The 2011 Audi Q5 carries 5 open NHTSA recalls — most recently covering fuel pump and sun/moon roof assembly. Owners report 7 recurring issue clusters, led by “Timing chain tensioner failure.” Audi follows the VW Group Longlife service rhythm: oil and minor service every 10,000 miles or 12 months, whichever comes first, using oil that meets VW 502 00 / 504 00 (or 508 00 for newer 0W-20 engines) — generic synthetic does not qualify. S tronic dual-clutch gearboxes need fluid service every 40,000 miles despite 'lifetime fill' claims. Fully electric models (e-tron, e-tron GT) skip oil service entirely but keep brake-fluid, cabin-filter, and coolant-circuit intervals.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Campaign #18V818000 · Nov 19, 2018
Issue: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2007-2012 Audi Q7 and 2009-2012 Audi Q5 vehicles, previously repaired under NHTSA recall 16V-660. These vehicles were previously repaired with an interim repair of installing butyl tape to the fuel pump flange, until replacement remedy parts became available.
Risk: The butyl tape may not prevent fuel from leaking. A fuel leak in the presence of an ignition source can increase the risk of a fire.
Fix: Volkswagen will notify owners, and dealers will replace the fuel pump flange and install butyl tape, free of charge. The recall began December 28, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20BJ.
VISIBILITY:SUN/MOON ROOF ASSEMBLY
Campaign #17V001000 · Mar 1, 2017
Issue: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2011-2017 Audi Q5 vehicles. The sunroof drainage system may allow water to soak into the foam surrounding the side head air bag inflator canister resulting in the corrosion of the canister. If this happens, the corrosion can weaken the canister and the inflator could fracture without air bag deployment, propelling fragments into the passenger compartment, striking and causing serious injury to vehicle occupants.
Risk: An inflator rupture may result in metal fragments striking the driver or other occupants resulting in serious injury or death.
Fix: Audi will notify owners, and dealers will inspect the inflator and either coat it or replace it, as necessary, after removing the surrounding foam, free of charge. The recall is expected to began March 2017. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 69P1.
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Campaign #18V082000 · Jan 30, 2018
Issue: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2006-2013 Audi A3, 2007-2009 A4 Cabriolet and S4 Cabriolet, 2008 RS4 Cabriolet, 2009-2012 Q5, and 2010-2012 Audi A5 Cabriolet and S5 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Fix: Audi will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternative inflator, free of charge. The recall began February 23, 2018. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 69R6. Note: This recall partially supersedes recall 16V-078.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Campaign #16V660000 · Sep 13, 2016
Issue: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2012 Audi Q5, and 2007-2012 Audi Q7 vehicles equipped with gasoline engines. The fuel pump flange on the affected vehicles may crack, allowing fuel to leak.
Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.
Fix: Audi will notify owners, and dealers will inspect the flange, replacing any flanges that are cracked. If the flange is not cracked, dealers will clean the pump flange and install a butyl rubber band to protect the pump. These repairs will be made free of charge. The recall began November 9, 2016. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20W9.
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Campaign #16V078000 · Oct 2, 2016
Issue: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Golf, 2007-2010 Passat sedans and wagon, 2012-2014 Passat sedan and Eos, 2009-2014 CC, 2009-2012 Audi Q5, 2010-2012 S5 Cabriolet and 2010-2012 Audi A5 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Fix: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflators, free of charge. Volkswagen issued an interim notification to owners on April 12, 2016, and will send a second notification when parts are available. Volkswagen will notify owners again once parts are available. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298. Audi owners may contact Audi customer service at 1-800-253-2834.
What drivers and federal regulators have officially reported about the 2011 Audi Q5.
ENGINE
13 NHTSA complaints · 2016-09 → 2020-06
“ENGINE FAIL DUE TO THE TIMING CHAIN TENSIONER”
“TIMING CHAIN AND TENSIONER FAILED, CAR BECAME COMPLETELY INOPERABLE. STOPPED IN THE MIDDLE OF A MAJOR INTERSECTION IN RUSH HOUR”
“UPON ATTEMPTING TO START THE ENGINE, THE TIMING CHAIN SLIPPED CAUSING PISTONS TO HIT INTAKE VALVES, WRECKING ENGINE. ONLY 77,000 MILES ON VEHICLE”
FUEL/PROPULSION SYSTEM
14 NHTSA complaints · 2011-10 → 2022-11
“THE CAR SMELLS TO RAW GAS SITTING IN THE GARAGE. WHEN I GET IN IT THE ISIDE SMELLS TO RAW GAS ALSO. I AM NOT GETTING ANY WARNING SIGNS”
“My car smells like gas, I took it to the dealership ans they said my fuel pump flange is leaking gas”
“THE INDOOR ODOR OF THE CAR SMELLED STRONG OF GAS. THE AREA AROUND OR UNDER THE CAR WAS COMPLETELY DRY. THE SMELL WAS PREVALENT WHILE MOVING OR PARKED. THE GAS TANK WAS DRY AT THE NOZZLE”
SUSPENSION
3 NHTSA complaints · 2025-04 → 2026-08
“1) The rear structural subframe (crossmember) has completely rotted, perforated, and failed due to severe corrosion. The factory-installed plastic underbody rock shields trapped road salt and water, causing the frame to rust from the inside out. The corrosion has spread”
“During an inspection of my 2011 Audi Q5 at Audi Burlington, severe corrosion was discovered on the rear subframe, which supports rear suspension components”
“Rear subframe rust causing car to fail state inspection. This vehicle has been maintained well and always parked in garage. The rear subframe rusted most, then front subframe. This is a common compliant among Audi forum users”
AIR BAGS
52 NHTSA complaints · 2016-04 → 2019-06
“THIS AIRBAG RECALL WAS ISSUED A YEAR AGO AND NO REMEDY HAS BEEN MADE AVAILABLE WHILE MORE PEOPLE HAVE CONTINUED TO DIE. AN IMMEDIATE SOLUTION NEEDS TO BE MADE AVAILABLE FOR MYSELF AND OTHERS SO THAT NO MORE LIVES ARE SENSELESSLY LOST”
“TAKATA RECALL THEY HAVE NOT RELEASED A FIX TO MY DEALER FOR THIS PROBLEM AND NOW THEY ARE FILING CHAPTER 11. WHAT DO I NEED IN ORDER TO FIX THIS ISSUE?”
“TAKATA RECALL STILL NO SOLUTION. I CAN'T TRADE THIS VEHICLE IN AND I'M AFRAID TO DRIVE. AUDI DOESN'T KNOW WHEN THEIR WILL BE A SOLUTION”
“STILL DRIVING A CAR WITH A HAZARDOUS AIR BAG ISSUE. WHY HASN'T AUDI BEEN REQUIRED TO PROVIDE A RENTAL UNTIL A FIX IS AVAILABLE? THIS SHOULD HAVE BEEN RESOLVED MONTHS AGO”
AIR BAGS
3 NHTSA complaints · 2017-07 → 2023-01
“Accident head on collision with wall airbags didn't deploy”
“TOOK SUV IN FOR RECALL X3 (2) SEPARATE DEALERS, WAS TOLD THEY DO NOT HAVE THE PART IN YET TO REPLACE IT. I WAS IN A HEAD ON COLLISION THIS PAST JANUARY 2017 THE AIR BAG DIDNT DEPLOIT”
“ITS BEEN OVER A YEAR I AM AWARE OF THE RECALL, I HAVE BEEN SERVICED SEVERAL TIMES AT 2 DIFFERENT DEALERS BOTH STATE THAT THEY DO NOT HAVE PARTS TO COMPLETE THIS RECALL. IN JANUARY 2017 I WAS IN A HEAD ON COLLISION AND THE AIR BAG DID NOT DEPLOY!”
ENGINE
6 NHTSA complaints · 2014-03 → 2020-02
“THE AUDI 2.0T ENGINE IS KNOWN TO HAVE ISSUES WITH SIGNIFICANT OIL CONSUMPTION. THE CAR HAS BEEN AT AUDI WITH THIS ISSUE SEVERAL TIMES”
“OIL CONSUMPTION ISSUE WHILE DRIVING DOWN THE ROAD. UNDER ANY ACCELERATION, SMOKE COMES OUT THE EXHAUST. USES ABOUT 1 QUART OF OIL PER 300 MILES. LEAK DOWN TEST WAS DONE, SHOWING LEAKAGE PAST PISTON RINGS. RESULTING IN A COMPLETE REBUILD OF ENGINE COSTING ME $5,000 PLUS”
POWER TRAIN
5 NHTSA complaints · 2010-11 → 2019-08
“TRANSMISSION SHIFT GEARS VERY BAD, WHILE BREAKING, FROM 2 GEAR TO 1ST GEAR CAR "JUMPS" FORWARD, I SEEN A LOT OF PEOPLE COMPLAINING ABOUT IT. SOMETHIMES WHEN I PUT IN TO REVERSE, IT TAKES A MINUTE UNTIL IT START DRIVING”
“TRANSMISSION OFTEN JERKS WHEN SLOWING DOWN BELOW 10 MPH, CAR JERKS FORWARD”
“WHILE TAKING A LEFT TURN ACROSS TRAFFIC, THE AUDI Q5 3.2 TRANSMISSION FAILED WHILE SHIFTING FROM 1ST TO 2ND GEAR. THE AUDI Q5 STALLED AND STOPPED AND WOULD NOT CONTINUE TO DRIVE. THE ENGINE SEEMED TO BE WORKING PROPERLY; HOWEVER, THE GEARS WOULD NOT”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Replace oil and filter every 10,000 miles or 12 months with VW 502 00 / 504 00 / 508 00 spec oil. S and RS models driven hard: many owners shorten to 5,000-7,500 miles. Wrong-spec oil is the leading cause of TFSI timing-chain tensioner and PCV problems.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate every 10,000 miles with the oil service. quattro models: keep all four tires within 4/32" of each other — mismatched wear stresses the center differential.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect pads, rotors, and wear sensors every 10,000 miles. Audi uses electronic pad-wear sensors on most models — replace the sensor with the pads.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Replace DOT 4 brake fluid every 2 years regardless of mileage — Audi's published schedule is time-based because the fluid absorbs moisture.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
S tronic (DSG) gearboxes on A3/S3/RS 3, Q3, TT, and many A5/Q5 models: replace fluid and filter every 40,000 miles with the VW Group-spec fluid for your gearbox code. Skipping this service is the most common cause of mechatronic failure.
Estimated cost — typical U.S. ranges
Dealer
~$470–$640
Shop
~$330–$450
DIY
Pro only
VW/Audi DSG service needs a fluid-fill procedure at a specific temperature — shop equipment territory.
Keeps your vehicle running smoothly and efficiently
A3/S3/RS 3, Q3, and TT use a Haldex-style rear coupling: replace its fluid roughly every 40,000 miles (some model years specify sooner — check your manual). Longitudinal quattro (A5-A8, Q5, Q8) has no coupling service; see differential fluid instead.
Estimated cost — typical U.S. ranges
Dealer
~$220–$290
Shop
~$155–$205
DIY
~$40–$90
VW/Audi/Volvo AWD coupling — specific fluid required. Filter usually swapped at the same time.
TFSI turbo engines: new plugs every 40,000 miles. RS models with the 2.5 TFSI five-cylinder: consider 30,000 miles under track or hard street use.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Replace every 40,000 miles; inspect at 20,000 on turbocharged engines — a clogged filter shows up as sluggish boost response first.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
2.0 TFSI (EA888) engines before roughly 2013 had timing-chain tensioner failures — have the tensioner revision checked by 80,000 miles on earlier cars. Later engines carry the updated design with no scheduled service.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Pro only
Timing chains are normally lifetime. Listen for rattle on cold start — that's the actionable signal. Replacement is major work, quote separately.
Extends the life of your vehicle and improves comfort
Q5, Q8, and A5-A8 quattro: independent Audi specialists recommend front/rear differential fluid service around 60,000 miles even where Audi lists it as lifetime fill.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Replace the cabin air filter every 20,000 miles or 2 years. Audi specifies an activated-carbon filter on most models.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Audi coolant is labeled lifetime fill. Independent VW/Audi specialists recommend a refresh around 5 years or 100,000 miles to protect the water pump and thermostat housing — and only with the correct pink/lilac VW Group coolant.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Occupant deaths in fatal crashes (FARS)
10 crashes 2010–2024
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
4
complaints mentioning a crash
2
complaints mentioning a fire
Reviewed known issues for this vehicle·Open recalls for this vehicle
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2011 Audi Q5 reflects Audi's published service intervals and the Audi Service Interval Display system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.