Wrench.Pro

2009 GMC Sierra 2500 Recalls, Problems & Maintenance

The 2009 GMC Sierra 2500 has no open NHTSA recalls. Owners report 7 recurring issue clusters, led by “Door lock actuator failure.” GMC trucks and SUVs use the GM Oil Life System (OLS) — the same algorithm as Chevrolet. Because GMC's lineup is exclusively trucks and SUVs, severe-service intervals apply to most owners (towing, hauling, off-roading). The schedule below surfaces the items most relevant to GMC's truck-focused buyer.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2009 GMC Sierra 2500.

Reported to NHTSA

Door lock actuator failure

ELECTRICAL SYSTEM

7 NHTSA complaints · 2011-09 → 2016-09

“POWER LOCKS QUIT WORKING HAVE TO USE THE KEY TO OPEN DOORS”
— Owner report, NHTSA ODI #10598656
“AT APPROXIMATELY 65,000 MILES THE PASSENGER SIDE DOOR LOCK ACTUATOR QUIT WORKING. THE LOCK DOES NOT OPERATE WITH THE AUTOMATIC DOOR LOCK ON THE DRIVER SIDE DOOR LOCK FUNCTION OR THE KEYPAD”
— Owner report, NHTSA ODI #10653772
“I HAVE A 2009 GMC SIERRA 2500 WITH 39,200 MILES. MY DOOR LOCK ACTUATOR QUIT WORKING, SO MY DOOR NO LONGER AUTOMATICALLY LOCKS AND UNLOCKS WHICH I CONSIDER TO BE A SAFETY HAZARD”
— Owner report, NHTSA ODI #10473261

Read all complaints on NHTSA →

Door handle fracture and chrome separation

STRUCTURE, LATCHES/LOCKS/LINKAGES

3 NHTSA complaints · 2014-12 → 2016-11

“TL* THE CONTACT OWNS A 2009 GMC SIERRA. THE CONTACT STATED THAT THE CHROME PLATING WAS SEPARATING FROM ALL OF THE INTERIOR DOOR HANDLES. THE CONTACT MENTIONED THAT THE PARTS THAT WERE STICKING OUT WERE VERY SHARP”
— Owner report, NHTSA ODI #10664269
“TL* THE CONTACT OWNS A 2009 GMC SIERRA. THE CONTACT STATED THAT THE FRONT DRIVER SIDE DOOR HANDLE FRACTURED. THE CONTACT STATED THAT THE DOOR HAD TO BE OPENED FROM THE OUTSIDE OF THE VEHICLE”
— Owner report, NHTSA ODI #10682875

Read all complaints on NHTSA →

StabiliTrak fault and engine power reduction

TRACTION CONTROL SYSTEM, ENGINE

8 NHTSA complaints · 2014-06 → 2025-01

“When I am driving in town I have an indication message that comes up and says engine power reduced”
— Owner report, NHTSA ODI #11638925
“TL* THE CONTACT OWNS A 2009 GMC SIERRA. THE CONTACT STATED THAT WHILE DRIVING AT ANY SPEED, THE SERVICE TRACTION CONTROL AND THE STABILIZER TRACK CONTROL WARNING LIGHTS ILLUMINATED”
— Owner report, NHTSA ODI #10849999
“ABOUT 2 MONTHS AFTER WE PURCHASED OUR PRE-OWNED 2009 GMC SIERRA DENALI WE STARTED HAVING PROBLEMS WITH THE ENGINE POWER AND ALL SENSORS GOING OFF”
— Owner report, NHTSA ODI #10597321

Read all complaints on NHTSA →

Air bag recall repair parts unavailable

AIR BAGS

4 NHTSA complaints · 2020-07 → 2025-08

“Local dealer is not repairing my recall. I keep getting told parts are not available and this has gone on for years”
— Owner report, NHTSA ODI #11678524
“Takata Recall. The contact owns a 2009 GMC SIERRA. The contact stated that the "Service airbag notification" warning light had illuminated onthe instrument panel”
— Owner report, NHTSA ODI #11421861
“TL* THE CONTACT OWNS A 2009 GMC SIERRA 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS) HOWEVER, THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE”
— Owner report, NHTSA ODI #11338455

Read all complaints on NHTSA →

Air bag warning light illumination and deployment failure

AIR BAGS

7 NHTSA complaints · 2014-05 → 2023-02

“The contact owns a 2009 GMC Sierra. The contact stated that while driving at an undisclosed speed, the air bag warning light was illuminated”
— Owner report, NHTSA ODI #11507624
“The contact owns a 2009 GMC Sierra 1500. The contact stated while driving at 45 MPH, he crashed into the driver's side of another vehicle. The air bags failed to deploy”
— Owner report, NHTSA ODI #11439348
“The contact called on behalf of a GM dealer where he is employed. He stated that a customer had dropped off his 2009 GMC Sierra to be serviced for NHTSA Campaign Number: 21V052000 (Air Bags)”
— Owner report, NHTSA ODI #11436802

Read all complaints on NHTSA →

Dashboard cracking and rattling

STRUCTURE

9 NHTSA complaints · 2011-02 → 2020-09

“3 CRACKS APPEARED IN THE TOP OF THE DASH. ONE 2" LONG RUNNING FROM THE AIR BAG COVER FORWARD TO EDGE OF DASH SECTION”
— Owner report, NHTSA ODI #10562780
“MY DASHBOARD IS DISINTEGRATING. IT STARTED WITH A FEW HAIRLINE CRACKS, BUT NOW THERE ARE FIST SIZED HOLES IN MY DASHBOARD, AND IT IS FULL OF CRASKS”
— Owner report, NHTSA ODI #10717350
“I HAVE HAD A RATTLE IN THE DASHBOARD OF MY 2009 GMC FROM ABOUT TWO WEEKS AFTER PURCHASE. I HAVE HAD IT IN FOR REPAIR 7 TIMES IN THE YEAR 1 YEAR 5 MONTHS OF OWNERSHIP”
— Owner report, NHTSA ODI #10380195

Read all complaints on NHTSA →

Accelerator pedal sticking and unintended acceleration

VEHICLE SPEED CONTROL

3 NHTSA complaints · 2012-08 → 2016-03

“TL* THE CONTACT OWNS A 2009 GMC SIERRA 2500. THE CONTACT STATED THAT THE ACCELERATOR PEDAL BECAME STUCK INTERMITTENTLY”
— Owner report, NHTSA ODI #10633165
“TL* THE CONTACT OWNS A 2009 GMC SIERRA. THE CONTACT STATED THAT THERE WAS A DELAY WHENEVER HE ATTEMPTED TO ACCELERATE, ONCE IT ENGAGED THE VEHICLE ACCELERATED UNEXPECTEDLY”
— Owner report, NHTSA ODI #10471876
“TRUCK WAS AT FULL THROTTLE BRAKES WOULD NOT STOP TRUCK DIESEL ENGINE OVER POWERED BRAKES. FOUND GAS PEDDLE UNDER FLOOR MAT LUCKLY I PUT IN NUTERAL AND TURNED OFF IGN GLAD MY WIFE OR KIDS WERE NOT DRIVING DEATH TRAP”
— Owner report, NHTSA ODI #10845529

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when OLS reaches 0% or every 12 months. dexos1-approved synthetic required on Sierra 1500 5.3L/6.2L; dexos2 specified on Duramax diesel.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Sierra and Yukon owners running 4x4 should rotate every 5,000-7,500 miles to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors, and parking brake every 7,500 miles. Towing accelerates pad wear by 30-50%; check more often if towing regularly.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

DOT 3 brake fluid: test annually, replace when moisture exceeds 3% or fluid is darker than copper.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

Long-life cellulose filter rated 45,000 miles. Trucks driven on unpaved roads or construction sites should inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (towing 5,000+ lbs regularly, heavy stop-and-go): every 45,000 miles. Normal: 97,500 miles. Use Dexron-VI for 6L80/6L90, Mobil 1 LV ATF HP for 10L80/10L1000.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

On 4WD models, replace every 45,000 miles. Use GM Auto-Trak II for active 4WD; GM 9986115 for selectable 4WD.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Differential Fluid (front + rear)

Every 50,000 mi

Replace front and rear axle fluid every 50,000 miles, or 25,000 miles if towing. G80 limited-slip rear axles require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs

Every 100,000 mi

Iridium spark plugs on the L83/L84 5.3L and L86/L87 6.2L V8 are rated 100,000 miles. AFM/DFM cylinder deactivation can cause uneven plug wear — check at 75,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000. Duramax diesel uses ELC (red) — different chemistry, do not mix.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace cabin air filter every 22,500 miles. Sierra HD and Yukon XL owners in dusty work environments should replace at 15,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

128 crashes 1990–2024

How the 128 occupant deaths break down

102

driver deaths

26

passenger deaths

128

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2010 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

4

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2009 GMC Sierra 2500 reflects GMC's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →