Wrench.Pro

2012 Nissan Pathfinder Recalls, Issues & Maintenance

The 2012 Nissan Pathfinder carries 2 open NHTSA recalls — most recently covering engine and engine cooling and hub. Owners report 3 recurring issue clusters, led by “Rear subframe corrosion and control arm failure.” Nissan owner's manuals split service into Schedule 1 (severe) and Schedule 2 (normal). Most US drivers fall under Schedule 1. The biggest preventable failure on Nissan vehicles is CVT transmission damage from extended fluid intervals — owners of Altima, Rogue, Sentra, Pathfinder, and Murano with CVT should not skip it.

2 Open Recalls

Source: NHTSA

ENGINE AND ENGINE COOLING

Campaign #11V592000 · Dec 19, 2011

Issue: NISSAN IS RECALLING CERTAIN MODEL YEAR 2011 INFINITI FX, MODEL YEAR 2012 INFINITI M, MODEL YEAR 2011-2012 NISSAN FRONTIER, MODEL YEAR 2011-2012 NISSAN XTERRA, MODEL YEAR 2011-2012 NISSAN PATHFINDER, AND MODEL YEAR 2012 NISSAN NV VEHICLES. SOME OF THE BOLTS THAT CONNECT THE ENGINE OIL COOLER AND THE ENGINE OIL FILTER TO THE ENGINE IN THESE VEHICLES MAY HAVE BEEN MANUFACTURED TO BELOW SPECIFICATION STRENGTH. AS A RESULT, THE BOLT MAY BREAK AT THE OIL FILTER ATTACHMENT POINT AND CAN CAUSE AN ENGINE OIL LEAK.

Risk: IF THERE IS AN ENGINE OIL LEAK, THE ENGINE OIL PRESSURE WOULD DROP AND THE ENGINE COULD SEIZE, INCREASING THE RISK OF A CRASH.

Fix: NISSAN WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE CONNECTOR BOLTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 30, 2012. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

SUSPENSION:FRONT:HUB

Campaign #12V462000 · Sep 20, 2012

Issue: Nissan is recalling certain model year 2012 Frontier, Pathfinder, and Xterra two-wheel drive vehicles manufactured from June 19, 2012, through July 12, 2012. These vehicles may have been equipped with front wheel hubs that may not meet the design hardness specifications. A wheel hub that was manufactured below hardness specification may wear prematurely and eventually crack.

Risk: If the vehicle is driven in this condition, the wheel hub may break, possibly resulting in a vehicle crash.

Fix: Nissan will notify owners, and dealers will replaced the left and right side front wheel hub assemblies free of charge. The safety recall began on October 22, 2012. Owners may contact Nissan Customer Service at 1-800-647-7261.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2012 Nissan Pathfinder.

Reported to NHTSA

Rear subframe corrosion and control arm failure

SUSPENSION

5 NHTSA complaints · 2023-04 → 2025-11

“Right lower control arm snapped while driving at highway speed (65MPH) causing vehicle into a 360 spin. Vehicle spun, was hard to control and tire blew out at speed. Others behind me or in front may have gotten involved if traffic was heavier at the time”
— Owner report, NHTSA ODI #11700670
“The contact owns a 2012 Nissan Pathfinder. The contact stated that while the vehicle was parked, he noticed that the rear tires were abnormally damaged. The contact stated that upon further inspection, he noticed that the subframe was severely corroded and fractured”
— Owner report, NHTSA ODI #11582196
“Rear lower control arm broke while driving. Vehicle had to be moved on a rollback. Upon replacing control arm, cracks have been found at several points on the crossmember subframe. As it stands, the vehicle is a danger to have on the road”
— Owner report, NHTSA ODI #11574413

Read all complaints on NHTSA →

Engine stall and loss of power while driving

ENGINE

4 NHTSA complaints · 2019-04 → 2022-05

“WHILE VEHICLE IS IN MOTION, THE ENGINE WILL ALL OF A SUDDEN SEIZE. THIS HAS HAPPENED 5 TIMES, 2 TIMES ON THE FREEWAY AT 55 - 65 MPH, SEIZED IN MOTION, STEPPED ALL THE WAY DOWN ON GAS AFTER ENGINE SEIZED, ENGINE REVS, HARDLY ANY POWER, ALMOST DOWN TO 10 MPH IN LESS THAN 10”
— Owner report, NHTSA ODI #11096647
“We purchased the truck in 2018. Starting last year the truck starting losing power, not cutting on. Replaced the battery and have had 5 mechanics check it. Not one mechanic has been able to find the issue. Today my truck cut off in a tunnel with my children in the car”
— Owner report, NHTSA ODI #11421203
“WHEN DRIVING AT ANY TIME, MORNING, AFTERNOON.... CHECK ENGINE LIGHT WILL GO ON AND WITHIN SECONDS, MINUTES..., ENGINE WILL REV, SEIZE AND WHEN PRESSING GAS, ENGINE WILL REV BUT BARELY ANY PROPULSION. IF DRIVING AT 60MPH, ENGINE WILL SEIZE AND SPEED WILL DROP IMMEDIATELY”
— Owner report, NHTSA ODI #11195861

Read all complaints on NHTSA →

Airbag non-deployment and recall repair failure

AIR BAGS

3 NHTSA complaints · 2015-09 → 2016-02

“I WAS IN A 40MPH CAR ACCIDENOT AND MY FRONT AIRBAGS DID NOT DEPLOY”
— Owner report, NHTSA ODI #10838927
“TL* THE CONTACT OWNS A 2012 NISSAN PATHFINDER. THE CONTACT STATED WHILE DRIVING AT 75 MPH, A DEER JUMPED INTO THE ROAD CAUSING THE CONTACT TO CRASH INTO IT. THE AIR BAGS FAILED TO DEPLOY. THERE WAS NO INJURIES SUSTAINED AND THERE WAS A POLICE REPORT FILED”
— Owner report, NHTSA ODI #10825803
“I RECEIVED THE RECALL LETTER, TOOK MY CAR IN, THEY SAID IT WAS DONE, IT WAS NOT DONE CORRECTLY, I TOOK IT BACK WAS TOLD IT WAS A CLIP NOT CLIPPED CORRECTLY,. THE AIRBAG LIGHT STARTED FLASHING AGAIN. I CALLED AND TOLD THE RECALL WAS EXPIRED AND I WOULD HAVE TO PAY”
— Owner report, NHTSA ODI #10778272

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 5,000 mi

Replace synthetic-blend or full-synthetic oil every 5,000 miles under Schedule 1. Schedule 2: 7,500 miles. VR30DDTT (3.0L twin-turbo): full synthetic only.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 5,000 mi

Rotate tires every 5,000 miles. Front-wheel-drive Nissans (Altima, Sentra, Versa) wear front tires fast — don't skip rotations.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

CVT Fluid (NS-3)

Every 60,000 mi

Nissan officially calls CVT fluid 'lifetime,' but independent technicians and Nissan TSBs recommend replacement every 60,000 miles to prevent CVT failure. Use Nissan NS-3 fluid only — substitutes destroy the belt-and-pulley system.

Estimated cost — typical U.S. ranges

Dealer

~$360–$500

Shop

~$255–$355

DIY

~$80–$180

CVT fluid is manufacturer-specific and pricey — do NOT substitute conventional ATF.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake every 7,500 miles. Rogue and Pathfinder front pads typically last 35,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 2 years. Dark or amber fluid indicates moisture contamination.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace engine air filter every 30,000 miles, sooner if driving on dusty unpaved roads.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Spark Plugs

Every 105,000 mi

Iridium-tipped spark plugs are rated 105,000 miles on QR25, MR20, and VQ35 engines. VR30DDTT: 60,000 miles due to higher cylinder pressures.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Long-Life Coolant

Every 75,000 mi

Nissan Long-Life Antifreeze/Coolant (blue/green): first change at 105,000 miles, then every 75,000. Do not mix with other coolant chemistries.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Transfer Case / Rear Diff (AWD models)

Every 60,000 mi

Rogue AWD, Murano AWD, Pathfinder 4WD: replace transfer case fluid and rear differential fluid every 60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 15,000 mi

Replace cabin air filter every 15,000 miles. Located behind the glove box on Altima, Rogue, and Sentra.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

16 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

2

complaints mentioning a crash

1

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2012 Nissan Pathfinder reflects Nissan's published service intervals and the Maintenance Reminder system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →