Wrench.Pro

2012 Nissan Frontier Recalls, Issues & Maintenance

The 2012 Nissan Frontier carries 3 open NHTSA recalls — most recently covering fuses and circuit breakers and engine and engine cooling. Owners report 6 recurring issue clusters, led by “Automatic transmission shifter fails to engage drive.” Nissan owner's manuals split service into Schedule 1 (severe) and Schedule 2 (normal). Most US drivers fall under Schedule 1. The biggest preventable failure on Nissan vehicles is CVT transmission damage from extended fluid intervals — owners of Altima, Rogue, Sentra, Pathfinder, and Murano with CVT should not skip it.

3 Open Recalls

Source: NHTSA

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

Campaign #14V052000 · Dec 2, 2014

Issue: Nissan North America, Inc. (Nissan) is recalling certain model year 2012 through 2014 Frontier vehicles manufactured from November 28, 2012, through December 17, 2013. In the affected vehicles, a circuit breaker may have been installed incorrectly causing the main wire harness connected to the circuit breaker to face outward, potentially contacting a metal bolt located on the A-pillar.

Risk: The bolt may wear through the wire harness covering, resulting in an electrical short which could cause a fire.

Fix: Nissan will notify owners, and dealers will inspect the circuit breaker orientation. If the circuit breaker orientation is incorrect, dealers will repair the vehicles free of charge. The recall began on March 17, 2014. Owners may contact Nissan at 1-800-647-7261.

ENGINE AND ENGINE COOLING

Campaign #11V592000 · Dec 19, 2011

Issue: NISSAN IS RECALLING CERTAIN MODEL YEAR 2011 INFINITI FX, MODEL YEAR 2012 INFINITI M, MODEL YEAR 2011-2012 NISSAN FRONTIER, MODEL YEAR 2011-2012 NISSAN XTERRA, MODEL YEAR 2011-2012 NISSAN PATHFINDER, AND MODEL YEAR 2012 NISSAN NV VEHICLES. SOME OF THE BOLTS THAT CONNECT THE ENGINE OIL COOLER AND THE ENGINE OIL FILTER TO THE ENGINE IN THESE VEHICLES MAY HAVE BEEN MANUFACTURED TO BELOW SPECIFICATION STRENGTH. AS A RESULT, THE BOLT MAY BREAK AT THE OIL FILTER ATTACHMENT POINT AND CAN CAUSE AN ENGINE OIL LEAK.

Risk: IF THERE IS AN ENGINE OIL LEAK, THE ENGINE OIL PRESSURE WOULD DROP AND THE ENGINE COULD SEIZE, INCREASING THE RISK OF A CRASH.

Fix: NISSAN WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE CONNECTOR BOLTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 30, 2012. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

SUSPENSION:FRONT:HUB

Campaign #12V462000 · Sep 20, 2012

Issue: Nissan is recalling certain model year 2012 Frontier, Pathfinder, and Xterra two-wheel drive vehicles manufactured from June 19, 2012, through July 12, 2012. These vehicles may have been equipped with front wheel hubs that may not meet the design hardness specifications. A wheel hub that was manufactured below hardness specification may wear prematurely and eventually crack.

Risk: If the vehicle is driven in this condition, the wheel hub may break, possibly resulting in a vehicle crash.

Fix: Nissan will notify owners, and dealers will replaced the left and right side front wheel hub assemblies free of charge. The safety recall began on October 22, 2012. Owners may contact Nissan Customer Service at 1-800-647-7261.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2012 Nissan Frontier.

Reported to NHTSA

Automatic transmission shifter fails to engage drive

POWER TRAIN

11 NHTSA complaints · 2015-03 → 2015-05

“VEHICLE WOULD NOT SHIFT INTO DRIVE AND STRANDED THE DRIVER. VEHICLE SHIFTER FOUND TO BE DEFECTIVE AND WAS REPLACED. THE SHIFTER CAN STOP OPERATING AT ANY TIME, LEAVING THE VEHICLE UNABLE TO DRIVE. I HAVE HAD 8 OF THESE SHIFTERS REPLACED ON 8 DIFFERENT 2012 NISSAN FRONTIERS AND”
— Owner report, NHTSA ODI #10702829
“TRANSMISSION SHIFTER WILL NOT GO INTO DRIVE, STRANDING DRIVER AND VEHICLE IN CUSTOMER'S DRIVEWAY. THIS IS A DEFECTIVE ASSEMBLY THAT HAS FAILED ON SEVERAL OTHER FRONTIERS WITH AUTOMATIC TRANSMISSIONS. VEHICLE IS DISABLED UNTIL REPAIRED. PARTS FOR THE REPAIR ARE DEALER ONLY AND”
— Owner report, NHTSA ODI #10704425
“SHIFTER FOR THE TRANSMISSION WOULD NOT GO INTO DRIVE STANDING THE DRIVER AND VEHICLE. SHIFTER ASSEMBLY IS DEFECTIVE AND VEHICLE IS SITTING AT NISSAN DEALERSHIP WAITING FOR REPAIR. NISSAN IS REFUSING TO COVER THE COST OF REPLACEMENT OUT OF WARRANTY. THIS IS THE 8TH 2012 NISSAN”
— Owner report, NHTSA ODI #10702868

Read all complaints on NHTSA →

Rear leaf spring fracture

SUSPENSION

2 NHTSA complaints · 2017-04 → 2018-12

“TL* THE CONTACT OWNS A 2012 NISSAN FRONTIER. WHILE DRIVING VARIOUS SPEEDS, A LOUD NOISE WAS PRESENT COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO NISSAN OF SALEM (33 MAIN ST, SALEM, NH) AND ALL FOUR TIRES WERE REPLACED, BUT THE NOISE GREW LOUDER. LATER, WHILE”
— Owner report, NHTSA ODI #11156483
“NOTICED CLUNKING SOUND COMING FROM REAR OF VEHICLE WHILE DRIVING. REAR END BECAME LOOSE AND JUMPY OVER SMALL BUMP SIN THE ROAD AT EVEN LOW SPEEDS. INSPECTION AT SHOP DETERMINED THAT BOTH LEAF SPRINGS WERE CRACKED (SEE ATTACHED PHOTO)”
— Owner report, NHTSA ODI #10972005

Read all complaints on NHTSA →

Frame and floorboard corrosion

STRUCTURE

2 NHTSA complaints · 2020-07 → 2025-06

“I was sold the 2012 Nissan Frontier SL from Lynne's Nissan City in Bloomfield, NJ being told it was a safe vehicle and passed their inspection. After bringing it to my mechanic I was informed the frame was so rusted it was unsafe to drive”
— Owner report, NHTSA ODI #11665563
“TL* THE CONTACT OWNS A 2012 NISSAN FRONTIER. THE CONTACT STATED THERE WAS A HOLE IN THE FLOORBOARD UNDERNEATH THE DRIVER'S SEAT CAUSED BY EXTREME CORROSION. THE VEHICLE WAS NOT TAKEN TO BE INSPECTED NOR REPAIRED”
— Owner report, NHTSA ODI #11339509

Read all complaints on NHTSA →

Airbag warning light illumination and inadvertent deployment

AIR BAGS

11 NHTSA complaints · 2012-03 → 2023-11

“TL* THE CONTACT OWNS A 2012 NISSAN FRONTIER. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, BOTH THE FRONT DRIVER AND PASSENGER SIDE CURTAIN AIR BAGS DEPLOYED INADVERTENTLY. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER FOR DIAGNOSIS HOWEVER, THE VEHICLE WAS NOT”
— Owner report, NHTSA ODI #10510496
“SIDE CURTAIN AIRBAGS WRONGFULLY DEPLOYED WHILE DRIVING AT ABOUT 5-10 MPH, WITH NO CRASH, AND ON A FLAT ROAD. CREATING AN EXTREMELY DANGEROUS SITUATION FOR MYSELF AND OTHERS ON THE ROAD AROUND ME. THIS TRUCK HAS FAULTY PROGRAMMING THAT CONTROLS THESE AIRBAGS”
— Owner report, NHTSA ODI #10896442
“PASSENGER AIR BAG WARNING LIGHT CONTINUALLY FLASHES WHEN DRIVING VEHICLE INDICATING AIR BAG WILL NOT DEPLOY. DEALERSHIP ADJUSTED SEAT BELT TENSION WHICH TEMPORARILY ( 2 WEEKS) FIXED ISSUE. DEALERSHIP NOW RECOMMENDS A NEW PASSENGER SEAT BOTTOM CUSHION TO REMEDY PROBLEM AT OWNER”
— Owner report, NHTSA ODI #10861860

Read all complaints on NHTSA →

Airbag recall repair parts unavailable

AIR BAGS

5 NHTSA complaints · 2023-03 → 2023-11

“The contact owns a 2012 Nissan Frontier. The contact received notification of NHTSA Campaign Number: 23E012000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall”
— Owner report, NHTSA ODI #11553068
“The contact owns a 2012 Nisan Frontier. The contact stated that on multiple occasions while driving under 50 MPH, the supplemental air bag safety warning light remained illuminated. The VIN search confirmed that the vehicle has one open recall at this time NHTSA Campaign Number”
— Owner report, NHTSA ODI #11514792
“The contact owns a 2012 Nissan Frontier. The contact received notification of NHTSA Campaign Number: 23E012000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the”
— Owner report, NHTSA ODI #11529756

Read all complaints on NHTSA →

Engine stalling linked to camshaft position sensor

ENGINE

5 NHTSA complaints · 2015-06 → 2021-03

“TL* THE CONTACT OWNS A 2012 NISSAN FRONTIER. THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH AN UNKNOWN WIRE NEEDING TO BE REPLACED. THE CONTACT STATED THAT THE WIRE WAS”
— Owner report, NHTSA ODI #11403039
“TL* THE CONTACT OWNS A 2012 NISSAN FRONTIER. THE CONTACT STATED THAT WHILE DRIVING UP A MOUNTAIN AT 30 MPH, THE VEHICLE STALLED WITH THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO NAPA NISSAN (510 SOSCOL AVE, NAPA, CA 94559) WHERE THE MECHANIC”
— Owner report, NHTSA ODI #11365826
“MY TRUCK HAS HAD WHAT FEELS TO ME LIKE A ROUGH IDLE FOR ABOUT AS LONG AS I'VE HAD IT. IT WAS FINE FOR SEVERAL YEARS BUT A COUPLE OF MONTHS AGO THE TRUCK DIED AT A STOP LIGHT. IT STARTED RIGHT BACK UP AND I DIDN'T THINK I'D BE ABLE TO REPLICATE THIS FOR A MECHANIC SO I JUST KEPT”
— Owner report, NHTSA ODI #11254640

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 5,000 mi

Replace synthetic-blend or full-synthetic oil every 5,000 miles under Schedule 1. Schedule 2: 7,500 miles. VR30DDTT (3.0L twin-turbo): full synthetic only.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 5,000 mi

Rotate tires every 5,000 miles. Front-wheel-drive Nissans (Altima, Sentra, Versa) wear front tires fast — don't skip rotations.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

CVT Fluid (NS-3)

Every 60,000 mi

Nissan officially calls CVT fluid 'lifetime,' but independent technicians and Nissan TSBs recommend replacement every 60,000 miles to prevent CVT failure. Use Nissan NS-3 fluid only — substitutes destroy the belt-and-pulley system.

Estimated cost — typical U.S. ranges

Dealer

~$360–$500

Shop

~$255–$355

DIY

~$80–$180

CVT fluid is manufacturer-specific and pricey — do NOT substitute conventional ATF.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake every 7,500 miles. Rogue and Pathfinder front pads typically last 35,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 2 years. Dark or amber fluid indicates moisture contamination.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace engine air filter every 30,000 miles, sooner if driving on dusty unpaved roads.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Spark Plugs

Every 105,000 mi

Iridium-tipped spark plugs are rated 105,000 miles on QR25, MR20, and VQ35 engines. VR30DDTT: 60,000 miles due to higher cylinder pressures.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Long-Life Coolant

Every 75,000 mi

Nissan Long-Life Antifreeze/Coolant (blue/green): first change at 105,000 miles, then every 75,000. Do not mix with other coolant chemistries.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Transfer Case / Rear Diff (AWD models)

Every 60,000 mi

Rogue AWD, Murano AWD, Pathfinder 4WD: replace transfer case fluid and rear differential fluid every 60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 15,000 mi

Replace cabin air filter every 15,000 miles. Located behind the glove box on Altima, Rogue, and Sentra.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

34 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

4

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2012 Nissan Frontier reflects Nissan's published service intervals and the Maintenance Reminder system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →