Wrench.Pro

2011 Subaru Outback Recalls, Issues & Maintenance

The 2011 Subaru Outback carries 16 open NHTSA recalls — most recently covering inflator module and parking brake. Owners report 6 recurring issue clusters, led by “Rear brake line corrosion and brake loss.” Subaru's symmetrical AWD system places unusually high demands on differential fluid and transfer case service — skipping these is the most common cause of premature drivetrain wear. Older Subarus with the EJ25 engine (pre-2011) require timing belt replacement; FB and FA engines (2011+) use a maintenance-free chain. Subaru's published intervals below align with the owner's manual Schedule II (severe) which most US drivers qualify for.

16 Open Recalls

Source: NHTSA

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Campaign #19V008000 · Sep 1, 2019

Issue: Subaru of America, Inc. (Subaru) is recalling certain 2010-2014 Tribeca, WRX, Outback, and Legacy vehicles, 2010-2011 Impreza vehicles and 2010-2013 Forester vehicles sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Risk: An explosion of an inflator within the passenger frontal air bag module may result in sharp metal fragments striking the front seat passenger, driver or other occupants resulting in serious injury or death.

Fix: Subaru is notifying owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began January 25, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is TKB-19.

PARKING BRAKE

Campaign #18V626000 · Sep 13, 2018

Issue: Subaru of America, Inc. (Subaru) is recalling certain 2010-2014 Subaru Legacy and Outback vehicles equipped with a manual transmission. The electronic parking brake (EPB) may not engage as intended, allowing the vehicle to rollaway if the transmission is not in the proper gear when parked.

Risk: A vehicle rollaway can increase the risk of a crash.

Fix: Subaru will notify owners, and dealers will replace the EPB actuator assembly, free of charge. The recall began July 19, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTV-81.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Campaign #19V007000 · Sep 1, 2019

Issue: Subaru of America, Inc. (Subaru) is recalling certain 2010-2013 Forester, 2010-2014 Tribeca, WRX, Outback, Legacy, and 2010-2011 Impreza vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Risk: An explosion of an inflator within the passenger frontal air bag module may result in sharp metal fragments striking the front seat passenger, driver or other occupants resulting in serious injury or death.

Fix: Subaru has notified owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began January 25, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is TKA-19.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Campaign #19V009000 · Sep 1, 2019

Issue: Subaru of America, Inc. (Subaru) is recalling certain 2010-2014 Tribeca, WRX, Legacy and Outback vehicles, 2010-2011 Impreza vehicles and 2010-2013 Forester vehicles sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Risk: An explosion of an inflator within the passenger frontal air bag module may result in sharp metal fragments striking the front seat passenger, driver or other occupants resulting in serious injury or death.

Fix: Subaru is notifying owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on January 25, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is TKC-19.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Campaign #20V002000 · Feb 1, 2020

Issue: Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Fix: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began January 7, 2020. Subaru owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKB-20.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Campaign #20V003000 · Feb 1, 2020

Issue: Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (including STI), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Fix: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began January 7, 2020. Subaru owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKC-20.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Campaign #20V001000 · Feb 1, 2020

Issue: Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester, 2003-2006 Baja, 2004-2011 Impreza, 2004-2014 WRX (STI included), 2003-2014 Legacy and Outback, and 2005-2006 Saab 9-2X vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Fix: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger air bag inflators with alternate inflators, free of charge. The recall began January 7, 2020. Subaru Owners may contact Subaru customer service at 1-844-373-6614. Saab owners may contact the Saab Customer Assistance Center at 1-800-955-9007. Subaru's number for this recall is TKA-20.

ELECTRICAL SYSTEM:IGNITION:SWITCH

Campaign #19V297000 · Nov 4, 2019

Issue: Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Forester vehicles, 2008-2011 Impreza vehicles, 2008-2014 WRX vehicles, 2005-2014 Legacy vehicles, 2005-2014 Outback vehicles and 2006-2008 Tribeca vehicles equipped with a mechanical key ignition switch installed as a replacement part. The ball spring inside the switch may break, reducing the strength of the ignition switch. If this occurs, the weight on the key ring and certain road conditions could cause the ignition switch to move out of the run position to the accessory position, turning off the engine.

Risk: The engine turning off unexpectedly can increase the risk of a crash. If a crash occurs under this condition, the air bag may not deploy, increasing the risk of injury.

Fix: Subaru will notify owners, and dealers will inspect the ignition switch, replacing the ignition switch, if necessary, free of charge. The recall began May 10, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUF-91.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Campaign #18V012000 · Sep 1, 2018

Issue: Subaru of America, Inc. (Subaru) is recalling certain 2009-2013 Legacy, Forester, Tribeca, WRX and Outback vehicles, and 2009-2011 Impreza vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Risk: An explosion of an inflator within the passenger frontal air bag module may result in sharp metal fragments striking the front seat passenger, driver or other occupants resulting in serious injury or death.

Fix: Subaru will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on February 9, 2018. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is TKA-18.

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

Campaign #16V694000 · Sep 27, 2016

Issue: Subaru of America, Inc. (Subaru) is recalling certain model year 2010-2014 Legacy vehicles manufactured November 26, 2008, to June 7, 2013, and 2010-2014 Outback vehicles manufactured January 9, 2009 to June 7, 2013. Due to contamination, components within the windshield wiper motor bottom cover may interfere with each other. If an obstruction, such as a buildup of snow or ice prevents the wiper arms from being able to stop in the parked position, the wiper motor may overheat and the bottom cover may melt.

Risk: If the windshield wiper motor overheats, the wipers may fail, reducing driver visibility and increasing the risk of a crash. Additionally, the wiper motor cover may melt, increasing the risk of a fire.

Fix: Subaru will notify owners, and dealers will replace the windshield wiper motor bottom cover assembly, free of charge. The recall began October 2016. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is WTK-71. Note: This recall supersedes recall 11V-469. All vehicles that were remedied under that campaign are affected by this campaign, and need to have their wiper motor bottom cover replaced again.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Campaign #17V014000 · Oct 1, 2017

Issue: Subaru of America, Inc. (Subaru) is recalling certain 2005-2006 Subaru Baja, 2006-2011 Impreza (including WRX and STI models), 2006-2012 Tribeca, 2009-2012 Forester, Legacy, Outback, and 2012 WRX vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Fix: Subaru will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began March 6, 2017. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is TKA-17.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Campaign #16V358000 · May 25, 2016

Issue: Subaru of America, Inc. (Subaru) is recalling certain model year 2003-2004 Legacy, Outback, 2009-2011 Legacy, Outback, Forester, 2006-2011 Impreza, Tribeca, 2003-2006 Baja, and 2006 Saab 9-2x vehicles originally sold or that have ever been registered in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." These vehicles may be equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Fix: Subaru will notify their owners. General Motors will notify Saab owners. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began August 26, 2016. Owners may contact Subaru customer service at 1-856-488-8500. Saab owners may contact GM at 1-800-955-9007. Subaru's number for this recall is TKA-16.

VISIBILITY:SUN/MOON ROOF ASSEMBLY

Campaign #11V467000 · Jul 9, 2011

Issue: SUBARU IS RECALLING CERTAIN MODEL YEAR 2011 OUTBACK AND LEGACY VEHICLES MANUFACTURED FROM AUGUST 3, 2010, THROUGH JULY 1, 2011. THE MOONROOF GLASS MAY COME LOOSE OR DETACH. THE AMOUNT AND POSITION OF THE ADHESIVE BETWEEN THE GLASS AND RETAINER WAS INADEQUATELY APPLIED.

Risk: THE MOONROOF GLASS CAN LOOSEN AND DETACH FROM THE VEHICLE DURING DRIVING, RESULTING IN A POTENTIAL ROAD HAZARD FOR OTHER VEHICLES, INCREASING THE RISK OF A CRASH.

Fix: SUBARU WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE GLASS ADHESION CONDITION AND EITHER APPLY ADDITIONAL ADHESIVE OR REPLACE THE MOONROOF GLASS, FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING OCTOBER 2011. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783.

ELECTRICAL SYSTEM

Campaign #13V061000 · Feb 25, 2013

Issue: Subaru is recalling certain model year 2010-2012 Legacy and Outback vehicles equipped with an automatic or CVT transmission and an Audiovox remote engine starter (RES) accessory, certain model year 2012-2013 Impreza vehicles equipped with a CVT transmission and an Audiovox remote engine starter (RES) accessory, and certain model year 2013 XV Crosstrek vehicles equipped with a CVT transmission and an Audiovox remote engine starter (RES) accessory. Additionally included are certain model year 2013 Legacy and Outback vehicles that may have received replacement RES fobs. If the RES fob is dropped, the fob may malfunction and randomly transmit an engine start request without pressing the button.

Risk: The engine may inadvertently start and run for up to fifteen minutes. The engine may continue to start and stop until the fob battery is depleted, or until the vehicle runs out of fuel. If the vehicle is parked in an enclosed area, there is a risk of carbon monoxide build-up which may cause headaches, dizziness or, in extreme cases, unconsciousness and/or asphyxiation.

Fix: Subaru will notify owners, and dealers will replace the RES key fobs, free of charge. The recall began on April 22, 2013. Owners may contact Subaru at 1-800-782-2783 for more information.

EXTERIOR LIGHTING

Campaign #12V602000 · Dec 26, 2012

Issue: Subaru is recalling certain model year 2010 and 2011 Legacy and Outback vehicles, certain model year 2006 through 2012 Tribeca vehicles sold before January 2012, and certain model year 2009 through 2012 Forester vehicles sold before January 2012. Up to 78,650 of these vehicles may have been equipped with accessory puddle lights that, when illuminated, brighten the area under the doors of the vehicle. A short circuit can develop when either the puddle light or connector are exposed to an electrolytic moisture source (such as road spray that has road salt in it) and it penetrates the circuit board of the puddle light or the pins of the puddle light connector(s).

Risk: Over time, migration of the moisture into the circuit board and/or into the connector cavity, may result in a short circuit of the puddle light system. This may generate heat which may melt the plastic resulting in smoke or fire.

Fix: Subaru will notify owners, and dealers will install an additional fused-harness, free of charge. The recall began February 19, 2013. Owners may contact Subaru at 1-800-782-2783 for more information.

POWER TRAIN:MANUAL TRANSMISSION

Campaign #10V326000 · Jul 20, 2010

Issue: SUBARU IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 OUTBACK AND LEGACY PASSENGER VEHICLES MANUFACTURED FROM APRIL 28 THROUGH JUNE 23, 2010. DUE TO A PROGRAMMING ERROR, A LUBRICATION HOLE WITHIN THE 6-SPEED MANUAL TRANSMISSION WAS OMITTED.

Risk: IF THE TRANSMISSION GEARS ARE NOT PROPERLY LUBRICATED, A GROANING SOUND MAY BEGIN TO DEVELOP ALERTING THE DRIVER OF A PROBLEM. IF THE SOUND IS IGNORED AND NO ACTION IS TAKEN, THE GEARS WILL EVENTUALLY BREAK AND THIS CONDITION WILL LEAD TO VEHICLE POWER LOSS, POSSIBLY RESULTING IN A CRASH.

Fix: SUBARU WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES BY DRILLING AN OIL LUBRICATION HOLE AND, IF NECESSARY, REPLACE THE INTERNAL PARTS WITH NEW ONES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 28, 2010. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2011 Subaru Outback.

Reported to NHTSA

Rear brake line corrosion and brake loss

SERVICE BRAKES

26 NHTSA complaints · 2019-10 → 2025-08

“Just lost brakes. Was parked at an atm. In park, foot on brake as i was shifting into drive, brake pedal goes to floor and brake fluid leaks out... I see there was a recall for brake lines in Michigan. I've owned this car since 2020. All Brake pads are new as of 4/2025. This”
— Owner report, NHTSA ODI #11678072
“Going down the road and my breaks went to the floor, further inspection the back passenger 4 way block blew apart due to rust I looked online and there is so many of these cars the same year that this is happening to, would love to have this year and model included in the recall”
— Owner report, NHTSA ODI #11635185
“I WAS DRIVING THIS VEHILCE WHILE COMING TO A STOP THE BRAKE PEDAL WENT TO THE FLOOR AND THE VEHICLE WOULDNT STOP COMPLETLY, I HAD TO SHIFT THE TRANSMISSION INTO PARK,, PERHAPS CAUSING DAMAGE TO MY TRANSMISSION, UPON INVESTIGATION I FOUND THE REAR BRAKE LINE FAILURED DUE TO RUST”
— Owner report, NHTSA ODI #11363876

Read all complaints on NHTSA →

Front subframe corrosion and fracture

SUSPENSION, STRUCTURE

10 NHTSA complaints · 2022-07 → 2025-01

“My front subframe broke. I was driving the car and was exiting the highway. I heard a snap n then had no control. Had my mechanic look at car and said frame snapped and control arm broke. The week before i had my car alignment and new tires put on. Nothing was noticed then”
— Owner report, NHTSA ODI #11533456
“Failure of front subframe while driving. Vehicle is unable to be driven. Vehicle pulled severely to drivers side while driving. Subframe had severe deterioration by rust . Vehicle is at Annen Brake Fond du Lac, Wi and available for inspection. Replacement part is unavailable and”
— Owner report, NHTSA ODI #11525925
“The contact owns a 2011 Subaru Outback. The contact stated there was a clunking sound coming from the front suspension location and the vehicle started feeling unstable while driving approximately 30 MPH. The steering wheel began to sway towards the left causing the contact to”
— Owner report, NHTSA ODI #11544449

Read all complaints on NHTSA →

Head gasket failure and coolant/oil leaks

ENGINE

16 NHTSA complaints · 2019-10 → 2026-05

“Purchased my 2011 Subaru Outback 3.6R Limited from the dealership, new. Since 2013, the Subaru dealer has discovered multiple oil leaks, replaced the head gaskets 3 times, thermostat 4 times, the alternator 3 times, timing belt 4 times, radiator 3 times, starter once, and my”
— Owner report, NHTSA ODI #11737640
“in 2023 my car started overheating. took it in and it was the headgasket. even with the age of my car, it only had just over 105,000 miles on it. looking at other subarus for sale out of curiosity, I saw that quite a lot had their engines replaced. even newer than mine. i do see”
— Owner report, NHTSA ODI #11563896
“My 2011 Outback had a head gasket failure at 98,000 miles. The car overheated which forced me to pull over in heavy traffic. There was no prior warning or symptoms until the engine temperature warning light appeared. The car was repaired by the dealership at a hefty price. They”
— Owner report, NHTSA ODI #11429558

Read all complaints on NHTSA →

Torque converter/CVT stall or shudder when stopping

POWER TRAIN

56 NHTSA complaints · 2019-07 → 2025-10

“Torque converter issue that causes stalling similar to a manual transmission vehicle. The issue should have been a full recall but instead was only a "bulletin." For my own safety, I am stuck paying several thousand dollars for an issue the manufacturer is aware of but refused”
— Owner report, NHTSA ODI #11640426
“Seems like a transmission problem on my Subaru Outback. While braking to a stop the car shudders and then the engine stalls creating a hazardous situation. I'm forced to put the car in park and restart the engine. This sounds like a common issue with the tourque converter on”
— Owner report, NHTSA ODI #11578081
“THE CAR STALLS WHEN COMING TO A FAST STOP AND SOMETIMES SHUDDERS LIKE IT IS GOING TO STALL WHEN SLOWING DOWN. THIS WAS HORRIBLE ON THE FREEWAY DURING TRAFFIC AS I HAD TO RESTART MY CAR NUMEROUS TIME. GOT CLOSE TO GETTING REAR ENDED A FEW TIMES. I TOOK MY CAR TO SUBARU AND IT IS”
— Owner report, NHTSA ODI #11244071

Read all complaints on NHTSA →

Low-beam headlight bulb burnout

EXTERIOR LIGHTING

6 NHTSA complaints · 2019-10 → 2021-01

“HEADLIGHTS BURN OUT REPEATEDLY, WITHOUT WARNING OR INCIDENT, SOMETIMES BOTH WITHIN A WEEK. CAR IS DRIVEN LESS THAN 10K MILES PER YEAR, YET ONE OR BOTH HEADLIGHTS HAVE HAD TO BE REPLACED ANNUALLY ON AVERAGE. BULBS ARE VERY DIFFICULT FOR CONSUMER TO REPLACE AND MUST BE DONE BY”
— Owner report, NHTSA ODI #11297469
“LOW BEAM HEAD LIGHT BURNS OUT WHILE DRIVING ON THE THE INTERSTATE HIGHWAY. REPLACING THE BULB IS NOT THAT EASY. THIS IS WELL KNOWN PROBLEM AND SUBARU HAS BEEN AWARE OF THE PROBLEM FOR LAST EIGHT PLUS YEARS. INSTEAD OF REPLACING THE DEFECTIVE LIGHTING SYSTEM SUBARU HAS EXTENDED”
— Owner report, NHTSA ODI #11298624
“LOW HEADLAMP BULB HOUSING MELTED SO BAD IT MUST BE REPLACED AT ESTIMATED DEALER COST OF $650. THERE IS AN EXTENDED WARRANTEE FOR REPLACING THE BULBS THAT HAVE BEEN BURNING OUT EVERY 6-9 MONTHS. I BELIEVE THEY HAVE BEEN BURNING UP DUE TO A MANUFACTURING DEFECT IN THE HOUSING THAT”
— Owner report, NHTSA ODI #11386791

Read all complaints on NHTSA →

Takata air bag recall service issues

AIR BAGS

4 NHTSA complaints · 2019-11 → 2024-12

“MY 2011 SUBARU OUTBACK IS PART OF THE AIRBAG RECALL. I HAVE PHONED SUBARU 6 TIMES AND THEY REFUSE TO FIX MY AIRBAGS. THE REASON IS THAT I LIVE ON A SMALL ISLAND IN HAWAII THAT DOES NOT HAVE A DEALERSHIP OR EVEN A CAR REPAIR SHOP. THE VEHICLE MUST BE SHIPPED TO OAHU TO BE FIXED”
— Owner report, NHTSA ODI #11387561
“I TOOK MY VEHICLE TO THE SUBARU IN MISSOULA, MT IN OCTOBER OF 2019 TO FIX THE TAKATA AIR BAG RECALL. IN JULY OF 2019 I RECEIVED A RECALL FOR THE EXACT SAME PROBLEM. I CALLED THE NUMBER ON THE RECALL NOTICE 855-371-5406. I WAS INFORMED THAT SUBARU HAD PUT IN THE SAME NON-WORKING,”
— Owner report, NHTSA ODI #11350902
“I ACCEPTED A RECALL TO REPLACE THE PASSENGER AIR BAG BY THE DEALER EVENSTON SUBARU, 3340 OAKTON STR, SKOKIE, ILL, 60076; AFTER THIS RECALL REPLACEMENT WAS PERFORMED, MY CAR HAD PROBLEMS LIKE THE PASSENGER WINDOW DID NOT OPPERATE FROM THE COMMEND BUTTON OF THE SAME DOOR AND THE”
— Owner report, NHTSA ODI #11282284

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 6,000 mi

Replace 0W-20 full-synthetic oil and filter every 6,000 miles. WRX/STI 2.0L/2.5L turbo: 3,750 miles. Non-turbo FB engines: 6,000 miles severe / 10,000 normal.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Critical on Subaru AWD — uneven tread depth across all 4 tires (>2/32") forces the center differential to bind, damaging the AWD coupling.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, calipers, and parking brake every 7,500 miles. Outback and Forester pads commonly last 35,000-50,000 miles depending on terrain.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Front Differential / Manual Transmission Fluid

Every 30,000 mi

Replace front differential and manual transmission fluid every 30,000 miles. CVT models use proprietary Subaru CVT fluid — a separate item.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Rear Differential Fluid

Every 30,000 mi

Replace rear differential fluid every 30,000 miles. Use Subaru 75W-90 GL-5 — substitutes can cause whining noises within months.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

CVT Fluid (Lineartronic)

Every 30,000 mi

Subaru CVT models (Outback, Legacy, Forester, Crosstrek, Impreza, Ascent): replace Lineartronic CVT fluid every 30,000 miles severe / 60,000 normal. Subaru High-Torque CVT-II fluid only — incorrect fluid destroys the chain-and-pulley system.

Estimated cost — typical U.S. ranges

Dealer

~$360–$500

Shop

~$255–$355

DIY

~$80–$180

CVT fluid is manufacturer-specific and pricey — do NOT substitute conventional ATF.

Timing Belt (EJ25 engines, pre-2011)

Every 105,000 mi

Older Subarus with the EJ25 boxer engine (Forester, Outback, Legacy 1996-2010): replace timing belt every 105,000 miles. FB and FA boxer engines (2011+) use a chain — no scheduled replacement.

Estimated cost — typical U.S. ranges

Dealer

~$935–$1175

Shop

~$655–$825

DIY

Pro only

On interference engines, a snapped belt destroys valves. Worth doing on schedule. Bundle water pump + tensioner — labor is already there.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 30 months. Subaru's brake hold and EyeSight automatic emergency braking depend on uncontaminated fluid.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace engine air filter every 30,000 miles. WRX/STI: inspect every oil change due to the higher airflow demand of the turbo intake.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Spark Plugs

Every 60,000 mi

Iridium plugs every 60,000 miles on FB engines. WRX/STI 2.5L turbo: 30,000 miles due to higher cylinder pressures and EGT.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Super Coolant

Every 30,000 mi

Subaru Super Coolant (blue): first change at 137,500 miles or 11 years, then every 30,000 miles. Do not substitute green or orange — head gasket sealing chemistry depends on the formula.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 15,000 mi

Replace cabin air filter every 15,000 miles. Behind the glove box on most Subaru models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

56 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

23

complaints mentioning a crash

6

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2011 Subaru Outback reflects Subaru's published service intervals. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →