Wrench.Pro

2010 Kia Forte Recalls, Issues & Maintenance

The 2010 Kia Forte carries 3 open NHTSA recalls — most recently covering air bag/restraint control module and switch. Owners report 6 recurring issue clusters, led by “TPMS valve stem cracking and rapid tire deflation.” Kia uses Hyundai Motor Group's powertrains, so service intervals mirror Hyundai's. Kia Promise covers the first 3 years / 36,000 miles of complimentary maintenance. Kia owners with the Theta II 2.0L/2.4L (Optima, Sorento, Sportage 2011-2019) should adhere strictly to oil intervals due to known oil-consumption issues in Kia TSBs.

3 Open Recalls

Source: NHTSA

AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE

Campaign #18V363000 · Jan 6, 2018

Issue: Kia Motors America (Kia) is recalling certain 2010-2013 Kia Forte, Forte Koup, 2011-2013 Kia Optima and 2011-2012 Kia Optima Hybrid and Sedona vehicles. In the event of a crash, the air bag control unit (ACU) may short circuit, preventing the frontal air bags and seat belt pretensioners from deploying.

Risk: If the frontal air bags and seat belt pretensioners are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.

Fix: Kia will notify owners. For model year 2011 Sedona vehicles, Kia will instruct dealers to verify the ACU part number and, if necessary, install an extension wire harness kit between the ACU Connector and the Vehicle Harness Connector. For all other affected vehicles, Kia will instruct dealers to install the extension wire harness kit. The recall began September 28, 2018. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC165.

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

Campaign #13V114000 · Jan 4, 2013

Issue: Kia Motors Corporation (Kia) is recalling certain model year 2007-2010 Rondo, model year 2007-2011 Sedona, Sorento and Sportage, model year 2010-2011 Soul, model year 2008-2011 Optima, model year 2010 Forte, model year 2007-2009 Amanti, and model year 2009 Borrego vehicles. Originally, in April 2013, Kia recalled 623,658 model year 2007-2010 Rondo and Sportage, model year 2007-2011 Sorento, model year 2007 Sedona, model year 2010-2011 Soul, and model year 2011 Optima vehicles. In September 2013, Kia informed the agency that it was adding an additional 356,719 vehicles to this campaign. The total number of vehicles being recalled is now 980,377. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake-transmission shift interlock feature preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.

Risk: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of PARK without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.

Fix: Kia will send an interim notification to owners in May 2013. When parts are available, owners will receive a second notification and dealers will replace the stop lamp switch, free of charge. Owners may contact Kia at 1-800-333-4542. Kia's recall campaign number is SC098.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Campaign #23V652000 · Sep 25, 2023

Issue: Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.

Risk: An engine compartment fire while parked or driving can increase the risk of injury.

Fix: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed November 14, 2023. Owner notification letters were mailed March 29, 2024 through June 18, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC284.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2010 Kia Forte.

1 active NHTSA investigation

Source: NHTSA

  • Hyundai and Kia ABS Module Fires

    Action #AQ23002 · opened Nov 17, 2023

    The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electron…

    View on NHTSA →

Reported to NHTSA

TPMS valve stem cracking and rapid tire deflation

TIRES, WHEELS

20 NHTSA complaints · 2013-06 → 2021-05

“THE TIRE DEFLATE RAPIDLY WHEN DRIVING AT 70MPH ON FREEWAY. WHEN IN THE TIRE SHOP TECHNICIAN REVELED THERE WAS NO PUNCTURE BUT THE STEM WAS MISSING. AFTER REMOVING THE TIRE THE STEM WAS FOUND INSIDE THE TIRE WITH VISIBLE CORROSION SIGNS. BY INSPECTING THE REST OF THE STEM, WAS”
— Owner report, NHTSA ODI #10521292
“ON JANUARY 19TH, 2014, WHILE THE CAR WAS BEING DRIVEN ON THE EXPRESSWAY, THE DRIVER'S SIDE REAR TIRE SUDDENLY WENT FLAT. UPON INSPECTION, THE HOLE WHERE THE VALVE STEM SHOULD RESIDE WAS EMPTY. THIS IS THE SECOND OCCURRENCE OF THIS TYPE. PREVIOUSLY, ON FEBRUARY 28TH, 2013, WHILE”
— Owner report, NHTSA ODI #10560692
“PULLING OUT DRIVE WAY GOING TO THE LEFT FELT LIKE PASSENGER WHEEL WAS LOCKING UP AND DOES IT QUITE A BIT. ALSO NTB IN CLEVELAND, TN SAID THERE WAS LOTS WRONG WITH UNDER NEATH , ALSO IT STILL FEELS LIKE IT'S RUNNING AFTER BEING CUT OFF. AND IT HAS A RIM THAT IS CRACKED AND WHEN I”
— Owner report, NHTSA ODI #11416288

Read all complaints on NHTSA →

Steering coupling clicking noise

STEERING

10 NHTSA complaints · 2013-05 → 2021-03

“WHILE DRIVING ANY SPEED STEERING WOULD MAKE A CLICKING NOISE AND GET STUCK FOR SEVERAL SECONDS WHEN TURNING THE WHEEL TO THE LEFT OR RIGHT.I FELT VERY UNSAFE ON THE INTERSTATE AS I WOULD JERK THE WHEEL TO GET THE WHEEL TO UNSTICK.I PUT MY HAND UNDER THE STEERING COLUMN AND GOT”
— Owner report, NHTSA ODI #11353077
“WHEN THE STEERING TURNS EVERY TIME, IT MAKES A CLICKING NOISE. AFTER THE CLICKING NOISE STARTED HAPPENING, I OFTEN HEAR METAL TO METAL CONTACT NOISE FROM THE STEERING WHEEL WHEN I DRIVE ON BUMPY ROADS. THE PROBLEM IS CAUSED BY THE FAULTY STEERING COUPLING INSIDE OF THE STEERING”
— Owner report, NHTSA ODI #11139092
“STEERING WHEEL MAKES A CLUNKING SOUND WHEN TURNING LEFT OR RIGHT. WAS TOLD IT COULD BE COUPLER OR BUSHING. KIA IS AWARE OF THE PROBLEM, BUT NO RECALL THAT I'M AWARE OF. BEING TOLD THE CAR IS NOT SAFE TO DRIVE $600-$1400 REPAIR ACCORDING TO FORUMS. IT DOES THIS DRIVING OR SITTING”
— Owner report, NHTSA ODI #10897325

Read all complaints on NHTSA →

Brake light and headlight bulb failure

EXTERIOR LIGHTING

15 NHTSA complaints · 2013-07 → 2025-08

“Brake lights are consistently blowing out especially the right brake light. I have replaced the bulb at least a dozen times in the past 2 years. Also the signal lights are going out as well. There is something faulty going on with the connection that I think needs to be”
— Owner report, NHTSA ODI #11586990
“Low beam headlights are so dim, driving at night is extremely dangerous. There is not enough illumination to detect more than 3 feet in front of the vehicle nor adequately see any potential hazards. After doing some research, it appears that this is a common problem that Kia is”
— Owner report, NHTSA ODI #11574368
“TL* THE CONTACT OWNS A 2010 KIA FORTE. THE CONTACT STATED THAT THE BACK UP AND BRAKE LIGHTS REMAINED ILLUMINATED AFTER THE VEHICLE WAS TURNED OFF. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED JENKINS KIA OF GAINESVILLE AT 855-764-9404 (LOCATED AT 3345 N MAIN”
— Owner report, NHTSA ODI #11121028

Read all complaints on NHTSA →

Service brake seizure and switch failure

SERVICE BRAKES

14 NHTSA complaints · 2013-12 → 2026-04

“I RECENTLY HAD BRAKE PROBLEMS ON MY 2010 KIA FORTE. IT WAS NOT DUE TO BRAKE WEAR OR ANY OF THE NORMAL BRAKE PROBLEMS. THE PROBLEM WAS ALL MY BRAKES SEIZED UP AND THE REAR ONES IN PARTICULAR HEATED UP TO THE POINT WHERE THEY WERE CLOSE TO FAILING. THE DEALER SAID IT MAY HAVE NOT”
— Owner report, NHTSA ODI #10641531
“TL* THE CONTACT OWNS A 2010 KIA FORTE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE REAR BRAKES SEIZED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE”
— Owner report, NHTSA ODI #10555413
“Brake light switch outage keeps happening”
— Owner report, NHTSA ODI #11634184

Read all complaints on NHTSA →

Engine rod-bearing knock and premature failure

ENGINE

77 NHTSA complaints · 2013-10 → 2026-06

“Known engine problem with bottom end knocking sounds. Potential risk of fire or wreck caused by engine failure. Engine condition is an ongoing issue. Dealerships and manufacture refuse to honor recall because last recall hasn't been addressed and the title is rebuilt”
— Owner report, NHTSA ODI #11648317
“179000 miles owner was driving and heard a knocking sound. He is an independent mechanic and put it in the shop to diagnose. While inspecting oil was within normal operating range and not yet due for an oil change. Low end rod knock. Changed oil to inspect for debris and found”
— Owner report, NHTSA ODI #11553838
“TL* THE CONTACT OWNS A 2010 KIA FORTE. THE CONTACT STATED THAT THERE WAS A LOAD KNOCKING IN THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE VEHICLE EXHIBITED A ROD KNOCK AND RECOMMENDED HAVING THE ENGINE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE”
— Owner report, NHTSA ODI #10574780

Read all complaints on NHTSA →

Air bag warning light and non-deployment in crashes

AIR BAGS

37 NHTSA complaints · 2013-06 → 2025-09

“On August 22nd 2025 my daughter was driving this vehicle and was in a car accident and her front air bags did not deploy. Her passenger side airbags deployed with no passenger but nothing in the front and it was a front collision. Upon receipt of the Paperwork from Copart we”
— Owner report, NHTSA ODI #11689708
“In June 2021 my air bag light came on. Called the dealership to have them check it out. Said they would get back with me to have it checked. 2-3 days later I was driving and hit a pothole air bags deployed while driving busted windshield driver and passenger side airbags”
— Owner report, NHTSA ODI #11440099
“TL* THE CONTACT OWNS A 2010 KIA FORTE. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CLOCKSPRING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TAKEN TO KIA STORE”
— Owner report, NHTSA ODI #11290829

Read all complaints on NHTSA →

Note: NHTSA also opened 2 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 3,750 mi

Severe service: every 3,750 miles. Normal: 7,500 miles. Theta II 2.0L/2.4L on Optima, Sorento, Sportage (2011-2019): full synthetic only, never extend.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Telluride and Sorento AWD owners benefit from rotation every 5,000 miles to prevent uneven wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads and rotors every 7,500 miles. Forte and Soul front pads typically last 40,000-55,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 24 months. Required for ABS and ESC pump longevity.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace engine air filter every 30,000 miles. Severe or dusty conditions: 15,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 30,000 mi

Severe service: every 30,000 miles. Normal: 60,000 miles. Use Kia SP-IV — same as Hyundai.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 105,000 mi

Iridium-tipped plugs rated 105,000 miles on most Kia engines. 1.6T (Forte GT, Soul Turbo): 60,000 miles. 3.5L Lambda II V6 (Telluride, Sorento): 105,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Long-Life Coolant

Every 30,000 mi

Kia Long-Life Coolant (pink, same as Hyundai): first change at 60,000 miles, then every 30,000. Do not mix with green or orange coolant.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Transfer Case / Rear Diff (AWD)

Every 60,000 mi

Sportage AWD, Sorento AWD, Telluride AWD: replace transfer case fluid and rear diff fluid every 60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 15,000 mi

Replace cabin air filter every 15,000 miles. Located behind the glove box on Optima, Forte, and Sportage; behind the dashboard panel on Telluride.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

111 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

21

complaints mentioning a crash

5

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2010 Kia Forte reflects Kia's published service intervals and the Service Reminder system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →