Wrench.Pro

2013 Gmc Sierra 3500 Recalls, Issues & Maintenance

The 2013 Gmc Sierra 3500 carries 4 open NHTSA recalls — most recently covering equipment and auxillary tank. Owners report 6 recurring issue clusters, led by “Transmission control module and shifting failures.” GMC trucks and SUVs use the GM Oil Life System (OLS) — the same algorithm as Chevrolet. Because GMC's lineup is exclusively trucks and SUVs, severe-service intervals apply to most owners (towing, hauling, off-roading). The schedule below surfaces the items most relevant to GMC's truck-focused buyer.

4 Open Recalls

Source: NHTSA

EQUIPMENT

Campaign #18V267000 · Apr 26, 2018

Issue: General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Risk: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Fix: GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.

FUEL SYSTEM, GASOLINE:STORAGE:AUXILLARY TANK

Campaign #17V664000 · Oct 19, 2017

Issue: General Motors LLC (GM) is recalling certain 2011-2015 Chevrolet Silverado 3500 and GMC Sierra 3500 trucks equipped with dual fuel tanks. The low fuel level sensor for the front tank may stick causing the rear tank to overfill the front tank.

Risk: If the front tank overfills, the excess pressure may cause the front tank to expand and contact the driveshaft, possibly resulting in a hole in the tank. The hole will leak fuel, which in the presence of an ignition source, can increase the risk of a fire.

Fix: GM has notified owners, and dealers will replace the rear tank fuel pump or update the fuel-level sensor software, as well as inspect the front tank, replacing it as necessary, free of charge. The recall began December 11, 2017. Owners may contact GM customer service for Chevrolet 1-800-222-1020 or for GMC customer service at 1-800-462-8782. GM's number for this recall is 17399.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Campaign #21V054000 · May 2, 2021

Issue: General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Fix: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Campaign #21V053000 · May 2, 2021

Issue: General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Fix: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2013 Gmc Sierra 3500.

1 active NHTSA investigation

Source: NHTSA

  • Desiccated Air Bag Inflator Rupture

    Action #EA21002 · opened Sep 17, 2021

    From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 200…

    View on NHTSA →

Reported to NHTSA

Transmission control module and shifting failures

POWER TRAIN

6 NHTSA complaints · 2013-10 → 2023-06

“There are over 9,000 GM trucks that are sitting idle because GM quit making this part, There are no after market replacements nationwide. When this part fails it shifts the transmission into 2-3 rd gear and goes into limp mode which if you are doing 70 on the interstate you are”
— Owner report, NHTSA ODI #11525589
“I was driving down the highway at 75 MPH when the Transmission Control Module overheat and put my truck into third gear causing the truck to speed unsafe”
— Owner report, NHTSA ODI #11445054
“MY TRANSMISSION SLIPS BETWEEN 2ND AND 3RD GEAR AT LEAST 4 TIMES A MONTH. THE DEALER TOLD ME THAT IF I CANT PROVE IT OR IF IT DOESN'T DO IT WHEN THEY DRIVE IT THEN THEY CANT PERFORM A DIAGNOSTIC TEST TO FIX THE PROBLEM”
— Owner report, NHTSA ODI #10573132

Read all complaints on NHTSA →

Takata air bag recall parts delays and dashboard cracking

AIR BAGS

9 NHTSA complaints · 2016-01 → 2023-09

“The contact received notification of NHTSA Campaign Number: 21V054000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair”
— Owner report, NHTSA ODI #11453445
“I PICKED UP MY TRUCK TODAY AND WAS TOLD THAT THEY FOUND A CRACK IN THE DASH LOCATED BEHIND THE INSTRUMENT CLUSTER. ONLY 6K MILES OUT OF WARRANTY. HOW CONVENIENT FOR GM”
— Owner report, NHTSA ODI #10851520
“The passenger side airbag recall involves the removal of the dashboard and the dealer advised the dashboard may break during this process and I am responsible for the cost to install a new one. Their estimate was $1500.00”
— Owner report, NHTSA ODI #11544454

Read all complaints on NHTSA →

Air bags failing to deploy in a crash

AIR BAGS

5 NHTSA complaints · 2014-01 → 2014-07

“THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH AND BECAME INVOLVED IN A SIX VEHICLE CRASH. THE CONTACT'S AIR BAGS FAILED TO DEPLOY ON IMPACT. THERE WERE NO INJURIES”
— Owner report, NHTSA ODI #10561304
“WHILE DRIVING IN THE MOUNTAINS, I SWERVED TO MISS AN ANIMAL, TOOK THE DITCH, HIT TWO TREES, SOME BOULDERS AND THE AIRBAGS DID NOT DEPLOY. I WAS TRAVELING AT ABOUT 47 MPH”
— Owner report, NHTSA ODI #10574287
“THE DPS OFFICER TOLD MY HUSBAND HE HIT A CULVERT AND FLIPPED 5- 6 TIMES. WITNESSES HAD TO PULL HIM OUT OF THE TRUCK AND HAD MENTIONED THERE WAS A SLIGHT FIRE THAT THEY PUT OUT. DURING ALL OF THIS NONE OF THE AIRBAGS DEPLOYED”
— Owner report, NHTSA ODI #10588319

Read all complaints on NHTSA →

Power steering leaks and intermittent lock-up

STEERING

6 NHTSA complaints · 2014-04 → 2019-02

“I OWN A 2013 GMC SIERRAHD 2500 AND I AM EXPERIENCING POWER STEERING FAILURES. GMC IS REFUSING TO FIX THE PROBLEM BECAUSE THEY CANT FIND IT”
— Owner report, NHTSA ODI #10652681
“I TOOK MY TRUCK IN FOR A GRINDING NOISE THE STEERING RACK WAS MAKING WHEN TURNING AT LOW SPEEDS, THE DEALERSHIP SAID IT WAS A POWER STEERING GEAR, COMMON PROBLEM AND THEY WOULD FIX IT BECAUSE IT WAS UNDER WARRANTY, THEY SOLVED THE PROBLEM”
— Owner report, NHTSA ODI #10577560
“AT LOW SPEED THE POWER STEERING LOCKS UP AND IS EXTREMELY DIFFICULT TO OPERATE WHEN TURNING EITHER DIRECTION”
— Owner report, NHTSA ODI #11175747

Read all complaints on NHTSA →

Engine stalling and loss of power while driving

ENGINE

4 NHTSA complaints · 2014-04 → 2023-10

“The contact stated that on several occasions while driving at various speeds, the vehicle lost power. The check engine warning light was illuminated. The vehicle veered to the side of the road and was restarted”
— Owner report, NHTSA ODI #11549542
“THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 58 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT WAITED FIVE MINUTES BEFORE RESTARTING THE VEHICLE AND RESUMED NORMALLY. THE FAILURE RECURRED FOUR TIMES”
— Owner report, NHTSA ODI #10585259
“While driving carrying a full load in the back of the truck, the engine began to lose power, started running rough and then died without any warning within a matter of seconds. No indicator light or warnings were displayed”
— Owner report, NHTSA ODI #11418356

Read all complaints on NHTSA →

Brake failure to stop and vibration when braking

SERVICE BRAKES

4 NHTSA complaints · 2013-11 → 2025-09

“I HAVE HAD TWO INCIDENTS WITH THE BRAKES WHERE THE VEHICLE FAILED TO STOP WITH THE BRAKES FULLY APPLIED. THE FIRST TIME WAS WHEN THE VEHICLE HAD APPROXIMATELY 15000 MILES ON IT”
— Owner report, NHTSA ODI #10667944
“The contact stated that while driving at 50 MPH, the ABS independently engaged. A dealer was contacted”
— Owner report, NHTSA ODI #11690612
“SEVERE STEERING WHEEL VIBRATION WHEN BRAKING AT 40 PLUS MPH”
— Owner report, NHTSA ODI #10572546

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 17, 2026. Investigation data refreshed Sep 17, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when OLS reaches 0% or every 12 months. dexos1-approved synthetic required on Sierra 1500 5.3L/6.2L; dexos2 specified on Duramax diesel.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Sierra and Yukon owners running 4x4 should rotate every 5,000-7,500 miles to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors, and parking brake every 7,500 miles. Towing accelerates pad wear by 30-50%; check more often if towing regularly.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

DOT 3 brake fluid: test annually, replace when moisture exceeds 3% or fluid is darker than copper.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

Long-life cellulose filter rated 45,000 miles. Trucks driven on unpaved roads or construction sites should inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (towing 5,000+ lbs regularly, heavy stop-and-go): every 45,000 miles. Normal: 97,500 miles. Use Dexron-VI for 6L80/6L90, Mobil 1 LV ATF HP for 10L80/10L1000.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Sierra and Yukon 4WD: replace every 45,000 miles. Use GM Auto-Trak II for active 4WD; GM 9986115 for selectable 4WD.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Differential Fluid (front + rear)

Every 50,000 mi

Replace front and rear axle fluid every 50,000 miles, or 25,000 miles if towing. G80 limited-slip rear axles require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs

Every 100,000 mi

Iridium spark plugs on the L83/L84 5.3L and L86/L87 6.2L V8 are rated 100,000 miles. AFM/DFM cylinder deactivation can cause uneven plug wear — check at 75,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000. Duramax diesel uses ELC (red) — different chemistry, do not mix.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace cabin air filter every 22,500 miles. Sierra HD and Yukon XL owners in dusty work environments should replace at 15,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

92 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

5

complaints mentioning a crash

1

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2013 Gmc Sierra 3500 reflects GMC's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →