Wrench.Pro

2014 Bmw 328i Recalls, Issues & Maintenance

The 2014 Bmw 328i carries 8 open NHTSA recalls — most recently covering hoses, lines/piping, and fittings and exterior lighting. Owners report 7 recurring issue clusters, led by “Interior door handle fails to unlock door.” BMW vehicles use Condition-Based Service (CBS) — the dashboard shows each service item with its own remaining mileage and time, calculated by sensors. The schedule below shows BMW's underlying targets. BMW Ultimate Care covers the first 3 years / 36,000 miles of factory-scheduled maintenance on most new vehicles.

8 Open Recalls

Source: NHTSA

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS

Campaign #14V627000 · Jul 10, 2014

Issue: BMW of North America LLC (BMW) is recalling certain model year 2014 BMW 328i xDrive Sports Wagon, 2012-2014 BMW 320i Sedan, 328i Sedan, 320i xDrive Sedan, 328i xDrive Sedan, 2012-2013 BMW 528i Sedan, 528i xDrive Sedan, 2013-2014 BMW X1 sDrive28i, X1 xDrive28i Sports Activity Vehicle, 2013-2014 BMW X3 xDrive28i Sports Activity Vehicle, 2012-2014 BMW Z4 sDrive28i Roadster, and 2014 BMW 428i Coupe, and 428i xDrive Coupe. Due to insufficient lubrication, the vacuum pump that supplies brake power assistance may fail. Note: This recall is an expansion of recall 13V-454.

Risk: A failure of the brake vacuum pump results in a reduction in braking power that could increase the risk of a crash.

Fix: BMW will notify owners, and dealers will install a locking ring in the camshaft to retain the camshaft seal disk in the proper location, free of charge. The recall began on December 2, 2014. Owners may contact BMW customer service at 1-800-525-7417.

EXTERIOR LIGHTING

Campaign #15V520000 · Aug 17, 2015

Issue: BMW North America, LLC (BMW) is recalling certain model year 2012-2015 320i, 320xi, 328i, 328xi, 335i, 335xi, and ActiveHybrid3 vehicles manufactured October 20, 2011, to June 22, 2015, 2014-2015 328xi Sports Wagon vehicles manufactured March 21, 2013, to March 17, 2015, 2014-2015 328d, 328xd vehicles manufactured June 28, 2013, to April 21, 2015, and 2014-2015 328xd Sports Wagon vehicles manufactured July 5, 2013, to April 21, 2015. The affected vehicles may have been programmed with new software that inadvertently makes the front side marker lights inoperative in conjunction with the parking lights or the headlights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: If the side marker lights do not illuminate, the vehicle may be less visible at night, increasing the risk of a crash.

Fix: BMW will notify owners, and dealers will upload revised software to correct the issue, free of charge. The recall began on October 7, 2015. Owners may contact BMW customer service at 1-800-525-7417 or by email at CustomerRelations@bmwusa.com.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Campaign #15V189000 · Mar 31, 2015

Issue: BMW of North America LLC (BMW) is recalling certain model year 2014 228i Coupe, M235i Coupe, 320i, 320xi, 328i, 328xi, 335i, 335xi, ActiveHybrid 3, 328xi Sports Wagon, 428i Coupe, 428xi Coupe, 435i Coupe, 435xi Coupe, 428i Convertible, 428xi Convertible, 435i Convertible, 328xi Gran Turismo, 335xi Gran Turismo, and 2015 428i Gran Coupe, 428xi Gran Coupe, and 435i Gran Coupe vehicles. Improper nickel plating of components within the fuel pump may result in the fuel pump failing.

Risk: If the fuel pump fails, the vehicle may stall without warning, increasing the risk of a crash.

Fix: BMW will notify owners, and dealers will replace the fuel pump, free of charge. Owners were mailed interim notices on May 28, 2015. The recall began on July 6, 2015. Owners may contact BMW customer service at 1-800-525-7417.

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM

Campaign #13V454000 · Sep 26, 2013

Issue: BMW of North America LLC (BMW) is recalling certain model year 2012-2014 320i, 328i, 320i xDrive, and 328i xDrive sedans; model year 2014 328i xDrive Sports Wagons; model year 2012-2013 528i and 528i xDrive sedans, model year 2013-2014 X1 sDrive28i and X1 xDrive28i vehicles and model year 2012-2014 Z4 sDrive28i roadsters. Due to insufficient lubrication, the vacuum pump that supplies brake power assistance may fail.

Risk: A failure of the brake vacuum pump results in a reduction in braking power that could increase the risk of a crash.

Fix: BMW will notify owners, and dealers will modify the vehicles to prevent insufficient vacuum pump lubrication, free of charge. The safety recall began on January 31, 2014. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.

AIR BAGS:SIDE/WINDOW

Campaign #24V288000 · Apr 24, 2024

Issue: BMW of North America, LLC (BMW) is recalling certain 2014-2015 2 Series Coupe (228i, 228i xDrive, M235i), 3 Series Sedan (320i, 320i xDrive, 328i, 328i xDrive, 335i, 335i xDrive, M3, 328d, 328d xDrive), 4 Series Coupe (428i, 428i xDrive, 435i, 435i xDrive, M4), and 2015 4 Series Gran Coupe (428i, 428i xDrive, 435i, 435i xDrive) vehicles. The head air bag inflator may fail at the weld joint, which can cause gas to leak from the inflator or result in an inflator rupture.

Risk: An inflator that ruptures may cause sharp metal fragments to enter or exit the vehicle, increasing the risk of injury. Additionally, an inflator that leaks gas may only partially inflate during a crash, increasing the risk of injury.

Fix: Dealers will replace the head air bags, free of charge. Owner notification letters were mailed November 4, 2024. Owners may contact BMW customer service at 1-800-525-7417.

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Campaign #24V527000 · Nov 7, 2024

Issue: BMW of North America, LLC (BMW) is recalling certain 2015 6 Series Gran Coupe, 2014 5 Series Gran Turismo, 2014 5 Series Sedan, 2015 6 Series Convertible, 2015 6 Series Coupe, 2014 X5, 2013-2014 X3, 2014-2015 3 Series Sedan, 2014 4 Series Coupe, 2014 4 Series Convertible, 2014 3 Series Gran Turismo, and 2015 4 Series Gran Coupe vehicles. Please see the recall report for the complete list of models. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, increasing the risk of injury or death.

Fix: The driver's front air bag will be replaced, free of charge. Owner notification letters were mailed September 6, 2024. Owners may contact BMW customer service at 1-800-525-7417.

ENGINE AND ENGINE COOLING:COOLING SYSTEM:PUMP

Campaign #24V608000 · Aug 13, 2024

Issue: BMW of North America, LLC. (BMW) is recalling certain 2012-2015 X1 sDrive28i, X1 xDrive28i, 2012-2016 Z4 sDrive28i, 528i, 528i xDrive, 328i, 328xi, 2016-2018 X5 xdrive 40e, 2014-2016 228i, 228xi, 428i, 428i xDrive, 328xi Gran Turismo, 2013-2017 X3 sDrive28i, X3 xDrive28i, 2015-2018 X4 xDrive28i, 2015-2016 428xi vehicles. An improperly sealed electrical connector on the water pump may be exposed to water and short circuit.

Risk: An electrical short increases the risk of a fire.

Fix: Dealers will inspect and replace the water pump and plug connector as necessary, and install a protective shield, free of charge. Owner notification letters were mailed on March 28, 2025. Owners may contact BMW customer service at 1-800-525-7417.

AIR BAGS:SIDE/WINDOW:HEAD

Campaign #25V871000 · Dec 17, 2025

Issue: BMW of North America, LLC (BMW) is recalling certain 2014 4 Series Coupe (428i, 428i xDrive, 435i, 435i xDrive), 3 Series Sedan (320i, 320i xDrive, 328i, 328i xDrive, 335i, 335i xDrive), and 2014-2015 2 Series Coupe (228i, 228i xDrive, M235i, M235i xDrive) vehicles. The head air bag inflator may fail at the weld joint, which can cause gas to leak from the inflator or result in an inflator rupture.

Risk: An inflator that ruptures may cause sharp metal fragments to enter or exit the vehicle, increasing the risk of injury. Additionally, an inflator that leaks gas may only partially inflate during a crash, increasing the risk of injury.

Fix: Dealers will replace the head air bags, free of charge. Owner notification letters were mailed February 12, 2026. Owners may contact BMW customer service at 1-800-525-7417.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2014 Bmw 328i.

1 active NHTSA investigation

Source: NHTSA

  • Desiccated Air Bag Inflator Rupture

    Action #EA21002 · opened Sep 17, 2021

    From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 200…

    View on NHTSA →

Reported to NHTSA

Interior door handle fails to unlock door

STRUCTURE

6 NHTSA complaints · 2017-06 → 2023-10

“THE DRIVER SIDE DOOR DOES NOT RELIABLY (I.E. <50% OF THE TIME) OPEN FROM THE INSIDE USING THE DOOR HANDLE WHEN THE VEHICLE IS STATIONARY. INSTEAD I HAVE TO PRESS THE CENTRAL UNLOCK BUTTON ON THE DASHBOARD”
— Owner report, NHTSA ODI #11170288
“IF DOORS ARE LOCKED. SPORADICALLY IT IS NOT POSSIBLE TO UNLOCK AND OPEN THE DRIVER OR PASSENGER'S FRONT DOOR FROM THE INSIDE USING DOOR HANDLE. IT IS POSSIBLE TO OPEN DOORS IF UNLOCKED WITH "DOOR UNLOCK"”
— Owner report, NHTSA ODI #11080289
“INABILITY TO OPEN THE DRIVER DOOR TO EXIT THE VEHICLE AFTER THE VEHICLE IS STOPPED. I WAS INFORMED THAT IT MAY REPRESENT A FAILURE OF THE DOOR ACTUATOR. TO BE UNABLE TO EXIT THE VEHICLE IN THE EVENT OF AN EMERGENCY IS UNACCEPTABLE”
— Owner report, NHTSA ODI #11066859

Read all complaints on NHTSA →

Engine coolant pump failure and overheating

ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM

42 NHTSA complaints · 2024-09 → 2026-07

“The contact owned a 2014 BMW 328I. The contact stated while the vehicle was parked, the vehicle stalled after overheating the previous day. The contact stated that an unknown warning light was illuminated”
— Owner report, NHTSA ODI #11753873
“The contact owned a 2014 BMW 328i. The contact stated that while at a complete stop at the red traffic light, the contact noticed smoke coming from underneath the hood. There was no warning light illuminated. The contact pulled to the side of the road”
— Owner report, NHTSA ODI #11621332
“The engine coolant pump is affected in my vehicle. There is a current recall issued on my vehicle with no available remedy. The recall was issued back in August, which means it has been 6 months”
— Owner report, NHTSA ODI #11642969

Read all complaints on NHTSA →

Loss of brake power assist during braking

SERVICE BRAKES

7 NHTSA complaints · 2014-09 → 2020-04

“THE SYMPTOMS ARE THE SAME AS THOSE REFERENCED IN RECALL #13V454000& 14V627000 THE BRAKING POWER IS LOST UNEXPECTEDLY RESULTING IN INCREASED VEHICLE STOPPING DISTANCE OR NO BRAKES AS WELL WHEN THE PEDAL GOES ALL THE WAY TO THE FLOOR”
— Owner report, NHTSA ODI #11321701
“WE WERE DRIVING DOWN A 35 MPH RD..I SLOWLY BEGAN TO BRAKE AS WE WERE APPROACHING A STOP LIGHT WHEN THE BRAKES DID NOT HOLD, I HIT THE BRAKE HARDER, THE CAR BEGAN TO BUCK FORWARD, I HIT THE BRAKE AS HARD AS POSSIBLE BUT THE BRAKES FAILED TO HOLD AND ONLY STOPPED WHEN IT HIT THE”
— Owner report, NHTSA ODI #11003415
“I WAS DRIVING MY 2014 BMW 328I XDRIVE, SLOWING FROM ~30MPH INTO AN INTERSECTION FOR A LEFT HAND TURN IN A RESIDENTIAL/SHOPPING AREA. UPON APPLYING THE BRAKES, THE BRAKE PEDAL MOVED BUT THE CAR DIDN'T SLOW”
— Owner report, NHTSA ODI #10778977

