Wrench.Pro

2012 Dodge Caliber Recalls, Issues & Maintenance

The 2012 Dodge Caliber carries 1 open NHTSA recall — most recently covering pretensioner. Owners report 5 recurring issue clusters, led by “Subframe and frame rust-through.” Dodge uses Stellantis' Oil Change Indicator — it watches engine load and duty cycle and messages when to change oil, capped at 10,000 miles or 12 months. Know your engine: the 3.6L Pentastar V6 goes 100,000 miles on plugs, while HEMI V8s carry sixteen plugs (two per cylinder) on a roughly 30,000-mile interval — that's a real cost difference at the service counter. HEMI models with MDS cylinder deactivation are especially sensitive to overdue oil.

1 Open Recall

Source: NHTSA

SEAT BELTS:PRETENSIONER

Campaign #16V668000 · Sep 15, 2016

Issue: Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.

Risk: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.

Fix: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2012 Dodge Caliber.

Reported to NHTSA

Subframe and frame rust-through

STRUCTURE

11 NHTSA complaints · 2018-11 → 2026-02

“Rear subframe rotted out, detached at tire arm...see many complaints online”
— Owner report, NHTSA ODI #11720594
“Subframe on the vehicle at 90,000 was found to have SEVERE huge rotted holes in the subframe that is supporting the engine. This can allow the engine to drop out of the vehicle at any given moment and cost to repair is $1200 which is insane”
— Owner report, NHTSA ODI #11484938
“THE STRUCTURE/FRAME IN THE FRONT OF OUR 2012 DODGE CALIBER WAS SO RUSTED THAT IT BROKE WHILE WE WERE DRIVING. THE FRAME BROKE WHEN WE PULLED OFF OF THE INTERSTATE AND STOPPED AT THE END OF AN EXIT. THIS ISSUE HAS NOT BEEN ADDRESSED BY A RECALL, B UT A BULLETIN HAS BEEN RELEASED”
— Owner report, NHTSA ODI #11153047

Read all complaints on NHTSA →

Throttle body and electronic stability control malfunction

ELECTRONIC STABILITY CONTROL (ESC)

8 NHTSA complaints · 2014-07 → 2022-03

“The contact owns a 2012 Dodge Caliber. The contact stated while driving at 15 MPH, the stability and throttle body malfunction indicators warning lights illuminated. The vehicle was taken to an independent mechanic. The vehicle was not diagnosed or repaired”
— Owner report, NHTSA ODI #11458149
“WHEN BRAKING THE ELECTRIC THROTTLE CONTROL LIGHT FLASHES MOMENTARILY. IT DOES NOT STAY ON. THE CAR DOES NOT BRAKE COMPLETELY AT THESE TIMES AND CONTINUES TO ACCELERATE AND MOVE FORWARD ANOTHER FOOT OR TWO DESPITE PRESSING THE BRAKE”
— Owner report, NHTSA ODI #11180654
“MY OILS AND FLUID LEVELS WERE FINE. I HAVE ABOUT 74,000 ON MY VEHICLE, AND JUST HAD A RECENT OIL CHANGE ABOUT 300 MILES OR SO AGO. WHILE DRIVING AROUND 35 MPH ON A LOCAL STREET, MY VEHICLE''S CHECK ENGINE LIGHT AND ABS LIGHT CAME ON”
— Owner report, NHTSA ODI #10926370

Read all complaints on NHTSA →

Airbag and seat belt pretensioner recall parts unavailable

AIR BAGS, SEAT BELTS

11 NHTSA complaints · 2017-02 → 2020-09

“TL* THE CONTACT OWNS A 2012 DODGE CALIBER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V668000 (SEAT BELTS, AIR BAGS). THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE”
— Owner report, NHTSA ODI #11003268
“NOTIFIED IN SEPTEMBER 2016 OF A RECALL ON THIS CAR BUT NO REMEDY AT THAT TIME WAS AVAILABLE. AS OF TODAY, MAY 6, 2017, THERE IS STILL NO REMEDY. THE PARTS AFFECTED WITH THIS RECALL COULD CONTRIBUTE TO INCREASED RISK FOR INJURY IN A CRASH”
— Owner report, NHTSA ODI #10983805

Read all complaints on NHTSA →

Airbags failed to deploy in crash

AIR BAGS

4 NHTSA complaints · 2012-09 → 2017-10

“AIR BAGS DID NOT DEPLOY IN MY CAR ACCIDENT IN APRIL 2017, CAR WAS TOTALED. RECEIVED CONCUSSION AND WHIPLASH AS A RESULT OF MY AIR BAGS NOT DEPLOYING. MY CAR WAS REG MAINTAINED AT THE DODGE DEALERSHIP ON RIVER DALE RD, OGDEN, UT CALLED IN AND SPOKE WITH A REP (SHAY) 10/09/2017”
— Owner report, NHTSA ODI #11032349
“I WAS INVOLVED IN A CAR ACCIDENT ON THURSDAY WHERE I HIT A GUARD RAIL PRETTY HARD AND DEAD ON. AT THE TIME I WAS GOING 35 MPH IN THE POURING RAIN. MY AIRBAGS NEVER DEPLOYED”
— Owner report, NHTSA ODI #10639697
“A CAR HIT US IN THE PASSENGER DOOR WE ROLLED AND SLID AND NONE OF THE SIDE CURTAIN AIR BAGS WENT OFF. *TR”
— Owner report, NHTSA ODI #10477459

Read all complaints on NHTSA →

Shifter and ignition interlock roll-away

POWER TRAIN, VEHICLE SPEED CONTROL

3 NHTSA complaints · 2013-09 → 2013-10

“MT 2012 DODGE CALIBER HAD A ROLL AWAY INCIDENT ON 9/6/2103 WHEN PARKED IN A DRIVEWAY. IT ROLLED AND THEN DOVE DOWN A VERY STEEP HILL WITH TREES WHICH EVENTUALLY STOPPED THE CAR ROLLING DOWN THE HILL. THE MANUFACTURER DEFECT HAS BEEN DIAGNOSED AS A FAILURE OF THE SHIFTER ASSEMBLY”
— Owner report, NHTSA ODI #10546385
“MY DODGE CALIBER 2012 SXT STILL UNDER WARRANTY HAD A FAILED MANUFACTURER COMPONENT, THE 'SHIFT INTERLOCK ASSEMBLY' WHICH CONTROLS DRIVE, PARK, REVERSE, NUETRAL AND ALL TRANSMISSION SETTINGS. VEHICLE WAS PARKED ON BLACKTOP AREA BEHIND MY HOUSE AND ROLLED FORWARD”
— Owner report, NHTSA ODI #10544259
“IGNITION KEY CAN BE REMOVED FROM ANY POSITION. DRIVE, NEUTRAL, REVERSE OR ANY. THIS LETS VEHICLE KEY BE REMOVED WITHOUT BEING IN PARK POSITION. THE 2012 DODGE CALIBER CAN JUST ROLL AWAY. CAUGHT CAR A FEW TIMES ROLLING. NOW HAD A VERY RECENT SERIOUS CRASH”
— Owner report, NHTSA ODI #10543786

Read all complaints on NHTSA →

Note: NHTSA also opened 1 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (Oil Change Indicator)

Every 10,000 mi

Change when the indicator says so — never beyond 10,000 miles or 12 months. Pentastar 3.6L: 0W-20. HEMI 5.7L: 5W-20 (0W-40 for 6.4L SRT). MDS-equipped HEMIs punish stretched oil intervals with lifter and cam wear.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 8,000 mi

Rotate every 8,000 miles. Charger/Challenger R/T and Scat Pack: staggered-width setups can't rotate front-to-rear — budget rear tires accordingly.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 10,000 mi

Inspect pads and rotors at every oil change. Heavy Durangos used for towing and hard-driven Chargers both run through rear pads faster than the front-pad-first rule of thumb suggests.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Spark Plugs

Every 30,000 mi

HEMI 5.7L: sixteen plugs roughly every 30,000 miles — check your year's manual. Pentastar 3.6L (Charger/Challenger V6, Durango V6, Journey, Grand Caravan): 100,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Automatic Transmission Fluid

Every 60,000 mi

Grand Caravan/Journey (62TE): ATF+4 service every 60,000 miles in family duty. Charger/Challenger/Durango with the TorqueFlite 8-speed: no published normal interval, but specialists recommend service around 60,000-100,000 miles — sooner with towing.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Rear Differential Fluid

Every 60,000 mi

RWD Charger/Challenger and AWD Durango: replace rear diff fluid around 60,000 miles, sooner with towing or drag-strip duty. Limited-slip units need the friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Engine Air Filter

Every 30,000 mi

Replace every 30,000 miles. HEMIs pull serious airflow — a clogged filter costs measurable power before it throws a code.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Serpentine Belt

Every 60,000 mi

Inspect from 60,000 miles, replace on cracking or glazing. On the HEMI, a shredded belt can take the cooling drive with it mid-drive.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 20,000 mi

Replace every 20,000 miles where equipped (behind the glovebox on most models). Some earlier Journeys and Avengers shipped without one — check before buying a filter.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Coolant Replacement (OAT)

Every 100,000 mi

Stellantis OAT coolant is scheduled for 10 years / 150,000 miles; shops commonly refresh by 100,000. OAT-compatible coolant only — mixing chemistries gels the system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Battery Test & Service

Every 25,000 mi

Test annually after year 3. Big-audio Chargers and tow-package Durangos lean on the battery hard; weak batteries surface as gremlins in the electronics before they fail to crank.

Estimated cost — typical U.S. ranges

Dealer

~$225–$390

Shop

~$160–$280

DIY

~$130–$250

Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

19 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

9

complaints mentioning a crash

3

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2012 Dodge Caliber reflects Dodge's published service intervals and the Oil Change Indicator System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →