

Inspect brake pads, rotors, and parking brake every 5,000 miles. Toyota recommends measuring pad thickness at each service.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 36 months. Critical for the integrity of the ABS, VSC, and brake assist systems.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace the engine air filter every 30,000 miles. Earlier under Schedule 1 if driven on unpaved roads.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 60,000 mi

Toyota labels ATF as 'lifetime fill' on most automatics, but recommends inspection and replacement every 60,000 miles under severe service. Use Toyota WS or Type-IV — no substitutes.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 120,000 mi

Toyota iridium-tipped spark plugs are rated for 120,000 miles. Earlier replacement reduces fuel economy and can cause misfires on direct-injection engines.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Super Long Life Coolant (SLLC)

Every 50,000 mi

Toyota SLLC (pink): first change at 100,000 miles, then every 50,000 miles. Do not substitute green or orange coolant — it will damage the cooling system seals.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 30,000 mi

Replace the cabin air filter every 30,000 miles, sooner in dusty climates. Located behind the glove box on most Toyota and Lexus models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Serpentine / Drive Belt Inspection

Every 60,000 mi

Inspect the serpentine belt and tensioner every 60,000 miles. Toyota uses long-life EPDM belts that rarely fail before 100,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Timing Chain — No Replacement

On condition / lifetime

Toyota's 2AR-FE, 2GR-FKS, A25A-FKS, and most Toyota engines built since 2010 use a timing chain rated for the life of the engine. No scheduled replacement.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Pro only

Timing chains are normally lifetime. Listen for rattle on cold start — that's the actionable signal. Replacement is major work, quote separately.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

228 crashes 1990–2024

How the 228 occupant deaths break down

180

driver deaths

48

passenger deaths

228

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2006 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

41

complaints mentioning a crash

6

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2007 Toyota Yaris reflects Toyota's published service intervals and the Maintenance Required Light system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →