The 2013 Ford Flex carries 6 open NHTSA recalls — most recently covering fuel pump and fuel system, gasoline. Owners report 5 recurring issue clusters, led by “Rear-view camera failure.” Ford uses the Intelligent Oil-Life Monitor (IOLM) to determine when oil changes are due based on actual driving load — not just mileage. Ford's published cap is 10,000 miles or 1 year, whichever comes first. The schedule below reflects Ford's Normal service intervals; F-Series trucks and Super Duty have additional towing-specific items.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Campaign #16V621000 · Aug 25, 2016
Issue: Ford Motor Company (Ford) is recalling certain model year 2013-2015 Ford Taurus, Ford Flex, Lincoln MKS and Lincoln MKT vehicles equipped with 3.5L GTDI Ecoboost engines and 2013-2015 Ford Taurus Police Interceptor vehicles. A component within the fuel pump electric module (PEM) may overheat causing a loss of electrical power to the fuel pump.
Risk: A loss of power to the fuel pump will cause the engine to stall or prevent the vehicle from starting, increasing the risk of a crash.
Fix: Ford will notify owners, and dealers will inspect the fuel PEM part number and replace the fuel PEM, as necessary, free of charge. The recall began on December 1, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S31.
FUEL SYSTEM, GASOLINE
Campaign #15V812000 · Feb 12, 2015
Issue: Ford Motor Company (Ford) is recalling certain model year 2013 Explorer, Explorer Police Utility, Taurus, Taurus Police Interceptor, Flex, Lincoln MKS, and Lincoln MKT vehicles. In the affected vehicles, the fuel delivery module may crack, allowing fuel to leak.
Risk: A fuel leak in the presence of an ignition source may result in a fire.
Fix: Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on December 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 13S04-S1.
STEERING:ELECTRIC POWER ASSIST SYSTEM
Campaign #15V340000 · Feb 6, 2015
Issue: Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.
Risk: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.
Fix: Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S18.
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
Campaign #14V393000 · Feb 7, 2014
Issue: Ford Motor Company (Ford) is recalling certain model year 2012-2014 Ford Edge and Lincoln MKX vehicles manufactured September 2, 2010, to November 30, 2013; 2013-2014 Ford Taurus and Lincoln MKS vehicles manufactured August 25, 2011, to November 30, 2013; and 2013-2014 Ford Flex and Lincoln MKT vehicles manufactured September 12, 2011, to November 30, 2013. In the affected vehicles, the halfshaft retention circlip may not have been properly installed, and as a result, the halfshaft may move outward and disengage from the linkshaft while driving and without prior warning.
Risk: If the halfshaft and linkshaft become disengaged while driving, power will no longer be transmitted to the wheels, increasing the risk of a vehicle crash. Additionally, if the parking brake is not applied before exiting the vehicle, the vehicle may roll away despite the transmission being placed in 'Park', increasing the risk of injury to exiting occupants and bystanders.
Fix: Ford will notify owners, and dealers will inspect the vehicles to make sure that the halfshaft is properly retained. If it is not, dealers will replace the linkshaft and also replace the halfshaft if it shows evidence of spline damage, free of charge. The recall began on August 4, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S10.
FUEL SYSTEM, GASOLINE
Campaign #13V227000 · May 31, 2013
Issue: Ford is recalling certain model year 2013 Explorer, Taurus, Flex, Fusion, Police Interceptor Sedan and Police Interceptor Utility vehicles; and certain model year 2013 Lincoln MKS, MKT, and MKZ vehicles. In the affected vehicles, the fuel delivery module may develop a crack, allowing fuel to leak.
Risk: A fuel leak in the presence of an ignition source may result in a fire.
Fix: Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on July 20, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332. Ford's recall campaign number is 13S04.
SUSPENSION:REAR
Campaign #20V072000 · Oct 2, 2020
Issue: Ford Motor Company (Ford) is recalling certain 2013-2018 Lincoln MKT and Ford Flex and Taurus vehicles with the Police Interceptor or SHO Performance Pack. The rear suspension toe links may fracture due to stress on the rear suspension.
Risk: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Fix: Ford will notify owners, and dealers will replace the rear suspension toe links, free of charge. Remedy parts are not currently available. Owners were notified about the recall on March 3, 2020. A second notice will be mailed when remedy parts become available, which is currently expected to be the end of September 2020. The recall began October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332 or Lincoln customer service at 1-800-521-4140. Ford's number for this recall is 20S04.
What drivers and federal regulators have officially reported about the 2013 Ford Flex.
BACK OVER PREVENTION
13 NHTSA complaints · 2021-05 → 2026-02
“Rear view camera has failed. The screen goes black and has a “contact dealer” message”
“THE REAR- VIEW BACK UP CAMERA DOES NOT OPERATE PROPERLY WHEN VEHICLE IS PUT IN REVERSE. IT WORKS INTEMITTEDLY. SOMETIMES IMAGE IS BLACK, SOMETIMES UPSIDE DOWN, SOMETIME, WORKS PROPERLY, SOMETIME IMAGE FREEZES, AND SOMETIMES SHOWS ERROR CAMERA NOT WORKING CONTACT DEALERSHIP”
LATCHES/LOCKS/LINKAGES
12 NHTSA complaints · 2020-02 → 2025-09
“Repeated problems with door latch system in 2013 Ford Flex. Door is interpreted as being ajar, despite being closed. Two warning lights/messages to this effect persist, interior lights will not turn off (which drains the battery), doors will not automatically lock while driving”
“TL* THE CONTACT OWNS A 2013 FORD FLEX. THE CONTACT STATED THAT THE FRONT PASSENGER'S SIDE DOOR LATCH FAILED TO LOCK THE DOOR SECURELY. THE CONTACT STATED THAT WHILE DRIVING THE FRONT PASSENGER SIDE DOOR UNLOCKED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO SALERNO DUANE FORD LOCATED”
STEERING
85 NHTSA complaints · 2019-06 → 2026-04
“The contact owns a 2013 Ford Flex. The contact stated that while driving at an undisclosed speed, the steering wheel seized, with the power steering fault warning light illuminated. The vehicle was restarted; however, the failure reoccurred, and the steering wheel became”
“The contact owns a 2013 Ford Flex. The contact stated that when the vehicle was started, the message “Power Steering Failure” was displayed on the instrument panel. The vehicle was not diagnosed or repaired. The contact also stated that a handheld diagnostic reader retrieved”
SUSPENSION
8 NHTSA complaints · 2019-12 → 2026-03
“WHILE DRIVING IN SNOW/ICE CONDITIONS ON CITY STREETS IN BIG BEAR CA, ICE BUILT UP IN THE RIGHT REAR TOE LINK CHASSIS POCKET CAUSING THE TOE LINK TO FLEX AND EVENTUALLY BREAK LEAVING US STRANDED IN BIG BEAR... THIS PART IS PART OF A RECALL IN THE CANADIAN PROVINCE S BASED ON THE”
“TL* THE CONTACT OWNS A 2013 FORD FLEX. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 67 MPH, A LOUD POPPING NOISE OCCURRED AND DRIVER SUDDENLY LOST CONTROL OF THE STEERING CAUSING THE VEHICLE TO VIOLENTLY SWERVE WHILE ON THE HIGHWAY. AFTER STOPPING THE VEHICLE THE DRIVER”
FUEL/PROPULSION SYSTEM
4 NHTSA complaints · 2019-06 → 2020-02
“THIRD TIME HAVING THE FUEL PUMP REPLACED . PUMP FAILS EVERY 20-30K MILES. CAR WILL STOP RUNNING WHILE DRIVING ON ROADWAYS, UNABLE TO RESTART VEHICLE. HAD TO PULL OVER TO SIDE OF ROAD AND WAIT FOR TOW. 1ST TIME 36,000 MILES 2ND 53,000, 3RD 90,000. ALL REPAIRS WERE PERFORMED BY”
“FUEL PUMP FAILURE AT 90,000 MILES. EXACT ISSUE WAS RECALLED ON SOME MODELS IN THE SAME YEAR, JUST NOT MY VIN. PUMP IS IN HIGH DEMAND, PRICES ARE THUS HIGHER THAN USUAL AND ALSO UNAVAILABLE THRU ANYONE BUT FORD DIRECTLY. MY CAR WAS, THANKFULLY, IN THE DRIVEWAY WHEN FAILURE”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Replace synthetic-blend or full-synthetic Motorcraft oil per the IOLM, or every 7,500-10,000 miles. EcoBoost engines require full synthetic; Coyote 5.0L V8 specifies SAE 5W-30.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 10,000 miles, or with every other oil change. F-150 4x4 owners should rotate every 5,000-7,500 miles to even out drivetrain bias wear.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect brake pads, rotors, and brake fluid level every 10,000 miles. Front pads on F-150 and Explorer typically last 40,000-60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Ford specifies brake fluid replacement on an inspection basis, but moisture testing every 3 years is recommended. Replace if reading exceeds 3% water content.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Replace the engine air filter every 30,000 miles. EcoBoost turbocharged engines are sensitive to airflow restriction — don't extend.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Ford 6R80, 10R80, and 8F transmissions use Mercon LV fluid rated 150,000 miles under normal service. Severe service (towing, plowing) drops this to 60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
F-150 4x4 and Bronco 4x4: replace transfer case fluid every 60,000 miles. Use Motorcraft XL-12 — do not substitute generic transfer case fluid.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
F-Series and Expedition: replace rear axle fluid every 100,000 miles, or 50,000 miles if towing. Limited-slip rear ends require friction-modifier additive.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Iridium spark plugs on Coyote 5.0L, EcoBoost 2.7L/3.5L, and 2.3L are rated 100,000 miles. EcoBoost engines: never exceed the interval — gap erosion causes coil failure.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Motorcraft Orange (Dex-Cool compatible) coolant: first change at 100,000 miles, then every 50,000. Older trucks with Yellow Motorcraft coolant: 50,000 miles throughout.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Extends the life of your vehicle and improves comfort
Replace the cabin air filter every 20,000 miles. On F-150, located behind the glove box; on Escape and Explorer, accessed from the passenger footwell.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Occupant deaths in fatal crashes (FARS)
11 crashes 2010–2024
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
11
complaints mentioning a crash
1
complaints mentioning a fire
Reviewed known issues for this vehicle·Open recalls for this vehicle
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2013 Ford Flex reflects Ford's published service intervals and the Intelligent Oil-Life Monitor system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.