Wrench.Pro

2012 Dodge Avenger Recalls, Issues & Maintenance

The 2012 Dodge Avenger carries 3 open NHTSA recalls — most recently covering head restraint and pretensioner. Owners report 6 recurring issue clusters, led by “Passenger-side heater core blocks heat and defrost.” Dodge uses Stellantis' Oil Change Indicator — it watches engine load and duty cycle and messages when to change oil, capped at 10,000 miles or 12 months. Know your engine: the 3.6L Pentastar V6 goes 100,000 miles on plugs, while HEMI V8s carry sixteen plugs (two per cylinder) on a roughly 30,000-mile interval — that's a real cost difference at the service counter. HEMI models with MDS cylinder deactivation are especially sensitive to overdue oil.

3 Open Recalls

Source: NHTSA

SEATS:FRONT ASSEMBLY:HEAD RESTRAINT

Campaign #17V640000 · Oct 10, 2017

Issue: Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.

Risk: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.

Fix: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.

SEAT BELTS:PRETENSIONER

Campaign #16V668000 · Sep 15, 2016

Issue: Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.

Risk: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.

Fix: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.

ELECTRICAL SYSTEM

Campaign #13V282000 · Feb 7, 2013

Issue: Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.

Risk: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.

Fix: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2012 Dodge Avenger.

Reported to NHTSA

Passenger-side heater core blocks heat and defrost

VISIBILITY/WIPER

111 NHTSA complaints · 2018-12 → 2025-11

“Window Defrost and Passenger Heat /Air. While either in motion or while driving, no heated air exits the passenger side of the windshield defroster, nor the passenger window defrost, lower and center console vents”
— Owner report, NHTSA ODI #11699661
“DODGE LEFT RESIDUAL MACHINING DEBRIS IN THE AVENGER ENGINE BLOCKS THAT FLOWS WITH COOLANT INTO THE HEATER CORE AND RADIATOR CAUSING THE HEATER CORE TO CLOG UP AND BLOCKS HEAT TO PASSENGER SIDE IN THE WINTER CAUSING UNSAFE OR UNFIT TO OPERATE IN COLD WEATHER”
— Owner report, NHTSA ODI #11265540
“PROBLEM: HEAT DOES NOT COME OUT OF THE PASSENGER SIDE VENT. AFTER A MONTH OR TWO, NO HEAT AT ALL. THE HEATER CORE WAS REPLACED ON THIS PIECE OF JUNK 3 TIMES (WHICH FIXED THE PROBLEM EACH TIME)”
— Owner report, NHTSA ODI #11162991

Read all complaints on NHTSA →

Active head restraint deploys without warning

SEATS

16 NHTSA complaints · 2019-08 → 2025-04

“The contact called on behalf of her son who owns a 2012 Dodge Avenger. The contact stated that while her son was exiting a parking lot, upon driving over a speed bump, the passenger’s side head restraint unintendedly deployed. There was no warning light illuminated”
— Owner report, NHTSA ODI #11656367
“TL* THE CONTACT OWNS A 2012 DODGE AVENGER. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE FRONTAL PASSENGER'S SEAT HEADREST DEPLOYED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED TO CHECK FOR RECALLS ON THE VEHICLE”
— Owner report, NHTSA ODI #11330402
“ACTIVE HEAD REST DEPLOYED WITHOUT BEING IN AN ACCIDENT. THE PLASTIC THAT HOLDS THE RETAINING PIN BROKE CAUSING THE HEAD REST TO DEPLOY”
— Owner report, NHTSA ODI #11265796

Read all complaints on NHTSA →

Horn sounds continuously from steering wheel short

STEERING, ELECTRICAL SYSTEM

6 NHTSA complaints · 2020-05 → 2022-09

“THE HORN HAS A ELECTRICAL SHORTAGE, WHICH CONTINUES TO HONK, WHILE DRIVING, OR STANDING STILL. YOUR DODGE JEEP CHRYSLER DEALER IN GLENDALE, NOW TELLS ME, THAT THERE IS A SHORT, AND HE KNOWS THAT THE SWITCH IS BAD, AS IT CONTINUES TO HONK WHEN THE HORN IS CONNECTED”
— Owner report, NHTSA ODI #11325150
“WHILE DRIVING DOWN THE STREET, ALL OF SUDDEN MY HORN, STARTS GOING OFF, I TOOK CAR TO MEINEKE SHOP, THEY TOLD ME THE BALANCE INSIDE THE STEERING WHEEL WAS BROKEN, TWO OF THE 3 SPRINGS WERE BROKEN”
— Owner report, NHTSA ODI #11323410
“Was driving and horn just start going off”
— Owner report, NHTSA ODI #11486206

Read all complaints on NHTSA →

Transmission limp mode or clunking on acceleration

POWER TRAIN

5 NHTSA complaints · 2020-06 → 2021-06

“I HAVE A 2012 DODGE AVENGER WITH APPROXIMATELY 76200 MILES ON IT. WHILE ACCELERATING FROM A STOP LIGHT MY TRANSMISSION MADE A CLUNKING SOUND AND MY VEHICLE WOULD ONLY GO ABOUT 30 MILES PER HOUR BUT THE RPMS BUT JUMP UP TO ABOUT 7000 AND STAY THERE”
— Owner report, NHTSA ODI #11397713
“VEHICLE IN LIMP MODE AND WON'T SHIFT GEARS PROPERTY. STARTED AFTER A PURCHASE OF THE VEHICLE HAD NO IDEA THAT THIS WAS GOING TO BE A ISSUE UNTIL I HAD IT FOR ABOUT A WEEK AND ENGINE LIGHT CAME ON AND THEN STARTED THE LIMP MODE AND THEN DRIVING IT IS VERY DANGEROUS”
— Owner report, NHTSA ODI #11389904

Read all complaints on NHTSA →

Engine stalls or shuts off while driving

ENGINE

24 NHTSA complaints · 2019-01 → 2026-05

“My car dies while im driving down the street, making it difficult to steer and qhen you try to restart it, sometimes it starts and some times it don't. But this is not the first time its happened it was just the latest”
— Owner report, NHTSA ODI #11739856
“ON APRIL 7TH 2020 I WAS DRIVING UP A HILL IN A RESIDENTIAL AREA. WHEN I GOT TO THE PEAK OF THE HILL AND I WENT TO TURN LEFT, THE CAR SHUT OFF AND THERE WAS NO POWER. I HAD TO PUT THE CAR IN NEUTRAL AND RESTART THE ENGINE. IT STARTED IMMEDIATELY”
— Owner report, NHTSA ODI #11321479
“While driving for about 50miles, the electrical system failed, I lost power to the entire vehicle, steering was hard, brakes hard as well. as I pulled over, the car started back up. Next day car drove fine”
— Owner report, NHTSA ODI #11562756

Read all complaints on NHTSA →

Air bags fail to deploy in a crash

AIR BAGS

4 NHTSA complaints · 2018-12 → 2023-03

“Was hit from the rear emd amd air bags did not deploy. Back bumper was totally destroyed amd brakes go out fast”
— Owner report, NHTSA ODI #11513774
“Air Bags from Steering Wheel did not deploy in a at fault rear end accident. Driver suffered from neck and back injuries. Problem has not been inspected. No warning lamps”
— Owner report, NHTSA ODI #11444286

Read all complaints on NHTSA →

Note: NHTSA also opened 1 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (Oil Change Indicator)

Every 10,000 mi

Change when the indicator says so — never beyond 10,000 miles or 12 months. Pentastar 3.6L: 0W-20. HEMI 5.7L: 5W-20 (0W-40 for 6.4L SRT). MDS-equipped HEMIs punish stretched oil intervals with lifter and cam wear.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 8,000 mi

Rotate every 8,000 miles. Charger/Challenger R/T and Scat Pack: staggered-width setups can't rotate front-to-rear — budget rear tires accordingly.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 10,000 mi

Inspect pads and rotors at every oil change. Heavy Durangos used for towing and hard-driven Chargers both run through rear pads faster than the front-pad-first rule of thumb suggests.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Spark Plugs

Every 30,000 mi

HEMI 5.7L: sixteen plugs roughly every 30,000 miles — check your year's manual. Pentastar 3.6L (Charger/Challenger V6, Durango V6, Journey, Grand Caravan): 100,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Automatic Transmission Fluid

Every 60,000 mi

Grand Caravan/Journey (62TE): ATF+4 service every 60,000 miles in family duty. Charger/Challenger/Durango with the TorqueFlite 8-speed: no published normal interval, but specialists recommend service around 60,000-100,000 miles — sooner with towing.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Rear Differential Fluid

Every 60,000 mi

RWD Charger/Challenger and AWD Durango: replace rear diff fluid around 60,000 miles, sooner with towing or drag-strip duty. Limited-slip units need the friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Engine Air Filter

Every 30,000 mi

Replace every 30,000 miles. HEMIs pull serious airflow — a clogged filter costs measurable power before it throws a code.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Serpentine Belt

Every 60,000 mi

Inspect from 60,000 miles, replace on cracking or glazing. On the HEMI, a shredded belt can take the cooling drive with it mid-drive.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 20,000 mi

Replace every 20,000 miles where equipped (behind the glovebox on most models). Some earlier Journeys and Avengers shipped without one — check before buying a filter.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Coolant Replacement (OAT)

Every 100,000 mi

Stellantis OAT coolant is scheduled for 10 years / 150,000 miles; shops commonly refresh by 100,000. OAT-compatible coolant only — mixing chemistries gels the system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Battery Test & Service

Every 25,000 mi

Test annually after year 3. Big-audio Chargers and tow-package Durangos lean on the battery hard; weak batteries surface as gremlins in the electronics before they fail to crank.

Estimated cost — typical U.S. ranges

Dealer

~$225–$390

Shop

~$160–$280

DIY

~$130–$250

Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

81 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

34

complaints mentioning a crash

7

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2012 Dodge Avenger reflects Dodge's published service intervals and the Oil Change Indicator System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →