Wrench.Pro

2012 Audi Q7 Recalls, Issues & Maintenance

The 2012 Audi Q7 carries 4 open NHTSA recalls — most recently covering fuel pump. Owners report 5 recurring issue clusters, led by “Crankshaft pulley/harmonic balancer failure.” Audi follows the VW Group Longlife service rhythm: oil and minor service every 10,000 miles or 12 months, whichever comes first, using oil that meets VW 502 00 / 504 00 (or 508 00 for newer 0W-20 engines) — generic synthetic does not qualify. S tronic dual-clutch gearboxes need fluid service every 40,000 miles despite 'lifetime fill' claims. Fully electric models (e-tron, e-tron GT) skip oil service entirely but keep brake-fluid, cabin-filter, and coolant-circuit intervals.

4 Open Recalls

Source: NHTSA

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Campaign #18V818000 · Nov 19, 2018

Issue: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2007-2012 Audi Q7 and 2009-2012 Audi Q5 vehicles, previously repaired under NHTSA recall 16V-660. These vehicles were previously repaired with an interim repair of installing butyl tape to the fuel pump flange, until replacement remedy parts became available.

Risk: The butyl tape may not prevent fuel from leaking. A fuel leak in the presence of an ignition source can increase the risk of a fire.

Fix: Volkswagen will notify owners, and dealers will replace the fuel pump flange and install butyl tape, free of charge. The recall began December 28, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20BJ.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Campaign #16V660000 · Sep 13, 2016

Issue: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2012 Audi Q5, and 2007-2012 Audi Q7 vehicles equipped with gasoline engines. The fuel pump flange on the affected vehicles may crack, allowing fuel to leak.

Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.

Fix: Audi will notify owners, and dealers will inspect the flange, replacing any flanges that are cracked. If the flange is not cracked, dealers will clean the pump flange and install a butyl rubber band to protect the pump. These repairs will be made free of charge. The recall began November 9, 2016. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20W9.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL

Campaign #15V019000 · Jan 20, 2015

Issue: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2011-2012 Audi S4, S5, Q7, 2012 Audi A6, Volkswagen Touareg Hybrid, and 2012-2013 Audi A7 vehicles. In the affected vehicles the fuel injection system may experience a fuel leak.

Risk: A fuel leak in the injection system in the presence of an ignition source, increases the risk of a fire.

Fix: Volkswagen will notify owners, and dealers will replace the fuel rails and corresponding seals, free of charge. The recall began on March 17, 2015. Owners may contact Audi customer service at 1-800-822-2834 or Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 24AP for Audi customers and 24BK for Volkswagen customers.

EQUIPMENT:OTHER:LABELS

Campaign #23V086000 · Feb 15, 2023

Issue: Volkswagen Group of America, Inc. (Audi) is recalling certain 2009-2015 Q7 vehicles. The Gross Axle Weight Rating (GAWR) listed on the certification label is incorrect, which can allow the vehicle to be overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims," and Part 567, "Certification."

Risk: An overloaded vehicle can increase the risk of a crash.

Fix: Dealers will install an overlay label containing the correct rear GAWR on top of the existing safety certification label, free of charge. Owner notification letters were mailed April 24, 2023. Owners may contact Audi's customer service at 1-800-253-2834. Audi's number for this recall is 50G5.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2012 Audi Q7.

Reported to NHTSA

Crankshaft pulley/harmonic balancer failure

STEERING, POWER TRAIN, ELECTRONIC STABILITY CONTROL (ESC)

3 NHTSA complaints · 2019-12 → 2020-06

“CRANK PULLEY HARD RUBBER CORE OR SO CALLED HARMONIC BALANCER BROKE AND SERPENTINE BELT FELL OFF CAUSING TO LOOSE POWER STEERING AND NOT BE ABLE TO STEER. I WAS PULLING OUT OF A HIGHWAY RAMP AND THANKFULLY OTHER CARS WERE ABLE TO AVOID ME DUE TO THE LOW TRAFFIC AT THE TIME OF THE”
— Owner report, NHTSA ODI #11327570
“MAIN PULLEY OR SO CALLED HARMONIC BALANCER BROKE AND SERPENTINE BELT FELL OFF CAUSING TO LOOSE POWER STEERING AND NOT BE ABLE TO STEER I WAS LUCKY THAT JUST MADE IT THE TURN AND I WAS ON STRAIGHT PAT AND LOW SPEED TO STOP SAFELY”
— Owner report, NHTSA ODI #11301540
“CRANKSHAFT PULLEY RIPPED ITSELF APART AT IDLE AFTER VEHICLE WAS STARTED”
— Owner report, NHTSA ODI #11286693

Read all complaints on NHTSA →

Windshield wiper arm failure

VISIBILITY/WIPER

2 NHTSA complaints · 2018-05 → 2019-11

“ON TWO DIFFERENT OCCASIONS THE PASSENGER SIDE WINDSHIELD WIPER ARM HAS SNAPPED OFF DURING HEAVY RAINSTORMS WHILE DRIVING WITHIN NYC'S POSTED SPEED LIMIT ON THE GRAND CENTRAL PARKWAY OF 50 MPH. THE LACK OF VISIBILITY COMPROMISES MY SAFETY AND OTHERS WHILE OPERATING THE VEHICLE”
— Owner report, NHTSA ODI #11280527
“PASSENGER SIDE WIPER ARM BROKE COMPLETELY OFF WHILE DRIVING IN THE RAIN ON A MAIN STREET. IT WAS IN OPERATION AT THE TIME OF INCIDENT”
— Owner report, NHTSA ODI #11096670

Read all complaints on NHTSA →

Fuel pump/tank flange leak and odor

FUEL/PROPULSION SYSTEM

10 NHTSA complaints · 2016-06 → 2025-03

“2012 AUDI Q7 3.0T S LINE PRESTIGE, 91K MILES! STARTED AS SMALL GASOLINE SMELL BECOMING STRONGER THROUGHOUT THE NEXT COUPLE DAYS. SMELLED REALLY STRONG AROUND REAR LEFT DOOR AREA AND INSIDE CABIN. INVESTIGATED FUEL LEAK AND NOTICE UNDERNEATH THE SUV, FUEL DRIPPING DOWN THE SIDE”
— Owner report, NHTSA ODI #11364394
“RECALL 20W9 WAS COMPLETED ABOUT MAY 2018. NO LEAKING OR CRACKS WERE FOUND. BUTYL TAPE WAS PLACED OVER FLANGE TO "PREVENT" FUTURE LEAKS. AUGUST 2020, FUEL FLANGE IS NOW LEAKING. STRONG GASOLINE SMELL FROM OUTSIDE OF VEHICLE. DEALERSHIP SERVICE DEPARTMENT CONFIRMS IT IS LEAKING”
— Owner report, NHTSA ODI #11352544
“VEHICLE HAS A VERY STRONG GASOLINE SMELL AFTER THE VEHICLE HAS BEEN TURNED OFF. THE ODOR IS ESPECIALLY STRONG IN A CONFINED SPACE SUCH A GARAGE. THE SOURCE OF THE ODOR IS NEAR THE DRIVER SIDE REAR TIRE. LIVING IN A VERY WARM CLIMATE, I FEAR THAT A FIRE MAY BE CAUSED BY THE”
— Owner report, NHTSA ODI #10874392

Read all complaints on NHTSA →

Engine oil consumption

ENGINE

5 NHTSA complaints · 2017-07 → 2024-02

“OVER THE PAST YEAR, MY VEHICLE HAS BEEN CONSUMING QUARTS OF ENGINE OIL. DURING MY LAST ENGINE OIL CHANGE, I WAS LEFT TO MINIMUM OIL LEVELS AFTER DRIVING ONLY 250 MILES. NO LEAKS WERE DETECTED IN ENGINE BY MECHANICS AT BOTH DEALERSHIP AND INDEPENDENT SHOPS. THE REMEDY RECOMMEND”
— Owner report, NHTSA ODI #11280524
“LOW OIL LIGHT CAME ON 3,000 MILES AFTER OIL CHANGE. NOTICED OIL ON GROUND UNDER VEHICLE WHERE IT IS PARKED IN GARAGE. TOOK IT BACK TO AUDI SERVICE CENTER AND THEY WENT OVER IT AND SAID THAT IT NEEDS THE PCV (PRESSURE CONTROL VALVE) REPLACED AS THEY HAVE SEEN THIS IN THE PAST ON”
— Owner report, NHTSA ODI #11101473
“TL* THE CONTACT OWNS A 2012 AUDI AUDI Q7. ON SEVERAL OCCASIONS, WHILE DRIVING, THE VEHICLE STARTED TO SHAKE. THE CONTACT PULLED OVER, OPENED THE HOOD, CHECKED THE DIPSTICK, AND NOTICED THAT THE OIL WAS LOW. THE CONTACT STATED THAT THE OIL BURNED FAST AND HE HAD TO ADD TWO EXTRA”
— Owner report, NHTSA ODI #11006007

Read all complaints on NHTSA →

Brake system failure

SERVICE BRAKES, HYDRAULIC

2 NHTSA complaints · 2019-03 → 2026-01

“TL* THE CONTACT OWNS A 2012 AUDI Q7. WHILE DRIVING 50 MPH APPROACHING A STOP LIGHT WITH THE BRAKE PEDAL DEPRESSED, THE BRAKES FAILED TO STOP THE VEHICLE. THE CONTACT QUICKLY APPLIED THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO AUDI MARIETTA (LOCATED AT 1141”
— Owner report, NHTSA ODI #11189715
“On or December 5th, 2025 (4 days after taking possession of the vehicle, I experienced a sudden and severe steering system failure while driving. When turning the steering wheel (even slightly), the vehicle produced a loud buzzing/grinding noise and the steering effort increased”
— Owner report, NHTSA ODI #11711746

Read all complaints on NHTSA →

Note: NHTSA also opened 1 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (Longlife Service)

Every 10,000 mi

Replace oil and filter every 10,000 miles or 12 months with VW 502 00 / 504 00 / 508 00 spec oil. S and RS models driven hard: many owners shorten to 5,000-7,500 miles. Wrong-spec oil is the leading cause of TFSI timing-chain tensioner and PCV problems.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 10,000 mi

Rotate every 10,000 miles with the oil service. quattro models: keep all four tires within 4/32" of each other — mismatched wear stresses the center differential.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 10,000 mi

Inspect pads, rotors, and wear sensors every 10,000 miles. Audi uses electronic pad-wear sensors on most models — replace the sensor with the pads.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 24,000 mi

Replace DOT 4 brake fluid every 2 years regardless of mileage — Audi's published schedule is time-based because the fluid absorbs moisture.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

S tronic Dual-Clutch Fluid

Every 40,000 mi

S tronic (DSG) gearboxes on A3/S3/RS 3, Q3, TT, and many A5/Q5 models: replace fluid and filter every 40,000 miles with the VW Group-spec fluid for your gearbox code. Skipping this service is the most common cause of mechatronic failure.

Estimated cost — typical U.S. ranges

Dealer

~$470–$640

Shop

~$330–$450

DIY

Pro only

VW/Audi DSG service needs a fluid-fill procedure at a specific temperature — shop equipment territory.

Important maintenance

Keeps your vehicle running smoothly and efficiently

quattro Coupling Fluid (Transverse Models)

Every 40,000 mi

A3/S3/RS 3, Q3, and TT use a Haldex-style rear coupling: replace its fluid roughly every 40,000 miles (some model years specify sooner — check your manual). Longitudinal quattro (A5-A8, Q5, Q8) has no coupling service; see differential fluid instead.

Estimated cost — typical U.S. ranges

Dealer

~$220–$290

Shop

~$155–$205

DIY

~$40–$90

VW/Audi/Volvo AWD coupling — specific fluid required. Filter usually swapped at the same time.

Spark Plugs

Every 40,000 mi

TFSI turbo engines: new plugs every 40,000 miles. RS models with the 2.5 TFSI five-cylinder: consider 30,000 miles under track or hard street use.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Air Filter

Every 40,000 mi

Replace every 40,000 miles; inspect at 20,000 on turbocharged engines — a clogged filter shows up as sluggish boost response first.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Timing Chain (EA888 — Inspect Tensioner)

On condition / lifetime

2.0 TFSI (EA888) engines before roughly 2013 had timing-chain tensioner failures — have the tensioner revision checked by 80,000 miles on earlier cars. Later engines carry the updated design with no scheduled service.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Pro only

Timing chains are normally lifetime. Listen for rattle on cold start — that's the actionable signal. Replacement is major work, quote separately.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Differential Fluid (Longitudinal quattro)

Every 60,000 mi

Q5, Q8, and A5-A8 quattro: independent Audi specialists recommend front/rear differential fluid service around 60,000 miles even where Audi lists it as lifetime fill.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Dust & Pollen Filter

Every 20,000 mi

Replace the cabin air filter every 20,000 miles or 2 years. Audi specifies an activated-carbon filter on most models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

G12evo / G13 Coolant

On condition / lifetime

Audi coolant is labeled lifetime fill. Independent VW/Audi specialists recommend a refresh around 5 years or 100,000 miles to protect the water pump and thermostat housing — and only with the correct pink/lilac VW Group coolant.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

2 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

1

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2012 Audi Q7 reflects Audi's published service intervals and the Audi Service Interval Display system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →