Wrench.Pro

2010 Chevrolet Malibu Recalls, Issues & Maintenance

The 2010 Chevrolet Malibu carries 4 open NHTSA recalls — most recently covering inflator module and wiring. Owners report 4 recurring issue clusters, led by “Electric power steering assist loss.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

4 Open Recalls

Source: NHTSA

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Campaign #19V019000 · Jan 16, 2019

Issue: General Motors LLC (GM) is recalling certain 2010-2011 Chevrolet Malibu vehicles. In the event of a crash necessitating deployment of the driver frontal air bag, the air bag inflator may explode due to being overpressurized.

Risk: If the inflator explodes, sharp metal fragments may strike the driver or other occupants resulting in serious injury or death.

Fix: GM has notified owners, and dealers will replace the front driver air bag module, free of charge. The recall began February 25, 2019. Owners may contact GM customer service at 1-800-522-9559. GM's number for this recall is N182206630.

ELECTRICAL SYSTEM:WIRING

Campaign #14V252000 · May 14, 2014

Issue: General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Risk: Any of the above failure conditions increases the risk of a crash.

Fix: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

STEERING

Campaign #14E044000 · Jul 21, 2014

Issue: Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.

Risk: A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.

Fix: Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.

POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)

Campaign #12V460000 · Sep 18, 2012

Issue: General Motors (GM) is recalling certain model year 2007-2010 Saturn Aura and model year 2008-2010 Chevrolet Malibu and Pontiac G6 vehicles, equipped with a 4-speed automatic transmission. On these vehicles, the tabs on the transmission shift cable end may fracture and separate.

Risk: If the tabs were to fracture and separate, the shift lever and the actual position of the transmission gear may not match. The driver would be able to move the shifter to 'PARK' and remove the ignition key, but the transmission gear may not be in 'PARK.' The vehicle may not be able to be restarted and the vehicle could roll away after the driver has exited the vehicle, resulting in a possible crash without prior warning.

Fix: GM will notify owners, and dealers will install a retainer over the cable end or replace the shift cable as necessary. This service will be performed free of charge. Notification to owners began on on November 9, 2012. Owners were instructed to not bring their vehicles for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2010 Chevrolet Malibu.

Reported to NHTSA

Electric power steering assist loss

STEERING

64 NHTSA complaints · 2020-03 → 2026-07

“The contact owns a 2010 Chevrolet Malibu. The contact stated that while driving 30 MPH, the steering wheel was shaking and locked up, and the steering wheel became difficult to turn. The vehicle lost power steering functionality. The power steering warning light was illuminated”
— Owner report, NHTSA ODI #11751580
“Hello I am very upset I was driving down the street normal day then all of a sudden my steering wheel got hard to turn... Then esc/power steering light came on. My steering wheel does shakes a little because it's dangerous to drive. I called to the Chevy dealership they said”
— Owner report, NHTSA ODI #11512149
“The contact owns a 2010 Chevrolet Malibu. The contact stated that while her son was driving at approximately 60 MPH, the power steering failed, and the steering wheel had become very difficult to turn to the left or right. The contact stated her son was able to pull off the road”
— Owner report, NHTSA ODI #11509587

Read all complaints on NHTSA →

Brake lights illuminate without pedal applied

ELECTRICAL SYSTEM, EXTERIOR LIGHTING, SERVICE BRAKES

22 NHTSA complaints · 2020-08 → 2026-01

“This is in reference to GM Recall Number: 13036 - I noticed that from time to time the service traction warning comes on, service esc warning comes on, my cruise control stops working suddenly. I didn't think anything of it until I finally noticed my brake lights were”
— Owner report, NHTSA ODI #11632002
“Brake lights stay on when not even pressing the brake pedal. This causes cruise control to shut off too. Sometimes "Service ESC" and "Traction Control" light will come on randomly too. Had taken it to Chevy dealership multiple times to have this issue fixed but problems seems to”
— Owner report, NHTSA ODI #11522375
“TL* THE CONTACT OWNS A 2010 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE REAR BRAKE LIGHT FAILED TO ILLUMINATE BUT WHEN THE BRAKE PEDAL WAS DEPRESSED THE BRAKE WARNING LIGHT ILLUMINATED. IN ADDITION, THE SERVICE TRAC START WARNING LIGHT”
— Owner report, NHTSA ODI #11351553

Read all complaints on NHTSA →

Headlight bulb and wiring harness failure

ELECTRICAL SYSTEM, EXTERIOR LIGHTING

14 NHTSA complaints · 2020-03 → 2024-09

“Passenger side low beam headlight wiring harness connector keeps melting even after replacement. Noticed online that many owners are experiencing the same issue. Replaced harness multiple times and same issue reoccurs after two to three weeks of use”
— Owner report, NHTSA ODI #11526313
“I HAVE HAD TO REPLACE MY PASSENGER AND DRIVERS SIDE HEADLIGHTS FOR THE 5TH TIME IN THE LAST 3 YEARS. JUST REPLACED THE PASSENGER HEADLIGHT LAST WEEK AND EXACTLY A WEEK LATER, IT IS BACK OUT ON THE SAME SIDE, 6TH TIME. IN THE PAST, I'VE HAD BOTH REPLACED WHEN ONE BLOWS OUT”
— Owner report, NHTSA ODI #11320067
“REPEATING HEADLAMP FAILURE. BULBS HAVE BEEN REPLACED THREE TIMES IN PAST YEAR. BOTH BULBS (DRIVER AND PASSENGER SIDES) HAVE BEEN REPLACED DURING SERVICE THOUGH ONLY ONE HAD FAILED, IN HOPES OF EXTENDING TIME BETWEEN THE NEXT REQUIRED SERVICE. HEADLAMP BULB REPLACEMENT ON THIS”
— Owner report, NHTSA ODI #11319746

Read all complaints on NHTSA →

Engine power reduced warning with sudden power loss

ELECTRICAL SYSTEM

10 NHTSA complaints · 2020-05 → 2026-07

““Engine Power Reduced” comes on suddenly, alongside numerous other lights (check engine, service traction, ESC, etc). This causes the vehicle to reduce speed in traffic, increasing risk of collision. Other models of Chevy Malibu have been recalled for this same issue (faulty”
— Owner report, NHTSA ODI #11453275
“The contact owns a 2010 Chevrolet Malibu. The contact stated that while driving over rough roads, the vehicle displayed a Service Traction, Service EFC and EFC Off, and Engine Power Reduced messages. After coming to a complete stop and then the attempting to accelerate, the”
— Owner report, NHTSA ODI #11498043
“WHILE TRAVELING AT 60 MPH, LOST POWER FOR A SPLIT SECOND THEN REGAINED. ABOUT 5 MILES TOWARD DESTINATION, AT A TRAFFIC LIGHT I WAS ATTEMPTING TO MAKE A RIGHT TURN & WHEN I ACCELERATED, THE CAR COMPLETELY DIED WITH LINE OF TRAFFIC BEHIND ME. SHOULD THIS CAR HAVE DIED IN THE MIDST”
— Owner report, NHTSA ODI #11389510

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

219 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

41

complaints mentioning a crash

14

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2010 Chevrolet Malibu reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →