Wrench.Pro

2010 Chevrolet Tahoe Recalls, Issues & Maintenance

The 2010 Chevrolet Tahoe carries 4 open NHTSA recalls — most recently covering inflator module. Owners report 4 recurring issue clusters, led by “Automatic transmission failure.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

4 Open Recalls

Source: NHTSA

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Campaign #21V050000 · May 2, 2021

Issue: General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Fix: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Campaign #21V054000 · May 2, 2021

Issue: General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Fix: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Campaign #21V053000 · May 2, 2021

Issue: General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Fix: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.

EQUIPMENT

Campaign #10E043000 · Mar 9, 2010

Issue: MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT OF A CRASH.

Risk: AN IMPROPERLY DEPLOYED AIRBAG COULD RESULT IN SERIOUS INJURY.

Fix: MARATHON WILL NOTIFY OWNERS OF RECORD AND REPLACE THE SEAT COVER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 14, 2010. OWNERS MAY CONTACT MARATHON AT 1-800-735-2769.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2010 Chevrolet Tahoe.

1 active NHTSA investigation

Source: NHTSA

  • Desiccated Air Bag Inflator Rupture

    Action #EA21002 · opened Sep 17, 2021

    From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 200…

    View on NHTSA →

Reported to NHTSA

Automatic transmission failure

POWER TRAIN

3 NHTSA complaints · 2021-03 → 2025-10

“Transmission failure knocking and pinging would not go in reverse would only go 10 mph. Vehicle has never been abused only has 128,428 miles”
— Owner report, NHTSA ODI #11444608
“In 2023, the vehicle’s transmission failed completely at only 128,000 miles. After researching the issue, I discovered that the 6L80E transmission installed in this model year has a long history of mechanical failures”
— Owner report, NHTSA ODI #11693610
“LIFTERS COLLAPSED, MOTOR BLEW ON THE HIGHWAY AT 60MPH CAUSING LARGE ACCIDENT ON SHOULDER”
— Owner report, NHTSA ODI #11398640

Read all complaints on NHTSA →

Cracked dashboard near airbag

UNKNOWN OR OTHER

130 NHTSA complaints · 2016-08 → 2024-08

“Dash board is cracking around passanger side air bag and above instrument panel. Could shatter into pieces upon air bag deployment sending shards of dashboard flying. Could lacerate air bags”
— Owner report, NHTSA ODI #11606965
“MY 2010 CHEVY TAHOE HAS DEVELOPED A CRACK IN THE UPPER DASH AREA BETWEEN THE PASSENGER SIDE AIR BAG AND THE DEFROST OUTLET. THERE WAS NO OUTSIDE INFLUENCE THAT CAUSED THE CRACK AND I'M VERY CONCERNED THAT THIS IS A SAFETY ISSUE IN THE EVENT OF AN ACCIDENT”
— Owner report, NHTSA ODI #11015334
“I NOTICED THAT THE DASH IN MY 2010 CHEVROLET TAHOE LTZ IS CRACKED ABOVE THE AIR BAG ON PASSENGER SIDE. I ALSO HAVE READ WHERE THIS IS SOMETHING THAT IS HAPPENING TO LOT OF TAHOES , SUBURBANS AND YUKONS ETC”
— Owner report, NHTSA ODI #10924049

Read all complaints on NHTSA →

Takata airbag recall parts delay

AIR BAGS

44 NHTSA complaints · 2017-01 → 2025-02

“TAKATA RECALL I WAS NOTIFIED IN JULY 2016 THAT MY VEHICLE WAS INVOLVED IN THIS RECALL. I HAVE CALLED CHEVROLET SEVERAL TIMES OVER THE LAST YEAR AND 5 MONTHS AND THEY DO NOT HAVE THE PARTS TO REPAIR IT”
— Owner report, NHTSA ODI #11055054
“Takata recall. The contact owns a 2010 Chevrolet Tahoe. The contact received notification of NHTSA Campaign Number: 21V050000 (Air Bags) however, the part to do the recall repair was not yet available”
— Owner report, NHTSA ODI #11501252
“"TAKATA RECALL" WHAT IS TAKING SO LONG TO ISSUE THE GM RECALL. TAKATA BELIEVES THAT THE GM AIRBAGS HAVE THE SAME ISSUES THAT OTHER MANUFACTURERS' AIRBAGS HAVE HAD, BUT THE NHTSA IS DRAGGING ITS FEET REGARDING THE ISSUANCE OF THE RECALL”
— Owner report, NHTSA ODI #11149699

Read all complaints on NHTSA →

Electrical stall and power loss while driving

ELECTRICAL SYSTEM

8 NHTSA complaints · 2017-08 → 2021-11

“WE HAVE A 2010 TAHOE. 3 YEARS AGO WE REPLACED THE BATTERY. AFTER THAT THE VEHICLE HAS BEEN HAVING THE FOLLOWING ISSUES. 1. EVERY 3-4 MONTHS THE CAR DIES WHILE DRIVING. DOOR LOCKS, LIGHTS, RADIO, ETC TURN ON AND OFF RAPIDLY WHILE DRIVING”
— Owner report, NHTSA ODI #11012005
“THE CAR HAS STALLED ON THE FREEWAY AND/OR BUSY ROADS MULTIPLE TIMES. IT WAS VERY DANGEROUS TIMING”
— Owner report, NHTSA ODI #11328438
“WHILE DRIVING IN TOWN OR HIGHWAY , DOOR LOCKS BEGAN POPPING UP AND DOWN, DASH GAUGES WERE GOING CRAZY AND CAR BEGAN TO BE LOSE TOTAL ELECTRICAL POWER. ENGINE CUT OUT AND DIED AND ALMOST REAR ENDED BY SEMI-TRUCK”
— Owner report, NHTSA ODI #11291029

Read all complaints on NHTSA →

Note: NHTSA also opened 1 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

47 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

3

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2010 Chevrolet Tahoe reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →