2012 Chevrolet Captiva Sport Recalls, Problems & Maintenance
The 2012 Chevrolet Captiva Sport carries 2 open NHTSA recalls — most recently covering power steering fluid and parking brake. No recurring owner-reported issue clusters are on file. Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.
2 Open Recalls
Source: NHTSASTEERING:HYDRAULIC POWER ASSIST:POWER STEERING FLUID
Campaign #11V591000 · Dec 19, 2011
STEERING:HYDRAULIC POWER ASSIST:POWER STEERING FLUID
Campaign #11V591000 · Dec 19, 2011
Issue: GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET CAPTIVA VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH APRIL 21, 2011. DRIVING THE VEHICLE WITH THE TRANSMISSION IN MANUAL MODE AND IN FIRST GEAR CAUSES THE ENGINE AND POWER STEERING PUMP TO OPERATE AT HIGHER SPEED THAN IS TYPICAL. INCREASED PUMP SPEED GENERATES HEAT THAT IS TRANSFERRED TO THE POWER STEERING FLUID AND CAN RESULT IN POWER STEERING FLUID TEMPERATURES THAT APPROACH THE POWER STEERING PUMP RESERVOIRS MELTING POINT.
Risk: AFTER PROLONGED EXPOSURE TO ELEVATED FLUID TEMPERATURES, THE RESERVOIR MAY LEAK. LEAKING FLUID, IN THE PRESENCE OF AN IGNITION SOURCE, MAY RESULT IN A FIRE.
Fix: GM WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE POWER STEERING FLUID COOLER WITH AN IMPROVED VERSION, FREE OF CHARGE. AN ADVISORY LETTER TO CUSTOMERS, ALONG WITH INSTRUCTIONS, WILL BE MAILED IN JANUARY 2012. WHEN PARTS BECOME AVAILABLE, GM WILL SEND ANOTHER LETTER ASKING CUSTOMER TO TAKE THEIR VEHICLE TO A GM DEALER TO HAVE THE REPAIRS PERFORMED. GM ANTICIPATES PARTS WILL BE AVAILABLE IN MARCH 2012. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
PARKING BRAKE
Campaign #12V301000 · Jun 28, 2012
PARKING BRAKE
Campaign #12V301000 · Jun 28, 2012
Issue: GENERAL MOTORS LLC (GM) IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET CAPTIVA SPORT PASSENGER VEHICLES MANUFACTURED FROM APRIL 26, 2012, THROUGH MAY 17, 2012. THESE VEHICLES FAIL TO CONFORM TO THE PARK BRAKE PERFORMANCE REQUIREMENTS FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "LIGHT VEHICLE BRAKE SYSTEMS." THE PARK BRAKE CABLE MAY NOT BE FULLY SEATED IN ITS CONNECTOR AND MAY SEPARATE FROM THE CONNECTOR. IF THIS OCCURS, THE PARK BRAKE WILL BECOME INOPERATIVE AND WILL NOT HOLD THE VEHICLE.
Risk: IF THE VEHICLE IS ON AN UNEVEN SURFACE, THIS COULD RESULT IN UNINTENDED VEHICLE MOVEMENT AND A CRASH.
Fix: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND ENSURE THAT THE PARK BRAKE CABLES ARE CONNECTED AND SECURE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 27, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.
Known issues & problems for this vehicle
What drivers and federal regulators have officially reported about the 2012 Chevrolet Captiva Sport.
Reported to NHTSA
No common issues reported to NHTSA for the 2012 Chevrolet Captiva Sport. That doesn't mean nothing can go wrong — just that the federal complaint database doesn't flag a pattern.
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Essential maintenance
Critical for safety and preventing major damage
Engine Oil & Filter (per Oil Life System)
Every 7,500 miChange oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Tire Rotation
Every 7,500 miRotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Brake Inspection
Every 7,500 miInspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Brake Fluid
Every 45,000 miGM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Important maintenance
Keeps your vehicle running smoothly and efficiently
Engine Air Filter
Every 45,000 miGM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Automatic Transmission Fluid
Every 45,000 miSevere service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Transfer Case Fluid (4WD)
Every 45,000 miOn 4WD models, replace transfer case fluid every 45,000 miles — sooner if towing or off-roading. Use GM Auto-Trak II fluid.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
Spark Plugs
Every 100,000 miGM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Dex-Cool Engine Coolant
Every 50,000 miGM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Rear Differential Fluid
Every 50,000 miSilverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Recommended maintenance
Extends the life of your vehicle and improves comfort
Cabin Air Filter
Every 22,500 miReplace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Fatal crash history & reported problems
Occupant deaths in fatal crashes (FARS)
44 crashes 1990–2024
How the 44 occupant deaths break down
30
driver deaths
14
passenger deaths
44
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 2012 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Why we show driver deaths too
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
0
complaints mentioning a crash
0
complaints mentioning a fire
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2012 Chevrolet Captiva Sport reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.