Read all complaints on NHTSA →

Timing chain guide failure causing engine damage

ENGINE

8 NHTSA complaints · 2020-02 → 2026-03

“Timing Chain Guide failure after 75k miles resulting in catastrophic engine damage. I was in heavy traffic at 60 mph when the engine began to knock loudly, just as quick the drivetrain malfunction warning came on along with the oil pressure warning light”
— Owner report, NHTSA ODI #11443048
“TOOK CAR IN FOR MAINTENANCE. MECHANIC TOLD ME TIMING CHAIN NEEDED REPLACED AND CAR COULD NOT BE DRIVEN OR IT WILL DESTROY ENGINE. MECHANIC SAID THIS IS A KNOWN ISSUE DUE TO BMW USING INFERIOR PLACTIC FOR TENSIONER”
— Owner report, NHTSA ODI #11309449
“Travelling at 45 mph, engine failed and shut off. Coasted to the side of the road. Towed vehicle on a flatbed to a BMW Dealership. Dealer inspected engine and reported a Timing Chain/Timing Chain Guide failure”
— Owner report, NHTSA ODI #11426001

Read all complaints on NHTSA →

Airbag non-deployment in collision

AIR BAGS

7 NHTSA complaints · 2014-11 → 2025-02

“The contact owns a 2014 BMW 328i. The contact stated that while stopped at a red light, another vehicle crashed into the entire rear at 50 MPH causing the contact's vehicle to spin around twice and come to a stop in the middle of the street. The air bags did not deploy”
— Owner report, NHTSA ODI #11644174
“AIRBAG FAILED TO DEPLOY IN HEAD-ON COLLISION How was your safety or the safety of others put at risk? + DUE TO FAILURE, DRIVER SUSTAINED MILD CONCUSSION WHEN HEAD HIT STEERING WHEEL AND PUT AT RISK OF LIFE THREATENING INJURY AND IMPAIRMENT”
— Owner report, NHTSA ODI #11563737
“2007 TOYOTA HIGHLANDER OBSERVED RUNNING RED LIGHT AND T-BONED THE DRIVER'S SIDE OF A 2014 BMW 328IX. IMPACT OF COLLISION WAS MEANINGFUL AND DIRECT, GENERATING IN EXCESS OF $10,000 OF STRUCTURAL REPAIRS TO DRIVER'S SIDE ALONE. NO AIR BAG DEPLOYMENT (FRONT, SIDE, CURTAIN, ETC)”
— Owner report, NHTSA ODI #10659927

Read all complaints on NHTSA →

Melted rear brake and turn signal wiring connector

ELECTRICAL SYSTEM, EXTERIOR LIGHTING

8 NHTSA complaints · 2018-12 → 2025-08

“For several months, intermittent warnings indicated a malfunction in these lights. On New Years, the warnings ceased to be intermittent, and the lights failed completely”
— Owner report, NHTSA ODI #11684163
“Left rear brake and turn lights malfunctioning -issue not fixed after changing light bulbs. Noticed that metal pins in the connector was melted and stuck into the wiring harness. Problem affects brake light and turn signal”
— Owner report, NHTSA ODI #11477527
“WAS GETTING WARNINGS ABOUT LEFT REAR BRAKE AND TURN LIGHTS MALFUNCTIONING FOR MONTHS THAT WOULD TURN ON AND THEN GO AWAY. ON CHRISTMAS DAY THE BRAKE LIGHT AND TURN LIGHT FOR LEFT REAR CAME ON AND STAYED ON”
— Owner report, NHTSA ODI #11163977

Read all complaints on NHTSA →

Fuel pump failure causing stall

FUEL/PROPULSION SYSTEM

8 NHTSA complaints · 2015-01 → 2025-06

“TL* THE CONTACT OWNS A 2014 BMW 328I. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE LOST ACCELERATION. THE CONTACT ACTIVATED THE HAZARD LIGHTS AND PULLED THE VEHICLE OVER TO THE SHOULDER. ONCE THE VEHICLE WAS TURNED OFF AND RESTARTED, IT RESUMED NORMAL OPERATION”
— Owner report, NHTSA ODI #11254628
“WHILE PROCEEDING AT 50 MPH ON HEAVILY-TRAVELED 2-LANE COUNTRY ROAD, THE ENGINE CUT OUT LEAVING THE CAR WITH NO PROPULSION. I WAS ABLE TO COAST TO THE DRIVEWAY OF A LOCAL FARM AND COME TO A STOP SAFELY OFF THE ROAD”
— Owner report, NHTSA ODI #11093842
“I WAS DRIVING ALONG WITH MY TWIN 6 YEAR OLD DAUGHTERS IN MY 4 MONTH OLD 2014 BMW 328 DRIVE M SPORT WHEN ALL OF A SUDDEN THE CAR STALLED WITH VERY LITTLE TO NO WARNING. THE CAR WAS NOT ABLE TO START”
— Owner report, NHTSA ODI #10669900

Read all complaints on NHTSA →

Note: NHTSA also opened 1 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil Service (CBS)

Every 10,000 mi

Replace BMW Longlife-04 (LL-04) full-synthetic oil and filter every 10,000 miles or annually — whichever the CBS system signals first. M-series engines may require shorter intervals; check the vehicle-specific iDrive screen.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Brake Fluid Service (CBS)

Every 24,000 mi

Replace DOT 4 LV brake fluid every 2 years regardless of mileage. CBS triggers based on time, not miles, due to moisture absorption.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Vehicle Check / Inspection (CBS)

Every 30,000 mi

Multi-point inspection covering brakes, suspension, steering, exhaust, fluids, lighting, and underbody. CBS signals every 30,000 miles or 2 years.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free with any paid service. A flashlight and 10 minutes covers the basics yourself.

Engine Air Filter

Every 40,000 mi

Replace engine air filter every 40,000 miles. Higher-performance N55, B58, and S58 engines should be inspected at every oil service.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Spark Plugs

Every 60,000 mi

B48 (2.0L turbo) and B58 (3.0L turbo) require new spark plugs every 60,000 miles. N20/N55 engines often spec 45,000 miles. M-series typically 30,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Automatic Transmission Fluid (ZF 8HP)

Every 60,000 mi

BMW labels the ZF 8HP automatic as 'lifetime fill,' but independent transmission specialists strongly recommend replacement every 60,000 miles. Use BMW-spec ZF Lifeguard 8 — no substitutes.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Rear Differential Fluid

Every 60,000 mi

RWD and xDrive AWD: replace rear diff fluid every 60,000 miles, sooner with M-Sport or active differential. M-cars require BMW SAF-XO synthetic.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

xDrive Transfer Case Fluid

Every 60,000 mi

BMW xDrive AWD: replace transfer case fluid every 60,000 miles. Skipping this causes the most common xDrive failure — actuator stuck in 100/0 split.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Microfilter (Cabin Air Filter)

Every 30,000 mi

Replace the activated-carbon microfilter every 30,000 miles. Most BMWs have a single combined cabin/charcoal filter behind the engine bay firewall.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Engine Coolant (G48 / HT-12)

On condition / lifetime

BMW labels coolant as lifetime fill on most modern vehicles. Independent BMW specialists recommend replacement every 4-5 years to prevent water-pump and thermostat housing degradation.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

50 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

19

complaints mentioning a crash

2

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2014 Bmw 328i reflects BMW's published service intervals and the Condition-Based Service system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →