Wrench.Pro

2012 Mitsubishi Outlander Recalls, Issues & Maintenance

The 2012 Mitsubishi Outlander carries 6 open NHTSA recalls — most recently covering motor and belts and associated pulleys. Owners report 6 recurring issue clusters, led by “Visibility/wiper recall repair parts unavailable.” Mitsubishi publishes short, conservative intervals: oil every 7,500 miles normal / 3,750 severe, and — unlike many rivals — an explicit CVT fluid replacement schedule rather than a 'lifetime fill' claim. Read the severe-service column honestly: stop-and-go city trips, short hops, and hot climates all qualify, and they describe how most Mirages actually live. The 10-year/100,000-mile powertrain warranty stays intact only with documented on-schedule service.

6 Open Recalls

Source: NHTSA

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

Campaign #17V461000 · Jul 20, 2017

Issue: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2007-2013 Outlander vehicles. In the affected vehicles, water may drop between the hood and the windshield and leak into the wiper motor breathing hole. The water may cause internal corrosion of the windshield wiper motor and the possible failure of the motor.

Risk: Failure of the wiper motor can cause a loss of visibility, increasing the risk of a crash.

Fix: MMNA will notify owners, and dealers will replace the wiper motor, free of charge. The recall began July 28, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-17-003.

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

Campaign #18V069000 · Jan 26, 2018

Issue: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2009-2012 Lancer, 2008-2012 Outlander, 2010-2012 Lancer Sportback, and 2011-2012 Outlander Sport vehicles equipped with either a 4B11 or 4B12 engine. The drive belt automatic tensioner flange may crack, allowing the accessory drive belt to detach.

Risk: If the drive belt detaches, the battery will discharge and the engine will stall, increasing the risk of a crash.

Fix: MMNA will notify owners, and dealers will replace the belt tensioner with one that has an improved shape, free of charge. The recall is expected to begin March 27, 2018. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-18-001.

VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES

Campaign #16V791000 · Oct 31, 2016

Issue: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2007-2013 Outlander vehicles manufactured September 8, 2006, to March 29, 2013. In the affected vehicles, water may enter between the hood and windshield and cause the front wiper link ball joint to corrode, possibly resulting in the wiper link separating and the wipers becoming inoperative.

Risk: Loss of wiper function can reduce visibility and increase the risk of a crash.

Fix: MMNA will notify owners, and dealers will replace the rubber boot on the ball joint to prevent water intrusion. Additionally, they will inspect the wiper motor crank arm for excessive play, replacing it as necessary. These repairs will be done free of charge. The recall began on July 28, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-009.

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

Campaign #16V458000 · Jun 23, 2016

Issue: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2002-2007 Lancer, 2004 Lancer Wagon, 2003-2006 Lancer Evolution, 2003-2006 Outlander and 2007-2013 Outlander V-6 vehicles originally sold in, or ever registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, the front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.

Risk: A detached front control arm can result in the loss of control of the vehicle, increasing the risk of a crash.

Fix: MMNA will notify owners, and dealers will inspect the front cross members. Depending on the level of existing corrosion, either a sealing/anti-corrosion agent will be applied or the front cross member will be replaced with a new one that has a sealing/anti-corrosion agent applied to it. These repairs will be performed free of charge. The recall began January 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-003.

STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

Campaign #14V366000 · Jun 25, 2014

Issue: Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2013 Outlander vehicles equipped with a 6-speed automatic transmission. Additionally, Mitusbishi is recalling certain 2007-2012 Outlander vehicles that received replacement 6-speed automatic transmissions during servicing. The transmissions in these vehicles have insufficient clearance between the power steering pressure tube and the converter housing of the automatic transmission. As a result of the contact, the power steering pressure tube may develop a hole and leak power steering fluid.

Risk: A power steering fluid leak could result in a loss of steering assistance, increasing the risk of a crash.

Fix: Mitsubishi will notify owners, and dealers will replace the power steering pressure tube and return tube, free of charge. The recall began in August 2014. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-14-006.

STRUCTURE:FRAME AND MEMBERS

Campaign #20V279000 · May 18, 2020

Issue: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2008-2010 Lancer, 2009-2010 Lancer Sportback, 2008-2013 Outlander, and 2011-2016 Outlander Sport vehicles originally sold in, or ever registered in, Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. The front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.

Risk: A detached front control arm can result in a loss of vehicle control, increasing the risk of a crash.

Fix: MMNA will notify owners, and dealers will inspect the front cross members. Depending on the level of existing corrosion, either a sealing/anti-corrosion agent will be applied or the front cross member will be replaced with a new one. These repairs will be performed free of charge. The recall began August 7, 2020. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-20-003.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2012 Mitsubishi Outlander.

Reported to NHTSA

Visibility/wiper recall repair parts unavailable

VISIBILITY/WIPER

5 NHTSA complaints · 2016-11 → 2017-07

“TL* THE CONTACT OWNS A 2012 MITSUBISHI OUTLANDER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V791000 (VISIBILITY) AND STATED THAT THE PART WAS NOT AVAILABLE WITHIN A REASONABLE TIME FRAME TO SCHEDULE THE RECALL REPAIR. THE DEALER (LARRY JAY MITSUBISHI, 8415”
— Owner report, NHTSA ODI #11006722
“TL* THE CONTACT OWNS A 2012 MITSUBISHI OUTLANDER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V791000 (VISIBILITY); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL”
— Owner report, NHTSA ODI #10959748
“TAKATA RECALL WHEN DRIVING MY VEHICLE MAKES A WINING SOUND FROM THE ENGINE IN THE VEHICLE WHEN I AM DRIVING. SECOND PROBLEM IS THE MY WINDHIELD WIPER NO LONGER HOLD WATER AND IT IS LEAKING OUT COMPLETELY. THE WINDSHIELD WIPER WORKED WHEN PURCHASED AND THE ENGINE LOUD WINING”
— Owner report, NHTSA ODI #10925524

Read all complaints on NHTSA →

Suspension component wear: struts, control arms, CV boots

SUSPENSION

4 NHTSA complaints · 2015-02 → 2024-08

“The contact owns a 2012 Mitsubishi Outlander. The contact stated that while driving on several occasions at various speeds, she observed a rubbing noise emanating from underneath the vehicle. The contact stated that on one of those occasions, the check engine warning light”
— Owner report, NHTSA ODI #11608802
“TL* THE CONTACT OWNS A 2012 MITSUBISHI OUTLANDER. WHILE DRIVING VARIOUS SPEEDS, THE REAR OF THE VEHICLE WOULD WOBBLE. THE VEHICLE WAS TAKEN TO DAYTONA MITSUBISHI (LOCATED AT 510 N NOVA RD, DAYTONA BEACH, FL 32114), BUT WAS NOT DIAGNOSED OR REPAIRED. IN ADDITION, THE VEHICLE WAS”
— Owner report, NHTSA ODI #11082555
“SQUEAKING NOISE FROM THE FRONT SUSPENSION AND OIL LEAKAGE FROM THE FRONT LEFT STRUT, (SHOCK ABSORBER), OR DRIVER SIDE. DEALER ORDERED AND WILL REPLACE UNDER WARRANTY THE LEFT SIDE STRUT BUT REPLACING ONLY ONE SIDE IN A FRONT WHEEL DRIVE VEHICLE WITH 50,638 MILES WILL CAUSE THE”
— Owner report, NHTSA ODI #10690800

Read all complaints on NHTSA →

Frame and subframe corrosion after recall inspection

STRUCTURE

2 NHTSA complaints · 2021-07 → 2024-04

“The vehicle has extreme rust and corrosion. Car was service under the manufacturer recall on [XXX] 2020. The subframe crossmember has rusted so bad that it is a safety hazard. On my paperwork from the dealership it stated that anti-corrosion aerosol was applied with NOX RUST”
— Owner report, NHTSA ODI #11585549
“The contact owns a 2012 Mitsubishi Outlander Sport. The contact stated upon looking under the vehicle, the contact noticed that the whole frame and upper panel were completely rusted. The contact was relating the failure to NHTSA campaign number: 16V867000 (Structure). The”
— Owner report, NHTSA ODI #11424791

Read all complaints on NHTSA →

Sun visor mounting screw detachment

VISIBILITY

2 NHTSA complaints · 2013-02 → 2014-04

“WHILE IN MOTION, AN ANCHORING SCREW HOLD THE PASSENGER SIDE VISOR TO THE ROOF PANEL FELL OUT INTO MY LAP. AS THE PASSENGER AT THE TIE, I CHECKED THE VISOR, NOTICING THE SCREW FELL FROM ABOVE AND NOTICED THE SECOND OF THE TWO ANCHORING SCREWS WAS NEAR FALLING OUT, ALSO”
— Owner report, NHTSA ODI #10508705
“ONE DAY I NOTICED A SCREW MISSING FROM THE PIECE THAT HOLDS THE VISOR TO THE ROOF AND IT WON'T BE LONG UNTIL THE VISOR FALLS ALL TOGETHER. *JS”
— Owner report, NHTSA ODI #10579398

Read all complaints on NHTSA →

CVT/powertrain premature failure and stalling

POWER TRAIN

7 NHTSA complaints · 2017-06 → 2021-09

“WHILE DRIVING THE TRANSMISSION CAUSES THE POWERTRAIN TO STOP WORKING MAKING THE CAR IMPOSSIBLE TO REMAIN IN MOTION. THIS WILL HAPPEN WHILE DRIVING IN TRAFFIC. THE TRANSMISSION WILL HOWL AND SQUEAL RIGHT BEFORE IT NO LONGER WORKS. WAS TOLD BY MITSUBISHI THAT THE CVT TRANSMISSION”
— Owner report, NHTSA ODI #11270402
“FOLLOWING I JUST SENT TO MITSUBISHI HEADQUARTERS I SEE RECALLS FOR TRANSMISSIONS FOR MY MAKE AND MODEL AND YEAR THAT STATES TRANSMISSION FAIL PREMATURELY BETWEEN THE MILES OF 114,000! AND 179,000 AND MINE DID AT 137,000 IT IS NOW STATING FOR 4 MODEL YEARS 2 OF WHICH ARE”
— Owner report, NHTSA ODI #11124483
“TRANSMISSION/ENGINE MAKES A HIGH PITCHED WHINING NOISE WHEN ACCELERATING ABOVE 2000 RPMS CURRENTLY. IT STARTED OUT ONLY DOING IT WHEN GOING UP HILL AT HIGHER RPMS BUT HAS GOTTEN WORSE. IT HAS ALSO AFFECTED THE ELECTRICAL SYSTEM AND HAD THE LOCKS, BACKUP CAMERA, REVERSE LIGHTS”
— Owner report, NHTSA ODI #10995813

Read all complaints on NHTSA →

Air bag warning light and non-deployment in crash

AIR BAGS

8 NHTSA complaints · 2012-05 → 2024-01

“TL* THE CONTACT OWNS A 2012 MITSUBISHI OUTLANDER SPORT. THE CONTACT STATED THAT WHILE DRIVING ABOUT 45 MPH DURING NIGHT, THE VEHICLE HIT TWO PEDESTRIANS CROSSING THE ROAD AND FATALLY INJURED ONE OF THE PEDESTRIANS. THE OTHER PASSENGER WAS BEING PUSHED IN A WHEELCHAIR AND DID”
— Owner report, NHTSA ODI #11219713
“I JUST HAD ACCIDENT TODAY 02/18/201. MY CAR WAS BADLY DAMAGED AND A POSSIBLE TOTAL LOSS. THE FIRST SITUATION THAT MADE ME CONCERNED ABOUT IS THE AIRBAG. THE SIDE AIRBAG ON THE PASSENGERS SIDE (FRONT AND BACK) DID NOT DEPLOY. THE IMPACT WAS ENORMOUS THAT IF MY CHILD WAS THERE I”
— Owner report, NHTSA ODI #10684164
“I WAS DRIVING IN FREEWAY 110 WHEN THE PASSENGER SIDE AIRBAG LOOSENED AND HANGED SEMI-OPEN. I DID NOT NOTICE IT UNTIL I GOT HOME AND A FRIEND OF MINE CAME WITH ME TO PICK UP MY SON IN SCHOOL. WHEN SHE SAT IN THE FRONT PASSENGER SEAT, SHE NOTICED IT AND POINTED IT OUT TO ME. I”
— Owner report, NHTSA ODI #10459989

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 7,500 mi

Replace every 7,500 miles normal / 3,750 severe. Mirage's 1.2L three-cylinder holds barely over 3 quarts — small sumps punish stretched intervals. 0W-20 on most recent models.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

CVT Fluid

Every 60,000 mi

Mitsubishi schedules CVT fluid replacement — commonly every 60,000 miles normal / 30,000 severe (check your year's table). Use only the specified CVT fluid (J4/CVTF-J4 family); generic ATF destroys the belt-and-pulley unit.

Estimated cost — typical U.S. ranges

Dealer

~$360–$500

Shop

~$255–$355

DIY

~$80–$180

CVT fluid is manufacturer-specific and pricey — do NOT substitute conventional ATF.

Tire Rotation

Every 7,500 mi

Rotate with every oil change. Light Mirages are easy on tires but the economy-focused OEM rubber wears fast when neglected.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors/drums, and lines at each service — Mirage G4 retains rear drums, which need periodic adjustment checks.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace every 2-3 years per the schedule. Cheap job, big ABS-unit insurance.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Spark Plugs

Every 60,000 mi

Iridium plugs commonly every 60,000 miles on the Mirage's 3A92 and Lancer's 4B11 — verify your year's table, as some engines list up to 105,000.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Air Filter

Every 15,000 mi

Mitsubishi's schedule replaces the engine air filter every 15,000 miles — shorter than most brands, and a 5-minute DIY on the Mirage.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Drive Belt

Every 60,000 mi

Inspect from 60,000 miles and replace on cracking. The Mirage's single serpentine belt also drives the A/C — a failure strands the car's accessories at once.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 15,000 mi

Replace every 15,000 miles, behind the glovebox. Often skipped at quick-lube visits — worth checking if airflow feels weak.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Coolant Replacement

Every 60,000 mi

First change around 60,000 miles, then roughly every 30,000-45,000 per the schedule. Mitsubishi long-life coolant or equivalent OAT for your year.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Battery Test & Service

Every 25,000 mi

Test annually after year 3. Small-battery economy cars have little reserve — the first cold snap finds a weak one.

Estimated cost — typical U.S. ranges

Dealer

~$225–$390

Shop

~$160–$280

DIY

~$130–$250

Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

13 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

4

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2012 Mitsubishi Outlander reflects Mitsubishi's published service intervals. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →