Wrench.Pro

2011 Toyota Prius Recalls, Issues & Maintenance

The 2011 Toyota Prius carries 6 open NHTSA recalls — most recently covering hybrid propulsion system and side/window. Owners report 4 recurring issue clusters, led by “Brake booster and ABS actuator failure (C1391).” Toyota's owner's manual splits service into Schedule 1 (severe) and Schedule 2 (normal). Most US drivers fall under Schedule 1 because it covers short trips, extreme temperatures, dusty roads, or heavy idling. The intervals below reflect Schedule 1 — the schedule Toyota recommends for typical real-world use.

6 Open Recalls

Source: NHTSA

HYBRID PROPULSION SYSTEM

Campaign #18V684000 · Apr 10, 2018

Issue: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.

Risk: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.

Fix: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.

AIR BAGS:SIDE/WINDOW

Campaign #16V487000 · Jun 30, 2016

Issue: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.

Risk: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.

Fix: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Campaign #14V743000 · Nov 19, 2014

Issue: Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Risk: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Fix: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

HYBRID PROPULSION SYSTEM: INVERTER

Campaign #14V053000 · Dec 2, 2014

Issue: Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.

Risk: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.

Fix: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Campaign #16V396000 · Feb 6, 2016

Issue: Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Risk: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Fix: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

Campaign #13V014000 · Jan 16, 2013

Issue: Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Risk: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Fix: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2011 Toyota Prius.

1 active NHTSA investigation

Source: NHTSA

  • Brake Actuator Valve Wear

    Action #DP23005 · opened Nov 22, 2023

    The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of…

    View on NHTSA →

Reported to NHTSA

Brake booster and ABS actuator failure (C1391)

SERVICE BRAKES

154 NHTSA complaints · 2019-09 → 2026-08

“Brake booster and brake booster pump failure”
— Owner report, NHTSA ODI #11510445
“My ability to break unexpectedly stopped working while I was on the highway during morning, rush-hour. I was going 55 mph on the highway at the time and luckily, I was on an uphill incline when they went out, thus allowing me to be able to ‘naturally’ slow down”
— Owner report, NHTSA ODI #11660213
“The contact owns a 2011 Toyota Prius. The contact stated that while driving at 60 MPH, the brake pedal was depressed but hesitated to respond”
— Owner report, NHTSA ODI #11441462

Read all complaints on NHTSA →

Premature low-beam headlight bulb failure

EXTERIOR LIGHTING

10 NHTSA complaints · 2019-11 → 2024-12

“Attached is a report from the Florida Attorney General's project office. Vehicle front headlight bulbs burn out prematurely and frequently and without warning causing reduced visibility at night on dark roads”
— Owner report, NHTSA ODI #11629190
“BOTH OF MY PRIUS LOW BEAMS WENT OUT AT THE SAME TIME, I THOUGHT IT WAS UNUSUAL AS BOTH HEADLIGHTS SHOULD NOT GO OUT SIMULTANEOUSLY”
— Owner report, NHTSA ODI #11319191
“LOW BEAM HEADLIGHTS ARE BURNING OUT WITHIN A WEEK OF INSTALLATION. WHEN BULBS ARE REPLACED, ONE OF THE TWO BULBS WILL BURN OUT WITHIN A WEEK, YET THE OTHER BULB WILL STAY ACTIVE. BOTH SIDES ARE AFFECTED. IT RANDOMLY CHOOSES WHICH SIDE TO BURN OUT”
— Owner report, NHTSA ODI #11282595

Read all complaints on NHTSA →

Airbag deployment failure or malfunction

AIR BAGS

7 NHTSA complaints · 2019-09 → 2025-08

“The contact owned a 2011 Toyota Prius. The contact stated while driving at an undisclosed speed in an intersection, a Ford F-150 vehicle crashed into the front driver's side of the vehicle”
— Owner report, NHTSA ODI #11678773
“ON Sept 9th, 2022, I was involved in a collision, traveling approximately 30 - 40 MPH and struck a vehicle that pulled into my path. I struck the other vehicle perpendicularly (T-Boned)”
— Owner report, NHTSA ODI #11484210
“The contact owns a 2011 Toyota Prius. The contact stated that she was hit by another vehicle while turning left onto a highway at 5 MPH. The contact was hit on her driver-side door at approximately 60 MPH and the airbags did not deploy upon impact”
— Owner report, NHTSA ODI #11448873

Read all complaints on NHTSA →

Hybrid propulsion system stall or shutdown

HYBRID PROPULSION SYSTEM

6 NHTSA complaints · 2020-03 → 2025-04

“The contact owns a 2011 Toyota Prius. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, the vehicle had unexpectedly shut off”
— Owner report, NHTSA ODI #11657571
“The contact owns a 2011 Toyota Prius. The contact stated while driving at various speeds, the vehicle lost motive power temporarily”
— Owner report, NHTSA ODI #11636448
“THE CONTACT OWNS A 2011 TOYOTA PRIUS. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE VEHICLE STALLED WITH SEVERAL UNKNOWN WARNING LIGHTS ILLUMINATED”
— Owner report, NHTSA ODI #11327176

Read all complaints on NHTSA →

Note: NHTSA also opened 2 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 5,000 mi

Replace 0W-20 full-synthetic oil and filter every 5,000 miles under Schedule 1, or 10,000 miles under Schedule 2. Toyota covers the first 2 oil changes through ToyotaCare.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 5,000 mi

Rotate tires every 5,000 miles. Toyota recommends rotation at every oil change to maximize tire life on FWD and AWD models.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 5,000 mi

Inspect brake pads, rotors, and parking brake every 5,000 miles. Toyota recommends measuring pad thickness at each service.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 36 months. Critical for the integrity of the ABS, VSC, and brake assist systems.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace the engine air filter every 30,000 miles. Earlier under Schedule 1 if driven on unpaved roads.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 60,000 mi

Toyota labels ATF as 'lifetime fill' on most automatics, but recommends inspection and replacement every 60,000 miles under severe service. Use Toyota WS or Type-IV — no substitutes.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 120,000 mi

Toyota iridium-tipped spark plugs are rated for 120,000 miles. Earlier replacement reduces fuel economy and can cause misfires on direct-injection engines.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Super Long Life Coolant (SLLC)

Every 50,000 mi

Toyota SLLC (pink): first change at 100,000 miles, then every 50,000 miles. Do not substitute green or orange coolant — it will damage the cooling system seals.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 30,000 mi

Replace the cabin air filter every 30,000 miles, sooner in dusty climates. Located behind the glove box on most Toyota and Lexus models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Serpentine / Drive Belt Inspection

Every 60,000 mi

Inspect the serpentine belt and tensioner every 60,000 miles. Toyota uses long-life EPDM belts that rarely fail before 100,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Timing Chain — No Replacement

On condition / lifetime

Toyota's 2AR-FE, 2GR-FKS, A25A-FKS, and most Toyota engines built since 2010 use a timing chain rated for the life of the engine. No scheduled replacement.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Pro only

Timing chains are normally lifetime. Listen for rattle on cold start — that's the actionable signal. Replacement is major work, quote separately.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

82 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

36

complaints mentioning a crash

7

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2011 Toyota Prius reflects Toyota's published service intervals and the Maintenance Required Light system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →