The 2011 Mazda Mazda6 carries 6 open NHTSA recalls — most recently covering inflator module. Owners report 5 recurring issue clusters, led by “Overhead sunglass holder detachment.” Mazda's Skyactiv engines use unusually high compression ratios (13:1 to 16:1) and require strict adherence to oil intervals — extending oil life on a Skyactiv engine accelerates carbon buildup on intake valves. Mazda's published Schedule 1 (severe) covers most US driving conditions.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Campaign #18V717000 · Dec 10, 2018
Issue: Mazda North American Operations (Mazda) is recalling certain 2014-2015 Mazda CX-9 vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, unless covered in "Zone A," Mazda is recalling certain 2011-2013 Mazda6, 2011-2012 CX-7, and 2011-2015 CX-9 sold, or ever registered in the states of Arizona, Arkansas, Delaware, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, West Virginia and the District of Columbia, or "Zone B." Additionally, unless covered in Zone A or Zone B, Mazda is recalling certain 2010-2013 Mazda6, 2010-2012 CX-7, and 2010-2015 CX-9 vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Fix: Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began November 9, 2018. Owners may contact Mazda customer service at 1-800-222-5500, Option 4. Mazda's number for this recall is 1317F.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Campaign #19V782000 · Oct 31, 2019
Issue: Mazda North American Operations (Mazda) is recalling certain 2007-2012 CX-7, CX-9, and 2009-2012 Maza6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Fix: Owners are advised not to drive their vehicles until the repair has been performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. The recall began December 3, 2019. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 1317F. Note: This recall supersedes recalls 16V356 and 17V012.
STRUCTURE
Campaign #19V323000 · Apr 25, 2019
Issue: Mazda North American Operations (Mazda) is recalling certain 2011-2013 Mazda6 vehicles sold, or ever registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland,Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. The front cross member may corrode after exposure to road salt.
Risk: Corrosion may weaken the mounting point for the passenger side lower control arm, unexpectedly changing the steering alignment and increasing the risk of a crash.
Fix: Mazda will notify owners, and dealers will inspect the cross member and either install a side member and drain hose and apply wax to protect from rust, or install a drain hose and an improved front cross member, free of charge. The recall began June 13, 2019. Owners may contact Mazda customer service at 1-800-222-5500 Option 4. Mazda's number for this recall is 2818I. Note: This recall is an expansion of Recall 18V-631.
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Campaign #17V429000 · Jun 29, 2017
Issue: Mazda North America Operations (Mazda) is recalling certain 2009-2011 Mazda6, and 2007-2011 CX-7 and CX-9 vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Fix: Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the passenger frontal air bag inflator with an alternate inflator, free of charge. The recall began on August 30, 2017. Owners may contact Mazda customer service at 1-800-222-5500. Mazda's number for this recall is 1317F. Note: This recall supersedes recall 16V356 and all vehicles that were not remedied under that campaign are now covered by this one.
FUEL SYSTEM, GASOLINE
Campaign #14V114000 · Nov 3, 2014
Issue: Mazda North America Operations (Mazda) is recalling certain model year 2010-2012 Mazda6 vehicles manufactured September 14, 2009, through May 2, 2011, and equipped with 2.5L engine. In the affected vehicles, spiders may weave a web in the evaporative canister vent hose, blocking it and causing the fuel tank to have an excessive amount of negative pressure.
Risk: Negative pressure could cause the fuel tank to crack resulting in a fuel leak, increasing the risk of a fire.
Fix: Mazda will notify owners, and dealers will reprogram the powertrain control module and inspect and clean the canister vent line. If a web was found in the line, the fuel tank and check valve on canister vent line will be replaced. These repairs will be done free of charge. The recall began on April 30, 2014. Owners may contact Mazda at 1-800-222-5500. Mazda's recall number associated with this campaign is 7214C.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Campaign #13V425000 · Sep 24, 2013
Issue: Mazda is recalling certain model year 2009-2013 Mazda6 vehicles manufactured February 4, 2008, through August 24, 2012. The door latch mounting screws may become loose.
Risk: If all three door latch mounting screws become excessively loose the door latch mechanism would not engage and the door might open while the vehicle is in motion increasing the risk of accident or injury.
Fix: Mazda will notify owners, and dealers will apply a thread locking adhesive to the door screws and retorque them, free of charge. The recall began on October 29, 2013. Owners may contact Mazda at 1-800-222-5500. Mazda's recall number is 7013I.
What drivers and federal regulators have officially reported about the 2011 Mazda Mazda6.
VISIBILITY/WIPER
3 NHTSA complaints · 2014-01 → 2015-09
“SUNGLASS HOLDER KEEPS POPPING OUT BLOCKING THE REARVIEW”
“SUNGLASS HOLDER ABOVE REAR VIEW MIRROR POPS OUT WHILE DRIVING OBSTRUCTING THE DRIVERS USE OF REAR VIEW MIRROR”
SUSPENSION, STRUCTURE
62 NHTSA complaints · 2017-12 → 2026-06
“Front Subframe has corroded and broke. There is a recall on the subframe that was repaired by dealership in 2019, but this repair did not fix the issue since it has now rusted through and broke. The repair was faulty”
“FRONT SUSPENSION SUBFRAME IS COMPLETELY RUSTED DISABLING THE VEHICLE AND MAKING IT UNSAFE FOR OPERATION. COMPLETE SUBFRAME WILL NEED TO BE REPLACED DUE TO THE SEVERITY OF RUST AND CORROSION BEFORE VEHICLE CAN BE OPERATIONAL AGAIN”
“The contact owns a 2011 Mazda MZ6. The contact stated that while her son was driving at approximately 60-65 MPH, the rear subframe had detached, causing the vehicle to spin across four lanes of traffic and then crash into the median wall”
AIR BAGS
26 NHTSA complaints · 2015-09 → 2020-10
“TAKATA RECALL. THE CONTACT OWNS A 2011 MAZDA 6. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V356000 (AIR BAGS). THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR”
“TAKATA RECALL MY SON'S 2011 VEHICLE HAS A TAKATA AIRBAG IN THE PASSENGER SIDE. ACCORDING TO THE DEALERSHIP THEY CAN NOT REPLACE IT AT THIS TIME AS THERE IS NOT A FORMAL RECALL”
“TWO CAR COLLISION AT AN INTERSECTION .CITY STREETS. BOTH CARS IN MOTION. AIR BAG DEPLOYED BUT DIDN'T INFLATE. SMOKE FILLED INTERIOR. ATTENDING FIREMAN AT FIRST THOUGHT THE CAR WAS ON FIRE”
EXTERIOR LIGHTING
12 NHTSA complaints · 2013-03 → 2022-09
“The headlights are increasingly failing. They are so dim that i can not safely drive at night. They burn out easily. I have to replace them about 4 times a year now”
“THE CONTACT OWNS A 2011 MAZDA 6. WHILE DRIVING APPROXIMATELY 55 MPH, THE HEADLIGHTS BECAME INOPERABLE. THE FAILURE RECURRED ON SEVERAL OCCASIONS”
“I WAS PULLED OVER MY LOCAL POLICE FOR NO HEAD LAMP. THEY LET ME OFF WITH A WARNING. I SEARCHED THE INTERNET THE NEXT DAY AND FOUND THAT THIS PROBLEM IS A KNOWN DEFECT BY MAZDA AND THEY ARE DOING NOTHING ABOUT IT”
UNKNOWN OR OTHER
14 NHTSA complaints · 2015-08 → 2021-08
“DASHBOARD BECAME STICKY AS IF MELTING”
“MY MAZDA 6 INTERIOR DASH IS MELTING IN 74 DEGREE WEATHER IN VA. THE DASH IS MELTING AND MAKING A STICKY MESS THAT MAY CAUSE A GLARE ON WINDSHIELD WHILE DRIVING. CAR IS STATIONARY”
“MELTED DASHBOARD. I'VE SEEN ON NEWS ABOUT COMPANY HAVING THEM REPLACED”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Replace 0W-20 full-synthetic oil every 5,000 miles under Schedule 1. Schedule 2 (highway-only): 7,500 miles. Turbo engines: 5,000 miles regardless of schedule.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 7,500 miles; every 5,000 on AWD models, where the front-biased coupling wears tires unevenly.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect brake pads, rotors, and parking brake at every oil change. Front pads typically last 35,000-50,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Replace DOT 3 brake fluid every 30,000 miles or 36 months.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Replace engine air filter every 30,000 miles. Skyactiv-G direct injection is sensitive to airflow restriction — inspect at every oil change.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Replace ATF every 60,000 miles severe / 100,000 normal. Use Mazda FZ ATF — substitutes cause harsh 1-2 shifts and torque converter shudder.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Iridium spark plugs every 60,000 miles on Skyactiv-G 2.0L and 2.5L; 45,000 miles on the 2.5L Turbo.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Mazda FL-22 (yellow): first change at 120,000 miles or 10 years, then every 60,000. Do not substitute — silicate-free formula prevents water pump damage on Skyactiv engines.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
On AWD models, replace transfer case fluid and rear differential fluid every 60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
Extends the life of your vehicle and improves comfort
Replace cabin air filter every 15,000 miles. On most models it sits behind the glove box.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Occupant deaths in fatal crashes (FARS)
32 crashes 1990–2024
How the 32 occupant deaths break down
25
driver deaths
7
passenger deaths
32
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 2011 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
8
complaints mentioning a crash
1
complaints mentioning a fire
Reviewed known issues for this vehicle·Open recalls for this vehicle
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2011 Mazda Mazda6 reflects Mazda's published service intervals. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.